Bradley MG-2/TT - Manual

Bradley MG-2/TT

Bradley MG-2/TT – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
Page: / 20

Table of Contents:

  • Page 2 – Pre-Installation Information; Barrier-free and ADA compliant - standard height mounting
  • Page 3 – MG-2/TT Express® Lavatory System Dimensions
  • Page 4 – TAS Juvenile Height; Grades Pre-K thru 5 or 6
  • Page 5 – Step 1: Rough in supplies and optional hot water heater; lines will cause the valves to malfunction.; Figure 1; Standard Height Mounting
  • Page 6 – Figure 1a; Figure 1b
  • Page 7 – Step 2: Rough in wall anchors and electrical outlet; Figure 2
  • Page 8 – Step 3: Mount frame to wall; Loosen, but do not remove the three bottom access panel screws.; Figure 3
  • Page 9 – Step 4: Install bowl assembly; to pinch tubing between bowl and frame.; bolts. Overtightening bolts can damage the Terreon® material.; (supplied by the installer) to bolt the bowl to the wall anchors.; Figure 4
  • Page 10 – Step 5: Connecting supply; pipe stubbed out of the wall.; Figure 5a
  • Page 11 – Step 6: Connecting optional hot water heater; Remove the two screws from the back of the water; Figure 6c
  • Page 12 – Figure 7; Step 7: Connecting electrical and supply tubing; (the timing is electronically controlled and set at 15 seconds).
  • Page 13 – Cleaning and Maintenance Instructions; Terreon® and panel maintenance; Always use stainless steel wool or stainless steel brushes.; NOTE: Strongly acidic or caustic cleaners may; Terreon® Bowl, Sprayhead and Pedestal End Cap cleaning
  • Page 14 – Assembly of Components; Figure 8
  • Page 15 – Sensor assembly and solenoid valve access; • To access solenoids:; Figure 9
  • Page 16 – TouchTime® and Aerator/Access Plate Assemblies; Other replacement parts
  • Page 17 – An individual operating station fails to shut off and drips.; careful not to lose the armature or spring (see Figure 12 on page 18).; An individual operating station fails to turn on.; valve and reconnect to the adjacent valve.
  • Page 19 – Thermostatic Mixing Valve Maintenance and Troubleshooting; Problem: Limited water flow; Cause: Dirt and debris have built up in the valve or strainer.; Problem: External leaks in the system; Cause: Thermostat is slowly failing or not working at all.; counterclockwise; increase; the temperature or; clockwise; to; decrease
Loading the manual

MG-2/TT

Express® Lavatory
System - MG-Series
with TouchTime® Control

Installation

Instructions

P.O. Box 309, Menomonee Falls, WI 53052-0309
TEL. 1-800-BRADLEY

FAX 262-251-5817

http://www.bradleycorp.com

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . . . .2
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
Installation Instructions . . . . . . . . . . . . . . . . . . 5-12
Cleaning and Maintenance . . . . . . . . . . . . . . . . . .13
Assembly of Components . . . . . . . . . . . . . . . .14-16
Solenoid Valve Troubleshooting . . . . . . . . . . .17-18
Vernatherm™ Valve Maintenance . . . . . . . . .19-20
Cleaning the Strainer . . . . . . . . . . . . . . . . . . . .19-20

A

D

A

C

O

M

P L I A N T

215-1480 Rev. E; EN 06-915
© 2007 Bradley Corporation
Page 1 of 20

2/8/07

IMPORTANT

Read this entire installation manual to ensure proper
installation.

Flush all the water supply lines before making connections.

Wall anchors used must have a minimum pull-out rating of
1,000 lbs.

File these instructions with the owner or maintenance
department.

Product warranties may be found under "Product
Information" on our web site at www.bradleycorp.com.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Pre-Installation Information; Barrier-free and ADA compliant - standard height mounting

Express® Lavatory System - MG-Series with TouchTime® ControlMG-2/TT Installation Instructions 2 2/8/07 Bradley Corporation • 215-1480 Rev. E; EN 06-915 Pre-Installation Information Barrier-free and ADA compliant - standard height mounting The MG-2/TT Express® Lavatory System must have a rim height n...

Page 3 - MG-2/TT Express® Lavatory System Dimensions

3 Express® Lavatory System - MG-Series with TouchTime® Control Installation Instructions MG-2/TT Bradley Corporation • 215-1480 Rev. E; EN 06-915 2/8/07 MG-2/TT Express® Lavatory System Dimensions 27" (686) 47" (1194) 54" (1372) 42" (1067) 15" (381) *Subtract 4" from vertical...

Page 4 - TAS Juvenile Height; Grades Pre-K thru 5 or 6

Express® Lavatory System - MG-Series with TouchTime® ControlMG-2/TT Installation Instructions 4 2/8/07 Bradley Corporation • 215-1480 Rev. E; EN 06-915 Dimensions continued . . . TAS Juvenile Height Grades 6 thru 8 or 9 TAS Juvenile Height Grades Pre-K thru 5 or 6 35-1/2" (902) 30" (762) 26&...

Other Bradley Models

All Bradley Other