Alto-Shaam 1220 - Manuals

Alto-Shaam 1220 – Manual in PDF format online.

Manuals:

Manual

Manual Alto-Shaam 1220

Summary

Page 3 - d e l i v e r y; c a u t i o n; TO PREVENT PERSONAL INJURY,

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 1. d e l i v e r y This alto-shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. upon receipt, check for any possible shipping damage and report it at once to the delivering car...

Page 4 - This appliance is intended to cook, hold; n o t e

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 2. c a u t i o n Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. c a u t i o n Used to indicat...

Page 5 - i n s t a l l a t i o n; d a n g e r; d a n g e r; s i t e i n s t a l l a t i o n

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 3. s i t e i n s t a l l a t i o n i n s t a l l a t i o n d a n g e r IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE.READ THE INSTALLATION, OPERATI...

Page 6 - positioning on site; Additional clearance is needed for; To avoid equipment damage, observe

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 4. n o t e : note dimensions required for doorways and aisles for access of the oven and pallet to the installation site. Transport the oven in an upright and level position only. do not tilt the oven. ® s i t e i n s t a l l a t i o n...

Page 7 - Lifting Instructions; Do not lift in

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 5. s i t e i n s t a l l a t i o n i n s t a l l a t i o n Lifting Instructions Do not lift in this area! Damage to the components will result. Center of Gravity Front View Top View (Front) Leg 24” Spacer Board Remove banding before li...

Page 8 - positioning requirements

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 6. s i t e i n s t a l l a t i o n i n s t a l l a t i o n positioning requirements q in order to ensure proper ventilation, a minimum distance of at least 6-inches (152mm) must be kept from the control panels side (left) of the oven a...

Page 9 - a c c e s s o r i e s; combiclean® Tablets —; scale FreeTM; shelf, stainless steel wire

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 7. a c c e s s o r i e s combiclean® Tablets — ce-28892 sPEcially FOrMulatEd FOr cOMbitHErM OvENs ➥ twO (2) cONtaiNErs / bOX , 90 PackEts EacH cONtaiNEr combitherm cleaning liquid — ce-24750 sPEcially FOrMulatEd FOr cOMbitHErM OvENs ➥ ...

Page 12 - iN

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 10. 6•10 es iN 32-15/16" (835mm) 35-9/16" (903mm) 21-11/16" (550mm) 5-3/8" (137mm) 6-3/8" (161mm) WATERDRAIN 33-7/8" (859mm) 35-13/16" (909mm) 2" (50mm) 41-1/16" (1042mm) Water Drain (Side Back) Stea...

Page 14 - *electrical service charge applies

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 12. 10•10 es i 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31...

Page 15 - h x w x d

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 13. 19-1/2" (495mm) 12-5/16" (312mm) 9-9/16" (242m m) 35-7/8" (910mm)33-7/8" (860mm) 33" (837mm) 2" (50mm) 35-11/16" (905mm) 25" (635mm) 7-9/16" (191mm) 5" (126mm) Water Drain (Rear) Steam Ve...

Page 18 - d i m e n s i o n s :; w e i g h t

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 16. 30" (760mm) 4-11/16" (120mm) 2-5/16" (58mm) 22-3/8 " (568mm) 15-1/2 " (393mm) 12-3/4" (323mm) Electrical Connection (Bottom) 2" (50mm) 46-7/8" (1190mm) 43-7/8" (1114mm) 41-15/16" (1064mm) 40-...

Page 19 - i n s t a l l a t i o n r e q u i r e m e n t s

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 17. 30" (760mm) 4-11/16" (120mm) 2-5/16" (58mm) 22-3/8 " (568mm) 15-1/2 " (393mm) 12-3/4" (323mm) Electrical Connection (Bottom) 2" (50mm) 46-7/8" (1190mm) 43-7/8" (1114mm) 41-15/16" (1064mm) 40-...

Page 21 - e l e c t r i c a l

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 19. 46-3/4" (1186mm) 44-3/4" (1136mm) 40-15/16" (1039mm) 1-13/16" (46mm) 48" (1218mm) 45-5/16" (1151mm) 33-1/2" (851mm) 2-1/16" (52mm) Water Drain (Bottom) 51-15/16" (1319mm) 2" (50mm) 76-15/16&#...

Page 24 - e l e c t r i c a l c o n n e c t i o n; an electrical wiring diagram is located behind; note; ce approved appliances must be

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 22. e l e c t r i c a l c o n n e c t i o n i n s t a l l a t i o n d a n g e r ENSURE POWER SOURCE MATCHES VOLTAGE STAMPED ON APPLIANCE NAMEPLATE. d a n g e r To avoid electrical shock, this appliance MUST be adequately grounded in ac...

Page 25 - FINAL ASM, TOUCH SCREEN; Terminal Block

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 23. e l e c t r i c a l c o n n e c t i o n i n s t a l l a t i o n d a n g e r ELECTRICAL CONNECTIONS MUST BE MADE BY A QUALIFIED SERVICE TECHNICIAN IN ACCORDANCE WITH APPLICABLE ELECTRICAL CODES. FINAL ASM, TOUCH SCREEN COMBICLEAN 50...

Page 26 - w a r n i n g; MuSt ROTATE IN THE SAME; tO CHANGE MOtOR dIRECtION,

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 24. motor with rotation direction electrical connection electrical panel terminal block ground w a r n i n g FOLLOWING ELECTRICAL CONNECTION, THE FAN MuSt ROTATE IN THE SAME DIRECTION AS THE ARROW LOCATED ON THE OVEN FAN MOTOR. T H I S...

Page 27 - m o b i l e e q u i p m e n t r e s t r a i n t; Two of the casters must be the locking type.; risk of electric shock.; Appliance must be secured

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 25. m o b i l e e q u i p m e n t r e s t r a i n t i n s t a l l a t i o n any appliance that is not furnished with a power supply cord but includes a set of casters must be installed with a tether. adequate means must be provided to ...

Page 28 - w a t e r q u a l i t y r e q u i r e m e n t; warning; use a drinking quality, cold water supply only; ALTO-SHAAM COMBITHERM WATER QUALITY MINIMUM STANDARDS; USE A DRINKING QUALITY, COLD WATER SUPPLY ONLY

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 26. i n s t a l l a t i o n w a t e r q u a l i t y r e q u i r e m e n t warning tO pREVENt WAtER pIpES OR HOSES FROM buRStING, INCOMING WAtER SuppLy SHOuLd bE tuRNEd OFF WHEN tHE AppLIANCE IS NOt IN uSE. warning WAtER SuppLy MuSt bE ...

Page 29 - w a t e r c o n n e c t i o n s; water supply & installation; one suggested

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 27. i n s t a l l a t i o n w a t e r c o n n e c t i o n s water supply & installation water requirements two (2) cold water inlets - drinking quality one (1) treated water inlet: 3/4” npT* one (1) untreated water inlet: 3/4” npT*...

Page 30 - w a t e r v a l v e

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 28. i n s t a l l a t i o n w a t e r v a l v e w a t e r d r a i n a g e s h u t - o f f v a l v e s h o w n i n t h e o f f p o s i t i o n note: the shut-oFF valve must be in the oPen Positionwhen the oven is being used. The oven mu...

Page 31 - c h e c k l i s t; Use this list as a final check of oven installation conformance.; C L E A R A N C E S :; C O N t R O L b O A R d C O N N E C t I O N S & O p E R A t I O N :; p H y S I C A L C O N d I t I O N : *

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 29. i n s t a l l a t i o n c h e c k l i s t Use this list as a final check of oven installation conformance. Damage directly attributed to improper set up, installation, or cleaning can invalidate warranty claims. C L E A R A N C E S...

Page 32 - PRESS AND HOLD THE POWER KEY FOR A PERIOD OF 5 SECONDS.; C O N T R O L R E S E T; PRESS THE START KEY TO ACKNOWLEDGE THE ERROR.; ERROR CODES AND REASONS; S E R v i C E m O D E A N D E R R O R C O D E S; Error

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 30. i n s t a l l a t i o n There is a remote possibility in the day-to-day operation of the Combitherm that the control could lock or freeze. If this occurs, the control is easy to reset. PRESS AND HOLD THE POWER KEY FOR A PERIOD OF 5...

Page 35 - CONTiNUED OPERATiON UNDER ERROR CONDiTiONS; E m E R g E N C y O P E R A T i O N

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 33. i n s t a l l a t i o n In the event of an error code, the Combitherm may be operated on a limited basis. Error conditions under which continued operation can be conducted are indicated by “Yes” in the chart show...

Page 36 - v e n t l e s s h o o d o p t i o n; c o n d e n s a t e d r a i n

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 34. i n s t a l l a t i o n v e n t l e s s h o o d o p t i o n The Ventless hood option is factory installed directly on the top of the alto-shaam combitherm oven. The hood is designed to vent clean air back into the kitchen, filterin...

Page 37 - t o p e x h a u s t v e n t; o p e r a t i o n

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 35. i n s t a l l a t i o n v e n t l e s s h o o d o p t i o n TOP LEVEL ASSY, VHES-5 HOOD FOR COMBI 5010692 t o p e x h a u s t v e n t 2 6 1 4 3 5 7 1 Ventless Hood Power Knob 2 Emergency Latch Release: This release is to be used on...

Page 38 - o r i g i n a l e q u i p m e n t l i m i t e d w a r r a n t y; THIS WARRANTY DOES NOT APPLY TO:

COMbIThERM® ES SERIES • ELECTRIC INSTALLATION MANUAL #MN-28897 • 36. o r i g i n a l e q u i p m e n t l i m i t e d w a r r a n t y Alto-Shaam, Inc. warrants to the original purchaser that any original part that is found to be defective in material or workmanship will, at Alto-Shaam’s option, subje...

Page 39 - t r a n s p o r t a t i o n d a m a g e a n d c l a i m s

t r a n s p o r t a t i o n d a m a g e a n d c l a i m s all alto-shaam equipment is sold F.o.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. should damage occur in shipment, it is a matter between the carrier and the consignee. in such case...