Brinkmann 816-3500 SERIES - Manuals

Page 2 - DANGER; which could cause property damage, personal injury or death.; WARNING; Never store a spare LP gas cylinder under or near this fryer.; DANGER; CARBON MONOXIDE HAZARD

1. Never operate this appliance unattended.2. Never operate this appliance within 10 feet (3m) of any other gas cylinder.3. Never operate this appliance within 25 feet (7.5m) of any flammable liquid.4. Do not fill cooking vessel beyond maximum fill line.5. When cooking with oil/grease, never allow t...

Page 3 - or any other enclosed area.

2 WARNING • For OUTDOOR use only. Do NOT use in a building, home, garage, balcony, porch, tent or any other enclosed area. • Smoking oil is an indication that the oil is too hot and may ignite. Oil ignites at varying temperatures; therefore, never allow the oil to exceed 400°F (200°C) and NEVER LEAV...

Page 5 - LP GAS CYLINDER; DO NOT connect to a propane cylinder exceeding this capacity.; CYLINDER SPECIFICATIONS:

4 WARNING LP GAS CYLINDER (NOT SUPPLIED WITH THIS FRYER) The LP (Liquid Propane) gas cylinder specifically designed to be used with this fryer must havea 20 lb. (9.1 kg) capacity incorporating a Type 1 cylinder valve and an over-filling protectiondevice (OPD). • DO NOT connect this fryer to an exist...

Page 6 - FILLING THE LP GAS CYLINDER:

5 • Turn off the cylinder valve when your fryer is not in use. • Handle the tank with care. • Always secure the cylinder in an upright position. • Never connect an unregulated LP gas cylinder to your fryer. • DO NOT expose LP gas cylinders to excessive heat or ignition sources. • DO NOT store a spar...

Page 7 - NOTE

HOSE AND REGULATOR: Your fryer is equipped with a Type 1 connection device withthe following features: 1. The system will not allow gas flow from the cylinder until a positive connection to the valve has been made. NOTE : The cylinder valve must be turned off before any connection is made or removed...

Page 8 - CONNECTING HOSE AND REGULATOR TO AN LP GAS CYLINDER; WHEN TO PERFORM A LEAK TEST:; Any time your fryer has been moved.

WARNING DANGER 7 CONNECTING HOSE AND REGULATOR TO AN LP GAS CYLINDER • Insure the cylinder valve is CLOSED prior to connecting the LP gas cylinder to your fryer. Turnthe regulator control knob clockwise to properly close the valve. Read and follow allinstructions and warnings on the supply hose safe...

Page 10 - LIGHTING INSTRUCTIONS:; Follow the instructions exactly.

9 PRE-START CHECK LIST: Property damage, bodily harm, severe burns, and death could result from failure to follow thesesafety steps. These steps should be performed after the fryer has been assembled, stored, moved,cleaned, or repaired. DO NOT operate this fryer until you have read and understand AL...

Page 11 - DO NOT; HOW TO REIGNITE BURNER:

4. Insert paper match in match holder prior to striking. Strike and place match through lighting hole to approximately 1/2" (2 to 3 cm) from the burner. We recommend the use of a long wooden match. 5. Slowly turn regulator control knob clockwise until burner lights. 6. If burner does NOT ignite ...

Page 12 - OPERATING INSTRUCTIONS; HOW TO DETERMINE PROPER AMOUNT OF OIL

11 OPERATING INSTRUCTIONS Read, understand and follow all warnings and instructions contained in this manual. DO NOT skipany of the warnings and instructions contained in the preceding sections of this manual. • Never leave heating oil unattended - it can ignite. • Smoking oil is an indication that ...

Page 13 - SLOWLY; from boiling pot to allow hot liquid to drain. Lifting; Basket

12 Step 2: Place pot with oil on fryer. Make sure thermometer is clipped to side of pot. Do not use lid when heatingor cooking with oil. Bring liquid to the desired cooking temperature (325°-350°F for frying) approximately20-30 minutes. Never leave heating oil unattended. It can ignite. Carefully mo...

Page 14 - BURNER ASSEMBLY/MAINTENANCE; Burner tube can become; NOTE: Wear eye protection when cleaning burner.; CLEANING & GENERAL MAINTENANCE; Check and tighten any loose hardware at least every 6 months.

BURNER ASSEMBLY/MAINTENANCE • Keep appliance area clear and free from combustible materials, gasoline and other flammable vaporsand liquids. • Although your burner is constructed of cast iron, it may rust as a result of the extreme heat andacids from cooking foods. Regularly inspect the burner for c...

Page 15 - ASSEMBLY INSTRUCTIONS; READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY; Turkey Fryer Gas Cooker

ASSEMBLY INSTRUCTIONS READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR FRYER. Inspect contents of the box to ensure all parts are included and undamaged. FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 1-800-527-0717. (Proof of purchase will be re...

Page 16 - ONE YEAR LIMITED WARRANTY

©2003 The Brinkmann Corporation Dallas, Texas 75244 U.S.A www.brinkmanncorp.com 140-3530-07/03, 1/04 For one year from date of purchase, The Brinkmann Corporation warrants the Cooker against defects due to workmanship or materialsto the original purchaser. The Brinkmann Corporation’s obligations und...