Invacare 3602GXL - Manuals

Invacare 3602GXL – Manual in PDF format online.

Manuals:

Manual

Manual Invacare 3602GXL

Summary

Page 4 - General; Symbols and Signal Words; information below for definitions of the signal words.; DANGER

1 GENERAL Invacare ® TheraPure™ Side Entry Whirlpool Tubs 4 Part No. 1167457 1 General 1.1 Symbols and Signal Words Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. See the information below for definitions of the...

Page 5 - Limited Warranty; product is serialized, indicate the serial number.

1 GENERAL Part No. 1167457 5 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 1.2 Limited Warranty This warranty is extended only to the original purchaser/user of our products. This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state. Inva...

Page 6 - Safety; General Guidelines; WARNING; Grounding is required.; DANGER - RISK OF SCALDING

2 SAFETY Invacare ® TheraPure™ Side Entry Whirlpool Tubs 6 Part No. 1167457 2 Safety The Safety section contains important information for the safe operation and use of this product. 2.1 General Guidelines 2.2 Important Safety Information  WARNING DO NOT use this product or any available optional e...

Page 7 - WARNING - FLOOR LOAD CAPACITY; Use this unit only for its intended use as described in this manual.

2 SAFETY Part No. 1167457 7 Invacare ® TheraPure™ Side Entry Whirlpool Tubs  WARNING - PLUMBING Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes.  WARNING - FLOOR LOAD CAPACITY The installation area MUST be able to support the 66 pounds per squ...

Page 8 - Overview; Features; Whirlpool On/Off Button; push-in and hold to add; Water Temperature Thermometer

3 OVERVIEW Invacare ® TheraPure™ Side Entry Whirlpool Tubs 8 Part No. 1167457 3 Overview 3.1 Features Whirlpool On/Off Button Fill Button (Push-in once to auto-fill, push-in and hold to add additional water to tub) Water Temperature Thermometer Water Temperature Control

Page 10 - Product Labeling; Labels located inside the Cabinet Door

3 OVERVIEW Invacare ® TheraPure™ Side Entry Whirlpool Tubs 10 Part No. 1167457 3.2 Product Labeling Model 3652G Models 3602GXL  Labels located inside the Cabinet Door Cabinet Door  Label located on interior hardware

Page 11 - Typical Product Parameters

3 OVERVIEW Part No. 1167457 11 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 3.3 Typical Product Parameters 3602GXL 3652G Weight Tub (shipping weight)Tub (empty)Tub (filled without user)Floor Load Capacity 324 pounds (147 kg) 274 pounds (124 kg) 380 pounds (172 kg) 66 PSI (45 n/cm²) 313 pounds (14...

Page 12 - Minimum Floor Space and Clearance Requirements; Tub is shown with Model 1900 Traverse lift.

3 OVERVIEW Invacare ® TheraPure™ Side Entry Whirlpool Tubs 12 Part No. 1167457 3.4 Minimum Floor Space and Clearance Requirements Model 3602GXL Tub is shown with Model 1900 Traverse lift. 12’ 80” TO 98” 6” to 24” 40” MIN Allow for a 40” door swing 12’ 9’ 36” MIN MINIMUM TUB CLEARANCE 9” RECOMMENDED ...

Page 14 - Dimensions; Connection

3 OVERVIEW Invacare ® TheraPure™ Side Entry Whirlpool Tubs 14 Part No. 1167457 3.5 Dimensions Model 3602GXL Connection Location Type C 9.5” (241 mm) from left side of tub, 5.5” (140 mm) up from floor 3/4” Cold water stub (with recommended shut off valve) D 16.5” (419 mm) inside of the door 2” Drain ...

Page 16 - Installation; Preparing the Work Area; Determine location for the tub installation.; WARNINGS

4 INSTALLATION Invacare ® TheraPure™ Side Entry Whirlpool Tubs 16 Part No. 1167457 4 Installation 4.1 Preparing the Work Area 1. Determine location for the tub installation. 2. Carefully remove the tub from the carton and inspect for shipping damage. If damage is found, contact the carrier. 3. Remov...

Page 17 - Electrical and Plumbing Hook-up Locations on the Tub

4 INSTALLATION Part No. 1167457 17 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 4.2 Electrical and Plumbing Hook-up Locations on the Tub  For installation details, refer to Refer to Electrical Installation on page 19 and Plumbing Installation on page 20.For dimensions, refer to Dimensions on pag...

Page 18 - Securing the Tub; SECURING LEGS TO FLOOR

4 INSTALLATION Invacare ® TheraPure™ Side Entry Whirlpool Tubs 18 Part No. 1167457 4.3 Securing the Tub 1. Set the tub in place. 2. Ensure the plumbing and electrical hook-ups have been installed. 3. Mark the locations of the anchor holes, using pre-drilled holes in leg mounting pads as a template. ...

Page 19 - Electrical Installation; DANGERS - ELECTRICAL SHOCK HAZARD; Use a 15 AMP GFCI breaker only.

4 INSTALLATION Part No. 1167457 19 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 4.5 Electrical Installation Ensure a 15 AMP GFCI breaker is installed to protect the unit. Insert the plug into a pre-installed GFCI protected hospital grade receptacle.  DANGERS - ELECTRICAL SHOCK HAZARD Grounding i...

Page 20 - Plumbing Installation; Measure the location of the drain on the unit.

4 INSTALLATION Invacare ® TheraPure™ Side Entry Whirlpool Tubs 20 Part No. 1167457 4.6 Plumbing Installation 1. Refer to Electrical and Plumbing Hook-up Locations on the Tub on page 17 for the location of the hot water stub and cold water stub. 2. Measure the location of the drain on the unit. 3. In...

Page 21 - Post Installation Checklist; Optional

4 INSTALLATION Part No. 1167457 21 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 4.7 Post Installation Checklist Before putting the tub into service, check the following: ❑ Water lines have been purged of any foreign matter. ❑ Both hot and cold water lines are properly connected to the tub. ❑ Dedi...

Page 22 - Operating Instructions; Overview

5 OPERATING INSTRUCTIONS Invacare ® TheraPure™ Side Entry Whirlpool Tubs 22 Part No. 1167457 5 Operating Instructions 5.1 Overview  WARNINGS Read and understand ALL information in this manual BEFORE use.Clean and disinfect the tub after EACH use to avoid resident infection and contamination of the ...

Page 23 - Transfer the resident to the tub.; Cleaning and Disinfecting

5 OPERATING INSTRUCTIONS Part No. 1167457 23 Invacare ® TheraPure™ Side Entry Whirlpool Tubs Perform these procedures in the following order:1. Make sure that the tub has been cleaned, disinfected and BEFORE use. Refer to Cleaning and Disinfecting on page 23. 2. Open the tub door. 3. Transfer the re...

Page 24 - Use the drain plug to close the drain.; Detail “A”; Jet Casing

5 OPERATING INSTRUCTIONS Invacare ® TheraPure™ Side Entry Whirlpool Tubs 24 Part No. 1167457 1. Use the drain plug to close the drain. 2. Remove and disassemble all jet assemblies. Lay all pieces in the bottom of the tub.• Rotate each jet assembly counterclockwise and pull away from the jet casing. ...

Page 25 - Removing Soap Film and Hard Water Deposits

5 OPERATING INSTRUCTIONS Part No. 1167457 25 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 8. Replace the impeller and impeller cap on each jet assembly by rotating them counterclockwise. 9. Assemble each jet assembly to the jet casings.• Position the Sanijet® logo and RED indicator at the 11 o’cl...

Page 26 - Opening/Closing the Tub Door; Place one hand on top of the door handle.; Closing the Tub Door; Push down on the door handle to lock the door into position.; Door Handle Safety Pin

5 OPERATING INSTRUCTIONS Invacare ® TheraPure™ Side Entry Whirlpool Tubs 26 Part No. 1167457 5.3 Opening/Closing the Tub Door Opening the Tub Door 1. Place one hand on top of the door handle. 2. Use the other hand to pull the safety pin out and release the door handle. 3. Lift up on the door handle ...

Page 27 - Shoulder and Waist Straps; Adjust the straps for comfort as necessary.

5 OPERATING INSTRUCTIONS Part No. 1167457 27 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 5.4 Shoulder and Waist Straps Installation On each end of the straps, insert the lead into the round portion of the slot in the attachment point, slide the lead up and turn it. Use 1. Pass the right end of t...

Page 28 - Water Temperature Setting; Flow Water

5 OPERATING INSTRUCTIONS Invacare ® TheraPure™ Side Entry Whirlpool Tubs 28 Part No. 1167457 5.5 Water Temperature Setting Flow Water Thermometer - measures the temperature of water coming from the tub fill spout or shower/massage wand.Water Temperature Control Valve - sets and maintains constant te...

Page 29 - Filling the Tub

5 OPERATING INSTRUCTIONS Part No. 1167457 29 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 5.6 Filling the Tub 1. Close the drain with the blue stopper. 2. Push the tub fill button to start the auto tub fill. 3. Use the water temperature control valve to adjust the water temperature while watching...

Page 30 - Using the Whirlpool Function

5 OPERATING INSTRUCTIONS Invacare ® TheraPure™ Side Entry Whirlpool Tubs 30 Part No. 1167457 5.8 Using the Whirlpool Function 1. If the water level does not cover the whirlpool jets, push the tub fill button to auto-fill the tub. 2. After the water level covers the whirlpool jets and after bathing t...

Page 31 - Inspection and Troubleshooting; Safety Inspection Checklists

6 INSPECTION AND TROUBLESHOOTING Part No. 1167457 31 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 6 Inspection and Troubleshooting If any part of the system is not functioning properly, DO NOT use the system. For parts and technical service information please contact ICCI Technical Service at (80...

Page 32 - Troubleshooting; SYMPTOMS

6 INSPECTION AND TROUBLESHOOTING Invacare ® TheraPure™ Side Entry Whirlpool Tubs 32 Part No. 1167457 6.2 Troubleshooting  If problems are not remedied, contact technical support at 1-800-668-2337, Extension 2. SYMPTOMS FAULTS SOLUTION Hydromassage System System will not start No electrical power to...

Page 33 - Maintenance Record; DATE

6 INSPECTION AND TROUBLESHOOTING Part No. 1167457 33 Invacare ® TheraPure™ Side Entry Whirlpool Tubs 6.3 Maintenance Record DATE MAINTENANCE PERSON TYPE OF MAINTENANCE PERFORMED NOTES

Page 36 - USA

Invacare Corporation www.invacare-cc.com USA One Invacare Way Elyria, Ohio USA 44036-2125 Canada 994 Hargrieve Road London, Ontario Canada N6E IP5 Customer Service 1-800-668-2337 Technical Support 1-800-668-2337, Extension 2 Manufacturing Location 899 Cleveland Street Elyria, Ohio 44036 © 2011 Invac...