BILLY GOAT AE401 - Manual - manualsarea.com

Page 2 - AE Owner’s Manual; ABOUT THIS MANUAL; for purchasing a BILLY GOAT; CONTENTS; CHECKLIST

Part No 360314 Form No F031708A 2 AE Owner’s Manual ABOUT THIS MANUAL THANK YOU for purchasing a BILLY GOAT ® Aerator . Your new machine has been carefully designed and manufactured to provide years of reliable and productive service. This manual provides complete operating and maintenance instructi...

Page 4 - GENERAL SAFETY INSTRUCTIONS and SYMBOLS; is recommended when operating this equipment.

Part No 360314 Form No F031708A 4 AE Owner’s Manual GENERAL SAFETY INSTRUCTIONS and SYMBOLS The safety symbols shown below are used throughout this manual. You should become familiar with them before assembling, operating, or servicing this equipment. This symbol indicates important information that...

Page 6 - INTENDED USE; ENGINE LABELS; SUBARU HONDA; Subaru Honda

Part No 360314 Form No F031708A 6 AE Owner’s Manual INTENDED USE INTENDED USE: This machine is designed for aerating established lawns and large grass covered areas. The machine should not be used for any other purpose than that stated above. DO NOT operate if excessive vibration occurs. If excessiv...

Page 7 - PACKING CHECKLIST; all safety instructions before assembling unit.; FILL WITH WATER

Part No 360314 Form No F031708A 7 AE Owner’s Manual PACKING CHECKLIST Your Billy Goat is shipped from the factory in one carton, completely assembled. PUT OIL IN ENGINE BEFORE STARTING ASSEMBLY READ all safety instructions before assembling unit. TAKE CAUTION when removing the unit from the box. 1. ...

Page 8 - PUT OIL IN ENGINE BEFORE STARTING

Part No 360314 Form No F031708A 8 AE Owner’s Manual OPERATION Like all mechanical tools, reasonable care must be used when operating machine. Inspect machine work area and machine before operating. Make sure that all operators of this equipment are trained in general machine use and safety. PUT OIL ...

Page 9 - TINES RAISING/LOWERING

Part No 360314 Form No F031708A 9 AE Owner’s Manual TINES RAISING/LOWERING The tines are raised or lowered into the ground by operating the tine engagement lever on the upper handle. Tine penetration is very dependent on surface preparation. READ the entire operation section before aerating. AERATIN...

Page 10 - engagement lever, lowering the tines into the dirt.; FOLDING HANDLE

Part No 360314 Form No F031708A 10 AE Owner’s Manual ENGAGE TINES: With the aerator in the work area, release the clutch bail and push forward on the tine engagement lever, lowering the tines into the dirt. AERATE: Engage the operators clutch bail by pushing it pulling it backwards from the handle, ...

Page 11 - ERIODIC; ENGINE MUST BE LEVEL WHEN CHECKING OR FILLING OIL; TINE REEL REMOVAL AND TINE ROW REPLACEMENT; Wait for engine to cool and disconnect spark plug.

Part No 360314 Form No F031708A 11 AE Owner’s Manual MAINTENANCE P ERIODIC M AINTENANCE Periodic maintenance should be performed at the following intervals: Maintenance Operation Every Use (daily) Every 25 hrs Every 50 Hours Inspect for loose, worn or damaged parts. z Check engine oil. z Inspect bel...

Page 13 - DRIVE BELT REPLACEMENT; NOTE

Part No 360314 Form No F031708A 13 AE Owner’s Manual DRIVE BELT REPLACEMENT 1 . Wait for engine to cool and disconnect spark plug. 2. Remove the top guard by removing the four nuts, two on each side, that secure it to the frame. 3. Slide the belt off of the engine drive pulley, and off of the jacksh...

Page 14 - WARRANTY CLAIM PROCEDURE; Should a BILLY GOAT

Part No 360314 Form No F031708A 14 AE Owner’s Manual Troubleshooting When servicing the engine refer to specific manufacturers engine owner's manual. All engine warranty is covered by the specific engine manufacturer. If your engine requires warranty or other repair work contact your local servicing...

Page 15 - MAINTENANCE RECORD; Date Service

Part No 360314 Form No F031708A 15 AE Owner’s Manual MAINTENANCE RECORD Date Service Performed

Page 16 - PARTS DRAWING AE

Part No 360314 Form No F031708A 16 AE Owner’s Manual PARTS DRAWING AE

Page 17 - PARTS LIST AE

Part No 360314 Form No F031708A 17 AE Owner’s Manual PARTS LIST AE ITEM AE401 AE401H5T AE401H AE401S NO. Part No. Part No. Part No. Part No. 2 WATER TANK 5.5 GAL 360238 1 360238 1 360238 1 360238 1 3 GUARD DRIVE COVER 360280 1 360280 1 360280 1 360305 1 9 WASHER 5/16 FENDER 8172020 5 8172020 5 81720...

Page 20 - If you liked this product please feel

Part No 360314 Form No F031708A 20 AE Owner’s Manual If you liked this product please feel free to view our full line of quality lawn care, renovation, and debris removal products at www.billygoat.com FINISH MOWER BRUSH CUTTER FORCE BLOWER QL VACUUM MULTI VACUUM POWER RAKE

BILLY GOAT AE401 - Manual

Table of Contents:

Summary

Other BILLY GOAT Models