Page 3 - Table of
© Copyright 2010, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. 513447 1 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT T...
Page 5 - Section 1; DANGER; WARNING
513447 3 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 1 Safety Information Throughout this manual and on machine decals, you will find precautionary statements (“CAUTION,” “WARNING” and “DANGER”) followed by specific instructions. These precautions are intended for the...
Page 6 - Locating an Authorized Servicer; reconnected to ensure that the dryer is properly grounded.
4 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Safety Information NOTE: The WARNINGS and IMPORTANT INSTRUCTIONS appearing in this manual are not meant to cover all possible conditions and situations that may occur. Common sense, caution and care must be exercised when i...
Page 7 - Section 2; Customer Service
513447 5 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 2 Introduction Customer Service If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950 for the name and address ...
Page 8 - Model Identification
6 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Introduction Model Identification Information in this manual is applicable to these dryers. ModelNumber Coin Dr op Re a d y Coin Dr op In stall e d Ca rd Re a d e r Re a d y Ce ntra l P a y Elec tr ic H e at G as H e at BD3...
Page 11 - How Your Dryer Works
513447 9 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Introduction How Your Dryer Works The dryer uses heated air to dry loads of laundry. When the motor is started, the exhaust fan pulls room temperature air in through louvers at the rear of the dryer and over the heat source...
Page 12 - Section 3; Dryer Motor Does Not Run
10 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 3 Dryer Troubleshooting IMPORTANT: Refer to wiring diagram for aid in testing dryer components. 1. Dryer Motor Does Not Run To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnec...
Page 14 - Dryer Stops In Cycle Quits After The First Few Loads Has A Burning
12 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 2. Dryer Stops In Cycle; Quits After The First Few Loads; Has A Burning Smell; Cycles On Motor Thermal Protector Dryer stops in cycle, quits after first few loads, has burning smell or cycles on motor...
Page 15 - Dryer Motor Runs But Cylinder Does Not Turn
513447 13 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 3. Dryer Motor Runs But Cylinder Does Not Turn Dryer motor runs but cylinder does not turn. Is motor drive pulley loose? Tighten pulley. Is belt installed on pulley? No Install belt. No Is cylinder be...
Page 16 - Dryer Motor Does Not Stop
14 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 4. Dryer Motor Does Not Stop Dryer motor does not stop. Is wiring to motor switch incorrect? Refer to wiring diagram. Yes Is motor centrifugal switch sticky or plugged with lint? No Remove dust or lin...
Page 17 - Dryer Runs Only When Door is Open
513447 15 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 5. Dryer Runs Only When Door is Open Dryer runs when door is open. Is door switch miswired? Rewire door switch. Refer to wiring diagram. Yes DRY1856S Replace door switch. No
Page 18 - Dryer Heating Assembly Does Not Heat or Burner Does Not Ignite
16 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 6. Dryer Heating Assembly Does Not Heat or Burner Does Not Ignite Dryer heating assembly does not heat or burner does not ignite. Is exhaust system improper or inadequate? Refer to Installation Instru...
Page 20 - Igniter Does Not Glow (Gas Supply Sufficient) – Gas Dryer Models
18 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 7. Igniter Does Not Glow (Gas Supply Sufficient) – Gas Dryer Models Gas dryer models: Igniter does not glow (gas supply sufficient). Is there power to power leads on valve (pink and blue wires)? Check...
Page 21 - Burner Ignites and Goes Out Repeatedly – Gas Dryer Models
513447 19 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 8. Burner Ignites and Goes Out Repeatedly – Gas Dryer Models G as dryer model s : B u rner ignite s a nd goe s o u t repe a tedly. I s exh aus t s y s tem improper or in a de qua te? Refer to Installa...
Page 22 - Igniter Glows But Burner Does Not Ignite – Gas Dryer Models
20 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 9. Igniter Glows But Burner Does Not Ignite – Gas Dryer Models Gas dryer models: Igniter glows but burner does not ignite. Did sensor fail in closed position? Replace sensor. Yes Is secondary coil or ...
Page 23 - Dryer Heater Assembly Or Burner Shuts Off Prematurely
513447 21 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 10. Dryer Heater Assembly Or Burner Shuts Off Prematurely Dryer heater assembly or burner shuts off prematurely. Is exhaust system improper or inadequate? Refer to Installation Instructions (supplied ...
Page 24 - Dryer Heater Assembly or Burner Repeatedly Cycles Off On Limit
22 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 11. Dryer Heater Assembly or Burner Repeatedly Cycles Off On Limit Thermostat Dryer heater assembly or burner repeatedly cycles off on limit thermostat. Is external exhaust system longer or providing ...
Page 26 - Dryer Heater Assembly or Burner Does Not Shut Off
24 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 12. Dryer Heater Assembly or Burner Does Not Shut Off Dryer heater assembly or burner does not shut off. Is motor switch inoperative? (Must be in a heat setting.) Test switch and replace if inoperativ...
Page 27 - Clothes Do Not Dry in Dryer
513447 25 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 13. Clothes Do Not Dry in Dryer Clothes do not dry in dryer. Does heater assembly not heat or burner not ignite? Refer to Dryer Heating Assembly Does Not Heat or Burner Does Not Ignite paragraph. Yes ...
Page 28 - Clothes Are Too Hot When Removed From Dryer
26 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 14. Clothes Are Too Hot When Removed From Dryer Clothes are too hot when removed from dryer. Is exhaust system improper or inadequate? Refer to Installation Instructions (supplied with unit) for exhau...
Page 29 - Excessive Chattering Or Vibrating Noise in Dryer
513447 27 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 15. Excessive Chattering Or Vibrating Noise in Dryer Excessive chattering or vibrating noise in dryer. Is idler spring inoperative? Remove lower access panel. Set dryer to normal cycle and allow it to...
Page 30 - Excessive Humming Or Whistling Noise in Dryer
28 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Dryer Troubleshooting 16. Excessive Humming Or Whistling Noise in Dryer Excessive humming or whistling noise in dryer. Is blower housing inoperative? If the abnormal operating noise is loudest at the vent exit, the problem...
Page 31 - Section 4; Description
513447 29 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 4 Electronic Control Troubleshooting 17. Error Codes Following is a list of possible error codes. Display Information Description Cause/Corrective Action Right most DP (decimal point) Lit Network Communication Erro...
Page 32 - Coins Ignored When Entered
30 513447 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 18. Coins Ignored When Entered Does the display on the electronic control increment properly? Is connector H5 on the control firmly seated in its receptacle? Is the 3 pin connector betwee...
Page 33 - No IR Communication
513447 31 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 19. No IR Communication Attempt to communicate with control using PDA. Is there a response of any kind from the control? Check PDA manual for correct use of IR. No DRY1859S Check PDA. Set...
Page 34 - No Di
32 513447 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 20. No Display Replace the control. Correct wirin g between the tran s former and the control. Replace the tran s former. Are there 24 volt s AC acro ss terminal s H1- 3 and H1-1 on the c...
Page 35 - No Display
513447 33 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT No Display DRY1 8 6 3S 1 2 3
Page 37 - Door Open
513447 35 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Door Open DRY1 8 6 3S 1 2 3 4
Page 38 - Motor Will Not Start
36 513447 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 22. Motor Will Not Start Is there voltage across terminals 5 and 4 of the motor? Is there voltage across H 3 -4 and H 3 -6 on the control ? Is there voltage across H 3 -1 and H 3 -6 on th...
Page 39 - Motor Will Not Start
513447 37 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Motor Will Not Start DRY1 8 6 3S 1 2 3
Page 40 - No Heat Electric
38 513447 Electronic Control Troubleshooting © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 23. No Heat (Electric) I s there volta g e acro ss the lead s to the heatin g element ? I s there volta g e from the output s ide of the limit thermo s tat to L2 ? I s there volta g e to ...
Page 44 - Section 5; Troubleshooting Coin Drop
42 513447 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 5 Coin Drop Troubleshooting 25. Troubleshooting Coin Drop a. Non-Electronic Coin Drops: When coin is placed into coin slot, the coin should roll down drop and be heard dropping into coin vault. If coin does not fal...
Page 46 - Remove Coin Drop From Machine; Replace Tension Spring
44 513447 Coin Drop Troubleshooting To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Never start the dryer(s) with any guards/panels removed.• When...
Page 48 - Reinstall Coin Drop Into Machine
46 513447 Coin Drop Troubleshooting To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Never start the dryer(s) with any guards/panels removed.• When...
Page 49 - Section 6
513447 47 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 6 Adjustments IMPORTANT: When reference is made to directions (right or left) in this manual, it is from operator’s position facing front of washer. 26. Leveling Legs Refer to Figure 10 . NOTE: Dryer should be inst...
Page 52 - Coin Drop
50 513447 Adjustments © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Never st...
Page 54 - Cleaning Electronic Coin Drop; Coin Drops with Old-Style Spring (refer to
52 513447 Adjustments © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Never st...
Page 56 - Coin Drops with OLD-Style Spring
54 513447 Adjustments © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Never st...
Page 57 - Section 7
513447 55 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 7 Test Procedures IMPORTANT: Electrical test procedures in this service manual are performed by using a Volt-Ohm meter. Tests can also be performed using a multi-meter or any other electrical testing equipment with...
Page 58 - Fabric Selector Switch
56 513447 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 59 - NOTE: Drive Motor Resistance
513447 57 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 60 - Motor Switch
58 513447 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 61 - Motor Windings
513447 59 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 62 - TWO
60 513447 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 63 - Motor with Switch on Blower End
513447 61 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 64 - Motor with switch on pulley end
62 513447 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 65 - Burner System Operation
513447 63 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 67 - Electrical Circuit To Ignition; Silicon Carbide Ignition:
513447 65 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 68 - Silicon Carbide Igniter; Ignition Control Grounding
66 513447 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 69 - Cycling or Limit Thermostat; or Limit Thermostat
513447 67 Test Procedures © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas dryer(s) before servicing.• Neve...
Page 71 - Section 8
513447 69 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Section 8 Internal Wiring of Dryer Motor Switch To reduce the risk of electric shock, fire, explosion, serious injury or death:• Disconnect electric power to the dryer(s) before servicing.• Close gas shut-off valve to gas ...
Alliance AWN432SP113TW01
User Manual
Alliance ATE50FGP171TW01
User Manual
Alliance AWNE82SP113TW01
User Manual
Alliance AWN432SP113TW04
User Manual
Alliance AWN43RSN115TW01
User Manual