Invacare 3752G - Manuals

Invacare 3752G – Manual in PDF format online.

Manuals:

Manual

Manual Invacare 3752G

Summary

Page 4 - General; Symbols and Signal Words; information below for definitions of the signal words.; DANGER

1 GENERAL Invacare® TheraPure™ Recessed Whirlpool Tubs 4 Part No. 1167458 1 General 1.1 Symbols and Signal Words Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. See the information below for definitions of the si...

Page 5 - Limited Warranty; product is serialized, indicate the serial number.

1 GENERAL Part No. 1167458 5 Invacare® TheraPure™ Recessed Whirlpool Tubs 1.2 Limited Warranty This warranty is extended only to the original purchaser/user of our products. This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state. Invacar...

Page 6 - Safety; General Guidelines; WARNING; Grounding is required.; DANGER - RISK OF SCALDING

2 SAFETY Invacare® TheraPure™ Recessed Whirlpool Tubs 6 Part No. 1167458 2 Safety The Safety section contains important information for the safe operation and use of this product. 2.1 General Guidelines 2.2 Important Safety Information  WARNING DO NOT use this product or any available optional equi...

Page 7 - WARNING - FLOOR LOAD CAPACITY; Use this unit only for its intended use as described in this manual.

2 SAFETY Part No. 1167458 7 Invacare® TheraPure™ Recessed Whirlpool Tubs  WARNING - PLUMBING Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes.  WARNING - FLOOR LOAD CAPACITY The installation area MUST be able to support the 66 pounds per square...

Page 8 - Overview; Features

3 OVERVIEW Invacare® TheraPure™ Recessed Whirlpool Tubs 8 Part No. 1167458 3 Overview 3.1 Features Model 3802G Whirlpool ON/OFF Button Fill Button (Push-in once to auto-fill, push-in and hold to add additional water to tub) Water Temperature Thermometer Water Temperature Control Shower/Massage ON/OF...

Page 10 - Product Labeling; Labels located inside the Service Access Door

3 OVERVIEW Invacare® TheraPure™ Recessed Whirlpool Tubs 10 Part No. 1167458 3.2 Product Labeling  Labels located inside the Service Access Door  Label located on Interior Hardware

Page 11 - Typical Product Parameters

3 OVERVIEW Part No. 1167458 11 Invacare® TheraPure™ Recessed Whirlpool Tubs 3.3 Typical Product Parameters 3752G 3802G Weight Tub (shipping weight)Tub (empty)Tub (filled without user)Floor Load Capacity 319 pounds (144 kg)260 pounds (117 kg)796 pounds (361 kg) 66 PSI (45 n/cm²) Minimum Space Require...

Page 12 - Minimum Floor Space and Clearance Requirements

3 OVERVIEW Invacare® TheraPure™ Recessed Whirlpool Tubs 12 Part No. 1167458 3.4 Minimum Floor Space and Clearance Requirements Models 3752G or 3802G 12’ 9’ 5” 2’ 7-1/2” 3752G OR 3802G RECESSED TUB ALLOW FOR A 40” DOOR SWING 4’ 11-1/2” TUB LENGTH 36” HOT AND COLD WATER STUBS,115 VOLT PUMP HOOKUPTHIS ...

Page 13 - Dimensions; /4” Cold water stub with recommended shut off valve

3 OVERVIEW Part No. 1167458 13 Invacare® TheraPure™ Recessed Whirlpool Tubs 3.5 Dimensions Models 3752G or 3802G 59.5” 17” 27” 5-1/2” CL 47” E 18” 31” H 34” C 6-1/2” 36” 41-1/2” D C H 8” E 7” 21” 16” 21” 31-1/2” Allo w fo r a 40 ” d oo r swing C 3/4” Cold water stub with recommended shut off valve D...

Page 14 - Installation; WARNINGS

4 INSTALLATION Invacare® TheraPure™ Recessed Whirlpool Tubs 14 Part No. 1167458 4 Installation  WARNINGS Check all parts for shipping damage. In case of damage, DO NOT use. Contact the carrier for further instruction.The installation area MUST be able to support the 66 pounds per square inch (45 n/...

Page 15 - Preparing the Work Area; Temporarily slide the tub into place.; Three wall installation only; be necessary to modify the pocket to receive the tub.; One wall installation

4 INSTALLATION Part No. 1167458 15 Invacare® TheraPure™ Recessed Whirlpool Tubs 4.1 Preparing the Work Area 1. Carefully remove the tub from the carton and inspect for shipping damage. If damage is found, contact the carrier. 2. Measure the tub. 3. Ensure the floor in the area of installation will b...

Page 16 - Electrical and Plumbing Hook-up Locations; LETTER; Height of 3⁄4-inch Hot Water Stub with Recommended Shut Off Valve; B C

4 INSTALLATION Invacare® TheraPure™ Recessed Whirlpool Tubs 16 Part No. 1167458 4.2 Electrical and Plumbing Hook-up Locations  Refer to Electrical Installation on page 17 and Plumbing Installation on page 18. Model 3752G shown below. A Top View Model 3752G Front View Model 3752G LETTER DESCRIPTION ...

Page 17 - Electrical Installation; DANGERS - ELECTRICAL SHOCK HAZARD; Use a 15 AMP GFCI breaker only.

4 INSTALLATION Part No. 1167458 17 Invacare® TheraPure™ Recessed Whirlpool Tubs 4.3 Electrical Installation Ensure a 15 AMP GFCI breaker is installed to protect the unit. Insert the plug into a pre-installed GFCI protected hospital grade receptacle.  DANGERS - ELECTRICAL SHOCK HAZARD Grounding is r...

Page 18 - Plumbing Installation; Measure the location of the drain on the unit.; The hot water supply to the tub MUST NOT exceed 110°

4 INSTALLATION Invacare® TheraPure™ Recessed Whirlpool Tubs 18 Part No. 1167458 4.4 Plumbing Installation 1. Refer to Electrical and Plumbing Hook-up Locations on page 16 for the location of the hot water stub and cold water stub. 2. Measure the location of the drain on the unit. 3. Install the drai...

Page 19 - Post Installation Checklist; Optional

4 INSTALLATION Part No. 1167458 19 Invacare® TheraPure™ Recessed Whirlpool Tubs 4.5 Post Installation Checklist Before putting the tub into service, check the following: ❑ Water lines have been purged of any foreign matter. ❑ Both hot and cold water lines are properly connected to the tub. ❑ Dedicat...

Page 20 - Operating Instructions; Overview; Whirlpool ON/OFF Button

5 OPERATING INSTRUCTIONS Invacare® TheraPure™ Recessed Whirlpool Tubs 20 Part No. 1167458 5 Operating Instructions 5.1 Overview  WARNINGS Read and understand ALL information in this manual BEFORE use.Clean and disinfect the tub after EACH use to avoid resident infection and contamination of the tub...

Page 21 - Transfer the resident to the tub.; Cleaning and Disinfecting

5 OPERATING INSTRUCTIONS Part No. 1167458 21 Invacare® TheraPure™ Recessed Whirlpool Tubs Perform these procedures in the following order:1. Make sure that the tub has been cleaned, disinfected and BEFORE use. Refer to Cleaning and Disinfecting on page 21. 2. Open the tub door. 3. Transfer the resid...

Page 22 - Use the drain plug to close the drain.; Detail “A”; Jet Casing

5 OPERATING INSTRUCTIONS Invacare® TheraPure™ Recessed Whirlpool Tubs 22 Part No. 1167458 1. Use the drain plug to close the drain. 2. Remove and disassemble all jet assemblies. Lay all pieces in the footwell of the tub.• Rotate each jet assembly counterclockwise and pull away from the jet casing. (...

Page 23 - Replace the impeller and impeller cap on each jet assembly.; Removing Soap Film and Hard Water Deposits

5 OPERATING INSTRUCTIONS Part No. 1167458 23 Invacare® TheraPure™ Recessed Whirlpool Tubs 8. Replace the impeller and impeller cap on each jet assembly. 9. Assemble each jet assembly to the jet casings.• Position the Sanijet® logo and RED indicator at the 11 o’clock position. • Insert the jet assemb...

Page 24 - Removing Calcium Deposits, Scale and Lime Build-up; according to the manufacturer's instructions.

5 OPERATING INSTRUCTIONS Invacare® TheraPure™ Recessed Whirlpool Tubs 24 Part No. 1167458 Removing Calcium Deposits, Scale and Lime Build-up Spray a commercially available cleaner (full strength) for the intended application on all surfaces to be cleaned. Allow the cleaner to remain in contact with ...

Page 25 - Opening/Closing the Tub Door; Place one hand on top of the door handle.; Closing the Tub Door; Push down on the door handle to lock the door into position.

5 OPERATING INSTRUCTIONS Part No. 1167458 25 Invacare® TheraPure™ Recessed Whirlpool Tubs 5.3 Opening/Closing the Tub Door Opening the Tub Door 1. Place one hand on top of the door handle. 2. Use the other hand to pull the safety pin out and release the door handle. 3. Lift up on the door handle and...

Page 26 - Door Handle

5 OPERATING INSTRUCTIONS Invacare® TheraPure™ Recessed Whirlpool Tubs 26 Part No. 1167458 Door Handle Safety Pin Door

Page 27 - Waist Strap; Adjust the straps for comfort as necessary.

5 OPERATING INSTRUCTIONS Part No. 1167458 27 Invacare® TheraPure™ Recessed Whirlpool Tubs 5.4 Waist Strap Installation On each end of the waist strap, insert the lead into the round portion of the slot in the attachment point, slide the lead up and turn it. Use 1. Bring both ends of the waist strap ...

Page 28 - Water Temperature Setting; Water Temperature Control Valve

5 OPERATING INSTRUCTIONS Invacare® TheraPure™ Recessed Whirlpool Tubs 28 Part No. 1167458 5.5 Water Temperature Setting Flow Water Thermometer - measures the temperature of water coming from the tub fill spout or shower/massage wand.Water Temperature Control Valve - sets and maintains constant tempe...

Page 29 - Filling the Tub

5 OPERATING INSTRUCTIONS Part No. 1167458 29 Invacare® TheraPure™ Recessed Whirlpool Tubs 5.6 Filling the Tub 1. Close the drain with the blue stopper. 2. Push the tub fill button to start auto-fill. 3. Use the water temperature control valve to adjust the water temperature while watching the flow w...

Page 30 - Using the Whirlpool Function

5 OPERATING INSTRUCTIONS Invacare® TheraPure™ Recessed Whirlpool Tubs 30 Part No. 1167458 5.8 Using the Whirlpool Function 1. If the water level does not cover the whirlpool jets, push the tub fill button to auto-fill the tub. 2. After the water level covers the whirlpool jets and after bathing the ...

Page 31 - Inspection and Troubleshooting; Safety Inspection Checklists

6 INSPECTION AND TROUBLESHOOTING Part No. 1167458 31 Invacare® TheraPure™ Recessed Whirlpool Tubs 6 Inspection and Troubleshooting If any part of the system is not functioning properly, DO NOT use the system. For parts and technical service information please contact ICCI Technical Service at (800) ...

Page 32 - Troubleshooting; SYMPTOMS

6 INSPECTION AND TROUBLESHOOTING Invacare® TheraPure™ Recessed Whirlpool Tubs 32 Part No. 1167458 6.2 Troubleshooting  If problems are not remedied, contact technical support at 1-800-668-2337, Extension 2. SYMPTOMS FAULTS SOLUTION Hydromassage System System will not start No electrical power to tu...

Page 33 - Maintenance Record; DATE

6 INSPECTION AND TROUBLESHOOTING Part No. 1167458 33 Invacare® TheraPure™ Recessed Whirlpool Tubs 6.3 Maintenance Record \ DATE MAINTENANCE PERSON TYPE OF MAINTENANCE PERFORMED NOTES

Page 34 - Notes

NOTES Invacare® TheraPure™ Recessed Whirlpool Tubs 34 Part No. 1167458 Notes

Page 36 - USA and Canada

Invacare Corporation www.invacare-cc.com USA and Canada One Invacare Way Elyria, Ohio USA 44036-2125 Customer Service 1-800-668-2337 Technical Support 1-800-668-2337, Extension 2 Manufacturing Location 899 Cleveland Street Elyria, Ohio 44036 © 2011 Invacare Corporation. All rights reserved. Republic...