Baldor DG3E - Manuals

Baldor DG3E – Manual in PDF format online.

Manuals:

Manual

Manual Baldor DG3E

Summary

Page 3 - Table of Contents

Table of Contents Table of Contents i MN2414 Section 1 Product Safety Information 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safety Notice 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . ...

Page 4 - ii Table of Contents

Page 5 - Safety Notice

Section 1 Product Safety Information Product Safety Information 1-1 MN2414 Safety Notice Be sure that you are completely familiar with the safe operation of this equipment. This equipment may be connected to other machines that have rotating parts or parts that are controlled by this equipment. Impr...

Page 7 - Product Safety Information 1-3; Operation Warning Statements; Continued; loose clothing or extremities and cause serious or fatal injury.; Continued on next page.

Product Safety Information 1-3 MN2414 Operation Warning Statements Continued WARNING: Be sure that you understand how to stop the engine quickly in case of an emergency situation. Become familiar with the controls and safety systems provided with this generator set. WARNING: Always wear safety glass...

Page 10 - -6 Product Safety Information

1-6 Product Safety Information MN2414 Caution Statements Caution: The brass connecting tab on some 120VAC duplex receptacles have been removed. Each receptacle is powered by a separate generator winding. When replacing a receptacle, inspect the brass tab that normally links both receptacles. If it i...

Page 11 - General Information 2-1; Limited Warranty; Warranty Period; Generator Series

Section 2 General Information General Information 2-1 MN2414 Thank you for purchasing your Baldor Generator Set. This manual contains information you need to safely and efficiently install and operate your generator set. During the preparation of this manual every effort was made to ensure the accur...

Page 12 - -2 General Information

Page 13 - Receiving & Inspection; Figure 3-1 DG Series Generators

Section 3 Receiving & Installation Receiving & Installation 3-1 MN2414 Receiving & Inspection When you receive your generator, there are several things you should do immediately. 1. Observe the condition of the shipping container and report any damage immediately to the commercial carrie...

Page 14 - Physical Location; necessary repaired or reinstalled in a well ventilated area.

3-2 Receiving & Installation MN2414 Physical Location The mounting location of the system is important. It should be installed in an area that is protected from direct harmful gases or liquids, dust, metallic particles, shock and vibration. It can only be installed in an outdoor location so the ...

Page 15 - Electrical Connections; Table 3-1 Single Phase Power Receptacle Description; Note: GFCI is Ground Fault Protected power.; Figure 3-2 Receptacle Connections; earth at least 8 feet.

Receiving & Installation 3-3 MN2414 Electrical Connections Continued Table 3-1 Single Phase Power Receptacle Description Model Electrical Connection Information (Receptacle Provided at Panel) Straight 120VAC (20Amp) Twist Lock 120VAC (30Amp) Twist Lock 120/240VAC (30Amp) Twist Lock 120/240VAC (5...

Page 18 - Optional Wheel Kit; PDG2; Interstate SP−40

3-6 Receiving & Installation MN2414 Optional Wheel Kit PDG2 − 2 Wheel Dolly Kit; and PDG4 − 4 Wheel Dolly Kit An optional 2 or 4 wheel dolly kit is available for these portable generators. If you have purchased one of these kits, refer to MN2409 for the installation instructions. Recommended Eng...

Page 21 - Maintenance

Section 5 Troubleshooting and Maintenance Troubleshooting and Maintenance 5-1 MN2414 Maintenance This manual contains only very minimal engine maintenance instructions. Refer to the engine manufacturer’s owner’s manual for specific engine maintenance instructions for your generator set. Any maintena...

Page 22 - -2 Troubleshooting and Maintenance; Problems and Solutions; Problem; Service; Parts; information available prior to contacting the factory:

5-2 Troubleshooting and Maintenance MN2414 Problems and Solutions Some of the more common problems are listed in Table 5-1. This information is intended to be a check or verification that simple causes can be located and fixed. It is not an exhaustive “how to” for all types of problems. Procedures t...

Page 23 - Operator Panel Configuration; OIL; Figure A-2 DG6E Operator Panel; AC Circuit Breakers.

Appendix A DG Series Premier K Series A-1 MN2414 Information in this Appendix applies to the following Baldor Generators: DG3E and DG6E. Caution: The brass connecting tab on some 120VAC duplex receptacles have been removed. Each receptacle is powered by a separate generator winding. When replacing a...

Page 24 - Replacement Parts; replacement parts information.; Figure A-3 Alternator Assembly; Figure A-4 Frame Assembly

A-2 Premier K Series MN2414 Replacement Parts Replacement parts assembly views for the Generator set are shown in Figure A-3 and A-4. Parts information is provided in Table A-1. Parts information for the engine is provided in the engine manual that was provided with your generator set. Please refer ...

Page 25 - Table A-1 Generator Set Parts List; Wiring Diagrams

Premier K Series A-3 MN2414 Table A-1 Generator Set Parts List Continued Ref No. Part No. Description DG3E DG6E Not Shown EH0316A00 Control Box (Operator Panel) X Not Shown EH0332A00 Control Panel Cover (Operator Panel) X Not Shown EH0434A00L2B Control Box (Operator Panel) X Not Shown EH0435A00L2B C...

Page 26 - Figure A-5 DG3E Wiring Diagram

A-4 Premier K Series MN2414 Figure A-5 DG3E Wiring Diagram

Page 27 - Figure A-6 DG3E Wiring Diagram with Low Oil & Remote Start

Premier K Series A-5 MN2414 Figure A-6 DG3E Wiring Diagram with Low Oil & Remote Start

Page 28 - Figure A-7 DG6E Wiring Diagram

A-6 Premier K Series MN2414 Figure A-7 DG6E Wiring Diagram

Page 29 - Baldor District Offices

Baldor District Offices UNITED STATES ARIZONA PHOENIX4211 S 43RD PLACEPHOENIX, AZ 85040PHONE: 602−470−0407FAX: 602−470−0464 CALIFORNIA LOS ANGELES6480 FLOTILLACOMMERCE, CA 90040PHONE: 323−724−6771FAX: 323−721−5859 HAYWARD21056 FORBES STREETHAYWARD, CA 94545PHONE: 510−785−9900FAX: 510−785−9910 COLORA...

Page 30 - BALDOR ELECTRIC COMPANY

© Baldor Electric Company MN2414 Printed in USA 5/05 WARNING: CALIFORNIA PROPOSITION 65 WARNING: Engine exhaust from this product contains chemicals known to the state of California to cause cancer, birth defects and other reproductive harm. WARNING: CALIFORNIA PROPOSITION 65 WARNING: Battery posts,...