Page 2 - L I M I T E D W A R R A N T Y; ONE YEAR FROM DATE OF PURCHASE; THIS WARRANTY DOES NOT COVER:; Authorized Warranty; FROM ANY DEFECT, FAILURE OR MALFUNCTION OF THE PRODUCT.; Some states do not allow the; PURPOSE, ARE LIMITED TO ONE YEAR FROM THE DATE OF ORIGINAL PURCHASE.; Some states do not
2 L I M I T E D W A R R A N T Y ONE YEAR FROM DATE OF PURCHASE All merchandise manufactured by DeVilbiss Air Power Company/ExCell Manufacturing is warranted to be free of defects in workmanship and material which occur during the first year from the date of purchase by the original purchaser (initia...
Page 3 - AIR TANK; HAZARD; • SAVE THESE INSTRUCTIONS •; IMPORTANT SAFETY INSTRUCTIONS
3 RISK OF BURSTING RISK OF EXPLOSION OR FIRE RISK OF ELECTRICAL SHOCK AIR TANK THE FOLLOWING CONDITIONS COULD LEAD TO A WEAKENING OF THE TANK, AND RESULT IN A VIOLENT TANK EXPLOSION: 1. FAILURE TO PROPERLY DRAIN CONDENSED WATER FROM THE TANK, CAUSING RUST AND THINNING OF THESTEEL TANK. 2. MODIFICATI...
Page 5 - Motor Thermal Overload Protector:
5 GLOSSARY CFM: Cubic feet per minute. SCFM: Standard cubic feet per minute; a unit of measure of air delivery. PSIG: Pounds per square inch gauge; a unit of measure of pressure. ASME: American Society of Mechanical Engineers; made, tested, inspected and registered to meet the standards ofASME. U.L....
Page 6 - ASSEMBLY INSTRUCTIONS; Items Needed for Assembly; NOTE; Installing Handle
6 DESCRIPTION OF OPERATION (cont'd) Outlet Pressure Gauge: The outlet pressure gauge indi- cates the air pressure available at the outlet side of theregulator. This pressure is controlled by the regulator and isalways less or equal to the tank pressure. See “OperatingProcedures”. Tank Pressure Gauge...
Page 7 - Voltage and Circuit Protection; . Extension cords comply with specifications; must; • use only a 3-wire extension cord that has a 3-blade ground-; Lubrication and Oil; Crankcase oil capacity is 16; GROUNDING INSTRUCTIONS; DO NOT USE AN ADAPTER.; Inspect the plug and cord before each use. Do not use if
7 Voltage and Circuit Protection Refer to your Parts Manual for voltage and circuit protectionrequirements of your compressor. Use only a fuse or circuitbreaker that is the same rating as the branch circuit the aircompressor is operated on. If the compressor is connected toa circuit protected by fus...
Page 8 - Piping; This procedure is required:; OPERATING PROCEDURES; Daily Start-Up Checklist
8 4. Clean or blow off fins or any part of compressor that collects dust and dirt. Compressor will run cooler andprovide longer service. 5. Before attaching an air hose or accessory make sure the pressure switch lever is in the "OFF" position.Close the air regulator outlet by turning it coun...
Page 9 - MAINTENANCE; Routine Maintenance Schedule; Every 40 Hours of Operation:; SERVICE INSTRUCTIONS; Air Filter - Inspection and Replacement
9 MAINTENANCE UNIT CYCLES AUTOMATICALLY WHEN POWERIS ON. DURING MAINTENANCE, YOU COULD BEEXPOSED TO VOLTAGE SOURCES, COM-PRESSED AIR OR MOVING PARTS. PERSONALINJURIES CAN OCCUR. UNPLUG THE UNIT ANDBLEED OFF ALL AIR TANK PRESSURE BEFOREDOING ANY MAINTENANCE OR REPAIR. NEVEROPERATE THE UNIT WITH THE B...
Page 11 - TROUBLESHOOTING GUIDE; PROBLEM
11 TROUBLESHOOTING GUIDE PERFORMING REPAIRS MAY EXPOSE VOLTAGE SOURCES, MOVING PARTS OR COMPRESSED AIR SOURCES.PERSONAL INJURY MAY OCCUR. PRIOR TO ATTEMPTING ANY REPAIRS, UNPLUG THE COMPRESSOR AND BLEEDOFF ALL TANK AIR PRESSURE. PROBLEM Excessive tank pressure - safety valvepops off. Air leaks at fi...
Page 12 - Bleed
12 TROUBLESHOOTING GUIDE (CONT'D) PROBLEM Knocking noise Motor will not run. CAUSE Restricted or defective check valve.Loose pulley.Low oil level.Loose flywheel.Loose compressor mounting screws. Loose belt. Belt too tight. Carbon build-up. Motor overload protection switch hastripped. Possible defect...
Page 13 - Restricted air intake.; CAUSE; Restricted air intake filter.; CORRECTION
13 TROUBLESHOOTING GUIDE (CONT'D) PROBLEM Restricted air intake. Compressor is not supplying enough airto operate accessories. Excessive belt wear. Squealing sound. Pressure reading on the regulated pres-sure gauge drops when an accessory isused. Regulator knob - continuous air leak.Regulator will n...
Page 14 - SERVICE NOTES