Graham Field lf 1031 - Manuals

Graham Field lf 1031 – Manual in PDF format online.

Manuals:

Manual

Manual Graham Field lf 1031

Summary

Page 2 - and; Lumex; are registered trademarks of GF Health Products, Inc.; CONTENTS

LF1031-INS-LAB-RevD12 2 GF Health Products, Inc. is not responsible for typographical errors.For the most updated and current information on packaging, warranties, products and specifications, including the most current version of this manual, please visit our website at www.grahamfield.com. Graham-...

Page 3 - INTRODUCTION; could result in death or serious personal injur y.

LF1031-INS-LAB-RevD12 3 1 INTRODUCTION Congratulations on your purchase of a Lumex patient lift. The following pages will provide you with important safety and operating instructions on the use of patient lifts, slings, and accessories, as well as maintenance and warranty information. Read this manu...

Page 4 - SAFETY PRECAUTIONS; CARE AND MAINTENANCE; WARNINGS; instructions prior to lifting anyone.

LF1031-INS-LAB-RevD12 4 2 SAFETY PRECAUTIONS IMPORTANT: Before using patient lift, please read and adhere to the following safety precautions and warnings. Failure to do so could result in serious personal injury or damage to your patient lift.Always consult your healthcare professional to determine...

Page 6 - FEATURES

LF1031-INS-LAB-RevD12 6 3 FEATURES LF1041 Battery Powered Patient Lift Battery (LF1041 only ) Control box (LF1041 only ) Battery charger (LF1041 only ) Actuator (LF1041 only ) Mast Push handle 6-point spreader bar (suspension) Hydraulic pump (LF1031 Hydraulic Patient Lift only ) See above left for L...

Page 7 - HANDLING PROCEDURES; SHIPPING AND TRANSPORTATION INSTRUCTIONS; Unpacking; carrier or your authorized Lumex Dealer.; Inspection

LF1031-INS-LAB-RevD12 7 4 HANDLING PROCEDURES SHIPPING AND TRANSPORTATION INSTRUCTIONS If the patient lift is to be reshipped by common carrier, it should be packed in the same carton/s in which it was received (the LF1031 is shipped in one carton; the LF1041 motor may be packaged separately from th...

Page 8 - ASSEMBLY INSTRUCTIONS; COMPONENTS; LF1031 Hydraulic Patient Lift components

LF1031-INS-LAB-RevD12 8 5 ASSEMBLY INSTRUCTIONS The LF1031 patient lift is packed in one carton. The LF1041 motor may be in a separate carton. Components are shown in illustration below and called out in list below illustration. COMPONENTS LF1031 Hydraulic Patient Lift components LF1041 * 1 3 2 4 7 ...

Page 9 - ASSEMBLY; Base and mast assembly; Remove the locking pin from the mast sleeve located on the rear of

LF1031-INS-LAB-RevD12 9 ASSEMBLY Base and mast assembly 1. Remove the locking pin from the mast sleeve located on the rear of the base. 2. Install the L-inserts in the base. 3. With the boom pointed in the same direction as the base legs, insert the mast into the sleeve. 4. Insert the locking pin th...

Page 12 - LF1041 only: electrical power connections

LF1031-INS-LAB-RevD12 12 LF1041 only: electrical power connections The control box is the heart of the electrical system.The battery charger and battery are plugged into the control box via built-in stacking connectors, depending on battery charger options.The hand control pendant and actuator / mot...

Page 13 - The LF1041 lift is now ready for use.; Charging the battery with wall-mounted batter y charger:; Remove the battery from its bracket; control box power switch; must be turned

LF1031-INS-LAB-RevD12 13 LF1041 only: charging the batter y The battery used on the LF1041 has an audible alarm that sounds when the battery charge has been depleted by 50%. Charge the battery as soon as possible upon hearing this alarm.There is also a light on the hand control pendant that illumina...

Page 14 - OPERATING INSTRUCTIONS; LF1041 ONLY: EMERGENCY PROCEDURES; The control box is equipped with a red; The motor is equipped with an; emergency release; , which is located on top of the motor; WARNING: Use caution when using the emergency

LF1031-INS-LAB-RevD12 14 6 OPERATING INSTRUCTIONS LF1041 ONLY: EMERGENCY PROCEDURES Emergency stop: The control box is equipped with a red emergency stop button . This button, also known as the control box power switch, is to be used in the event the hand control pendant ceases to function correctly...

Page 15 - LIFT OPERATION: PATIENT TRANSFER; weight capacity of the selected sling.; Lifting the patient from a bed; must be locked in the maximum open position.; Lowering the patient onto a bed

LF1031-INS-LAB-RevD12 15 LIFT OPERATION: PATIENT TRANSFER WARNING: Do not attempt to transfer a patient without prior approval of the patient’s healthcare professional and without having read the instructions and practiced using the patient lift. WARNING: Use special care for those patients who cann...

Page 16 - Reverse the above procedures to lower.

LF1031-INS-LAB-RevD12 16 2. Center the patient over the bed, and rotate the patient to face the foot section of the bed. SLOWLY release the pressure knob by turning it counter-clockwise for gradual lowering of the patient (LF1031) or using the hand control pendant (LF1041). Carefully lower the patie...

Page 17 - Removing the sling; locks in locked position.

LF1031-INS-LAB-RevD12 17 Removing the sling Gently pull the leg sections to the side, out from under the patient’s thighs. Standing by the patient’s side, lean the patient forward while supporting the patient with one hand. Pull the sling up from behind the patient’s back and position the patient in...

Page 18 - CARE AND MAINTENANCE; BEFORE EACH USE; The electronic components operate properly (LF1041 only); BATTERY; The point where actuator / motor and boom connect (LF1041 only)

LF1031-INS-LAB-RevD12 18 7 CARE AND MAINTENANCE Proper care and maintenance are essential to keeping your Lumex patient lift in a safe operating condition. In addition to inspecting the unit before each use, periodic maintenance checks should be done. We further recommend that this unit be serviced ...

Page 19 - CLEANING; NOTICE: DO NOT wash under water pressure or steam clean.; CHECKING FOR DAMAGE AND WEAR

LF1031-INS-LAB-RevD12 19 CLEANING Regular cleaning is recommended. A soft cloth, dampened with water and a mild NON-ABRASIVE detergent (household cleaner, soapy water, or hospital grade disinfectant) is all that is needed to clean your patient lift. Automobile wax or furniture polish will help maint...

Page 20 - Removal of Existing Pump; installing pump for the first time, proceed to; Installation of new pump; Use two

LF1031-INS-LAB-RevD12 20 LF1031 ONLY: INSTALLATION OF 1010S005 HYDRAULIC PUMP Removal of Existing Pump lower mast bracket upper boom bracket boom mast existing pump existing pump detach existing pump from upper boom detach existing pump from lower mast 1. Follow the instructions in this section to r...

Page 21 - Installation of New Pump; FRONT; wrenches to tighten.

LF1031-INS-LAB-RevD12 21 Installation of New Pump Tools needed: two 9 / 16 " wrenches Info: The hardware to attach the Hydraulic Pump (GF #1010S005) to the LF1031 mast and boom comes with the lift frame. mast attach new pump to lower mast detail — attach new pump to lower mast boom upper boom br...

Page 22 - MAINTENANCE SCHEDULE

LF1031-INS-LAB-RevD12 22 MAINTENANCE SCHEDULE Info: Only qualified persons should service and repair your Lumex patient lift. Regular maintenance of your patient lift is necessar y to ensure continuing proper and safe operation. Read and observe the following recommended maintenance schedule: Item I...

Page 23 - TROUBLESHOOTING; LF1031 HYDRAULIC PATIENT LIFT

LF1031-INS-LAB-RevD12 23 8 TROUBLESHOOTING WARNING: If you experience a problem with your lift and are unable to ser vice it yourself, contact your Lumex dealer. LF1031 HYDRAULIC PATIENT LIFT SYMPTOM POSSIBLE CAUSE ACTION Patient lift does not go up or down Air in the cylinder Bleed the cylinder by ...

Page 24 - SPECIFICATIONS

LF1031-INS-LAB-RevD12 24 9 SPECIFICATIONS Info: All dimensions are given in inches unless otherwise specified. LF1031 HYDRAULIC PATIENT LIFT / LF1041 BATTERY POWERED PATIENT LIFT Base width Open: 39.4"Closed: 25.6" Base height clearance 5-1/2" Base length 45.30" Lifting height range ...

Page 25 - 0 LIMITED WARRANTY; GF Health Products Inc.

LF1031-INS-LAB-RevD12 25 10 LIMITED WARRANTY GF Health Products Inc. warrants this product to be free from manufacturing defects in material and workmanship for its period of warranty that is in accordance with industry standards. This warranty is extended only to the original purchaser/consumer or ...

Page 28 - Made in Taiwan

GF Health Products, Inc. 2935 Northeast Parkway Atlanta, Georgia 30360 USA tel: 770-368-4700 www.grahamfield.com Made in Taiwan