Alto-Shaam 2020 - Manuals

Alto-Shaam 2020 – Manual in PDF format online.

Manuals:

Manual

Manual Alto-Shaam 2020

Summary

Page 3 - d e l i v e r y; c a u t i o n; TO PREVENT PERSONAL INJURY,

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 1 . d e l i v e r y This alto-shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. see...

Page 4 - This appliance is intended to cook, hold; n o t e

c a u t i o n Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. c a u t i o n Used to indicate the presence of a hazard that can or will cause minor or moderate ...

Page 5 - i n s t a l l a t i o n; d a n g e r; d a n g e r; s i t e i n s t a l l a t i o n

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 3 . s i t e i n s t a l l a t i o n i n s t a l l a t i o n d a n g e r IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE.READ THE INSTALLATION, OPERATING AND MA...

Page 6 - positioning on site; Additional clearance is needed for; To avoid equipment damage, observe

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 4 . n o t e : note dimensions required for doorways and aisles for access of the oven and pallet to the installation site. Transport the oven in an upright and level position only. do not tilt the oven. ® s i t e i n s t a l l a t i o n i n s t ...

Page 7 - Lifting Instructions; Do not lift in

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 5 . s i t e i n s t a l l a t i o n i n s t a l l a t i o n Lifting Instructions Do not lift in this area! Damage to the components will result. Center of Gravity Front View Top View (Front) Leg 24” Spacer Board Remove banding before lifting. Pl...

Page 8 - positioning requirements

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 6 . s i t e i n s t a l l a t i o n i n s t a l l a t i o n positioning requirements q in order to ensure proper ventilation, a minimum distance of at least 6-inches (152mm) must be kept from the control panels side (left) of the oven and any ad...

Page 9 - c o m m o n s p e c i f i c a t i o n s; combiguardTM Bws Blended water system; shelf, stainless steel wire; Tablets —; scale FreeTM

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 7 . c o m m o n s p e c i f i c a t i o n s combiguard™ Bws Blended water system ( iNcludEs 50 gallON taNk , 1 MEMbraNE & 3 FiltErs ) Fi-28727 combiguard™ Bws replacement Filter cartridge aMs-QT Fi-29316 combiguard™ Bws replacement Filter ca...

Page 12 - iN

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 10. 6•10 es iN 32-15/16" (835mm) 35-9/16" (903mm) 21-11/16" (550mm) 5-3/8" (137mm) 6-3/8" (161mm) WATERDRAIN 33-7/8" (859mm) 35-13/16" (909mm) 2" (50mm) 41-1/16" (1042mm) Water Drain (Side Back) Steam Vent(Top...

Page 14 - *electrical service charge applies

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 12 . 10•10 es i 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31-3/8"...

Page 24 - e l e c t r i c a l c o n n e c t i o n; an electrical wiring diagram is located behind; note; ce approved appliances must be

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 22 . e l e c t r i c a l c o n n e c t i o n i n s t a l l a t i o n d a n g e r ENSURE POWER SOURCE MATCHES VOLTAGE IDENTIFIED ON APPLIANCE RATING TAG. d a n g e r To avoid electrical shock, this appliance MUST be adequately grounded in accorda...

Page 25 - FINAL ASM, TOUCH SCREEN; Terminal Block

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 23 . e l e c t r i c a l c o n n e c t i o n i n s t a l l a t i o n d a n g e r ELECTRICAL CONNECTIONS MUST BE MADE BY A QUALIFIED SERVICE TECHNICIAN IN ACCORDANCE WITH APPLICABLE ELECTRICAL CODES. FINAL ASM, TOUCH SCREEN COMBICLEAN 5011685 Ter...

Page 26 - m o b i l e e q u i p m e n t r e s t r a i n t; Two of the casters must be the locking type.; w a r n i n g; risk of electric shock.; Appliance must be secured

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 24 . m o b i l e e q u i p m e n t r e s t r a i n t i n s t a l l a t i o n any appliance that is not furnished with a power supply cord but includes a set of casters must be installed with a tether. adequate means must be provided to limit the...

Page 27 - w a t e r q u a l i t y r e q u i r e m e n t; warning; use a drinking quality, cold water supply only; ALTO-SHAAM COMBITHERM WATER QUALITY MINIMUM STANDARDS; USE A DRINKING QUALITY, COLD WATER SUPPLY ONLY

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 25 . i n s t a l l a t i o n w a t e r q u a l i t y r e q u i r e m e n t warning tO pREVENt WAtER pIpES OR HOSES FROM buRStING, INCOMING WAtER SuppLy SHOuLd bE tuRNEd OFF WHEN tHE AppLIANCE IS NOt IN uSE. warning WAtER SuppLy MuSt bE OpEN WHEN...

Page 28 - w a t e r c o n n e c t i o n s; water supply & installation; one suggested

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 26 . i n s t a l l a t i o n w a t e r c o n n e c t i o n s water supply & installation water requirements two (2) cold water inlets - drinking quality one (1) treated water inlet: 3/4" npT* one (1) untreated water inlet: 3/4" npT* ...

Page 29 - w a t e r v a l v e

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 27 . i n s t a l l a t i o n w a t e r v a l v e w a t e r d r a i n a g e s h u t - o f f v a l v e s h o w n i n t h e o f f p o s i t i o n note: the shut-oFF valve must be in the oPen Positionwhen the oven is being used. The oven must discha...

Page 30 - g r e a s e c o l l e c t i o n h o o k - u p

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 28 . g r e a s e c o l l e c t i o n h o o k - u p ( I F E Q U I P P E D W I T H T H I S F E A T U R E ) • grease collection hose assembly is attached to the oven in the back. • place grease collection containers inside the tray of the Mobile gr...

Page 31 - c o m b i t o u c h ® c h e c k l i s t; Use this list as a final check of oven installation conformance.; C L E A R A N C E S :; C O N t R O L b O A R d C O N N E C t I O N S & O p E R A t I O N :; p H y S I C A L C O N d I t I O N : *

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 29 . i n s t a l l a t i o n c o m b i t o u c h ® c h e c k l i s t Use this list as a final check of oven installation conformance. Damage directly attributed to improper set up, installation, or cleaning can invalidate warranty claims. C L E ...

Page 32 - error codes; unit is not operating properly, check the; PRESS THE START ICON TO ACKNOWLEDGE THE ERROR.

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 30. i n s t a l l a t i o n cONTINUed ON NexT pAge error codes this section is provided for the assistance of qualified technicians only and is not intended for use by untrained or unauthorized service personnel. if your alto-shaam ® unit is not...

Page 34 - see motor control error code list

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 32 . i n s t a l l a t i o n error codes error code error call out in display description of error possible cause e34 Steam Generator Drain Pump Fault Water level in steam generator does not drop during cleaning program — Scale build up inside t...

Page 36 - type of error; combitouch motor control error codes

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 34 . i n s t a l l a t i o n type of error indication release of error Undervoltage LED fl ashing sequence, with 1 fl ash per period. Voltage of intermediate circuit is less than 250V Overvoltage LED fl ashing sequence, with 2 fl ashes per perio...

Page 38 - v e n t l e s s h o o d o p t i o n; c o n d e n s a t e d r a i n

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 36 . i n s t a l l a t i o n v e n t l e s s h o o d o p t i o n The Ventless hood option is factory installed directly on the top of the alto-shaam combitherm oven. The hood is designed to vent clean air back into the kitchen, filtering vapors ...

Page 39 - t o p e x h a u s t v e n t; o p e r a t i o n

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 37 . i n s t a l l a t i o n v e n t l e s s h o o d o p t i o n TOP LEVEL ASSY, VHES-5 HOOD FOR COMBI 5010692 t o p e x h a u s t v e n t 2 6 1 4 3 5 7 1 Ventless Hood Power Knob 2 Emergency Latch Release: This release is to be used only if the...

Page 40 - o r i g i n a l e q u i p m e n t l i m i t e d w a r r a n t y; THIS WARRANTY DOES NOT APPLY TO:

COMbITOUCh® ES SERIES • ELECTRIC INSTALLATION MANUAL • 38 . o r i g i n a l e q u i p m e n t l i m i t e d w a r r a n t y Alto-Shaam, Inc. warrants to the original purchaser that any original part that is found to be defective in material or workmanship will, at Alto-Shaam’s option, subject to pro...

Page 41 - t r a n s p o r t a t i o n d a m a g e a n d c l a i m s

t r a n s p o r t a t i o n d a m a g e a n d c l a i m s all alto-shaam equipment is sold F.o.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. should damage occur in shipment, it is a matter between the carrier and the consignee. in such case...