Mr. Heater MHBF30LPT - Manuals

Mr. Heater MHBF30LPT – Manual in PDF format online.

Manuals:

Manual

Manual Mr. Heater MHBF30LPT

Summary

Page 2 - Carbon Monoxide Poisoning:; WARNINGS

2 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 This appliance may be installed in an aftermarket* permanently manufactured (mobile) home, where not prohibited bylocal codes.This appliance is only for use with the type of gas indicated on the rating plate. This appliance is notconve...

Page 3 - Figure 1; LOCAL CODES

Installation instructions and Owner’s Manual 3 Product Features Figure 1 SAFETY DEVICE This heater has a pilot with an Oxygen Depletion Sensor(ODS) safety shut off system. The ODS/pilot shuts offthe heater if there is not enough fresh air. IGNITION SYSTEM PIEZO: BF10LP/ IR10LP – The heater is equipp...

Page 4 - VENTILATION AIR; Figure 2

4 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 *Adjoining rooms are communication only if thereare doorless passageways or ventilation grillsbetween them. DETERMINING THE TYPE OF HEATERLOCATION SPACE: Use this method to determine if you have a confined orunconfined space. Note: the...

Page 5 - Ventilation from Outdoors; CAUTION: If you install the heater in a home garage:

Installation instructions and Owner’s Manual 5 Figure 3. Ventilation from Outdoors If necessary provide extra fresh air by using ventilationgrills or ducts. Connect these items directly to theoutdoors or spaces open to the outdoors. Theseinclude attics* and crawl spaces. Follow the NationalFuel Gas ...

Page 6 - Figure 4; FASTENING HEATER TO WALL; Figure 5; Attach to wall studs; Figure 7; For attaching mounting bracket to wall studs

6 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 Figure 4 FASTENING HEATER TO WALL Mounting Bracket The mounting bracket in located on the back panel ofheater (see figure 5). It has been taped there for ship-ping. Remove mounting bracket from back panel. Figure 5 Removing Front Panel...

Page 7 - Fold wall anchor as shown in figure 8 below.; Placing Heater on Mounting Bracket; Mark screws locations on wall.; FLOOR MOUNTING AWAY FROM WALL:

Installation instructions and Owner’s Manual 7 1. Drill holes at marked locations using 5/16” drillbit. For solid walls (concrete or masonry), drillat least 1” deep. 2. Fold wall anchor as shown in figure 8 below. Figure 8. 3. Insert wall anchor (wings first) into hole. Tapanchor flush to wall. 4. F...

Page 8 - CHECKING GAS CONNECTIONS; Correct all leaks at once.

8 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 WARNING: This appliance requires a 3/8” NPT(National Pipe Thread) inlet connection to thepressure regulator. Use of floor mounting feet willrequire you to use a 3/8 NPT street elbow to makegas connection. CAUTION: Never connect heater ...

Page 9 - Pressure Testing Heater Gas Connections:; WHAT TO DO IF YOU SMELL GAS

Installation instructions and Owner’s Manual 9 Pressure Testing Heater Gas Connections: 1. Make sure that the heater supply piping systemis connected and has been leak tested asdescribed above. 2. Make sure control knob of heater is in OFFposition. 3. Open equipment shutoff valve (see figure 13). 4....

Page 10 - C. Use only your hand to push in or turn the gas; LIGHTING INSTRUCTIONS; Check that gas supply to heater is on.; FOR IR10LP: After first burner tile has turned

10 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 C. Use only your hand to push in or turn the gas control knob. Never use tools. It knob will notpush in or turn by hand, don’t try to repair it; calla qualified service technician or gas supplier.Force or attempted repair may result i...

Page 11 - TO TURN OFF GAS TO APPLIANCE

Installation instructions and Owner’s Manual 11 TO TURN OFF GAS TO APPLIANCE SHUTTING OFF HEATER: 1. Turn control knob clockwise to the OFF posi-tion. 2. Turn off all electrical power to the appliance ifservicing is to be preformed. 3. Turn off equipment shutoff valve. SHUTTING OFF BURNER ONLY (PILO...

Page 12 - THERMOSTAT CONTROL OPERATION; Shutting Off Heater; INSPECTING BURNER; BURNER FLAME PATTERN

12 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 8. When the pilot is lit, turn control know counter-clockwise to heating level. The main burnershould light. 9. To select the desired heat level, turn the tem-perature setting knob counterclockwise tobetween 1 & 7. THERMOSTAT CONT...

Page 13 - CLEANING AND MAINTENANCE; CLEANING ODS/PILOT AND BURNER; Inspect burner and pilot for dust and dirt.; CLEANING HEATER CABINET; Air passageways

Installation instructions and Owner’s Manual 13 Figure 24b CLEANING AND MAINTENANCE WARNING: Turn off heater and let cool beforeservicing. CAUTION: You must keep control areas, burner andcirculation air passageways of heater clean. Inspectthese areas of heater before use. Have the heaterinspected ye...

Page 14 - TROUBLESHOOTING; OBSERVED SYMPTOM

14 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 TROUBLESHOOTING NOTE: All troubleshooting items are listed in order of operation and likely occurrence. WARNING: Only a qualified service person should service and repair heater. CAUTION: Never use a wire needle, or similar object to ...

Page 15 - TROUBLESHOOTING CON’T

Installation instructions and Owner’s Manual 15 TROUBLESHOOTING WARNING: If you smell gas: • Shut off gas supply • Do not try to light any appliance • Do not touch any electrical switch; do not use any phone in your building • Immediately call you gas supplier from a neighbor’s phone. Follow the gas...

Page 16 - SPECIFICATIONS

16 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 SPECIFICATIONS IR10 LP IR20LPT IR30LPT BTU (Available) 10,000 20,000 30,000 Type of Gas LP-Gas Only LP-Gas Only LP-Gas Only Ignition Piezo Battery ignitor (1-AA) Battery ignitor (1-AA) Pressure Regulator Setting 10 Inches of Water 10 ...

Page 17 - REPLACEMENT PARTS; PARTS UNDER WARRANTY; Your name; Usually, we will ask you to return the defective part to the factory.; PARTS NOT UNDER WARRANTY; Equipment Shutoff Valve

Installation instructions and Owner’s Manual 17 REPLACEMENT PARTS Note: use only original replacement parts. This will protect you warranty coverage for parts replaced underwarranty. PARTS UNDER WARRANTY Contact authorized dealer from whom you purchased this product. If they are unable to supply ori...

Page 18 - Thermostat models

18 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 Thermostat models MHIR20LPT, MHIR30LPT, MHBF20LPT, MHBF30LPT TSIR20LPT, TSIR30LPT, TSBF20LPT, TSBF30LPT 7 2 20-2 36 39 38 35 16 21 20-1 16-1 16-2 33-2 6 8 26 30 29 17 34 24 3-5 22-3 31-1 31-1 19 13 23 18 10 32 12 3-3 3-1 3-2 3-4 11 1-...

Page 19 - PARTS LIST; ITEM

Installation instructions and Owner’s Manual 19 PARTS LIST Thermostat modelsMHIR20LPT, MHIR30LPT, MHBF20LPT, MHBF30LPTTSIR20LPT, TSIR30LPT, TSBF20LPT, TSBF30LPTThis list contains replacement parts used in your heater. When ordering parts, follow the instructions listedunder Replacement Parts on page...

Page 21 - NON-Thermostat models

Installation instructions and Owner’s Manual 21 NON-Thermostat models MHIR10LP, MHBF10LPTSIR10LP, TSBF10LP 33-1 22-1 1-1 3-1 3-3 3-2 3-6 3-5 26 7 8 23 24 13 1-4 1-2 1-3 6 15 14 42 5 22-3 22-2 20-2 16-2 16-1 16 2 20-1 BF10LP 27-2 16-2 16-1 16 21 20-2 40 38 36 20-1 22-2 35 29-1 4 33-1 22-1 1-4 1-2 1-1...

Page 24 - WARRANTY INFORMATION; Keep this warranty

24 Installation instructions and Owner’s Manual 70575 Rev. C 8/05 WARRANTY INFORMATION Keep this warranty Model ______________________ Serial No. ___________________ Date Purchased _______________ Always specify model and serial numbers when communication with the factory. We reserve the right to am...