BILLY GOAT 510223 - Manual - manualsarea.com

Page 2 - HW Owner’s Manual; ABOUT THIS MANUAL; for purchasing a BILLY GOAT; CONTENTS; CHECKLIST

Part No 510267 Form No F070506A 2 HW Owner’s Manual ABOUT THIS MANUAL THANK YOU for purchasing a BILLY GOAT ® High Wheel Mower . Your new machine has been carefully designed and manufactured to provide years of reliable and productive service. This manual provides complete operating and maintenance ...

Page 3 - HW651SP

Part No 510267 Form No F070506A 3 HW Owner’s Manual SERIAL PLATE DATA Record the model number, serial number, date of purchase, and where purchased. Purchase Date: Purchased From: Specifications HW651SP Engine: HP 6.0 (4.5 kW) Engine: Model FJ180V Engine: Type Kawasaki OHV Engine: Fuel Capacity 2.1 ...

Page 4 - GENERAL SAFETY INSTRUCTIONS and SYMBOLS; is recommended when operating this equipment.

Part No 510267 Form No F070506A 4 HW Owner’s Manual GENERAL SAFETY INSTRUCTIONS and SYMBOLS The safety symbols shown below are used throughout this manual. You should become familiar with them before assembling, operating, or servicing this equipment. This symbol indicates important information that...

Page 6 - SOUND

Part No 510267 Form No F070506A 6 HW Owner’s Manual SOUND SOUND LEVEL 80 dB(a) at Operator Position Sound tests were conducted in accordance with 2000/14/EEC, and were performed on 2-21-2002 under the conditions listed below. Sound power level listed is the highest value for any model covered in thi...

Page 7 - INSTRUCTION LABELS; ENGINE LABELS; KAWASAKI

Part No 510267 Form No F070506A 7 HW Owner’s Manual INSTRUCTION LABELS The labels shown below were installed on your BILLY GOAT ® HW Mower. If any labels are damaged or missing, replace them before operating this equipment. Item numbers from the Illustrated Parts List and part numbers are provided f...

Page 8 - PACKING CHECKLIST; PUT OIL IN ENGINE BEFORE STARTING; all safety instructions before assembling unit.; TAKE CAUTION; folded over; Kawasaki 6HP

Part No 510267 Form No F070506A 8 HW Owner’s Manual PACKING CHECKLIST Your Billy Goat HW Mower is shipped from the factory in one carton, completely assembled except for the upper handle. PUT OIL IN ENGINE BEFORE STARTING ASSEMBLY READ all safety instructions before assembling unit. TAKE CAUTION whe...

Page 10 - PROPULSION; can be varied by selecting a higher or lower gear using; HILLSIDE MOWING; Never mow on any slope greater than 15 degrees. Always; STORAGE; : Wheels must be chocked or blocked when unit is parked on a slope.

Part No 510267 Form No F070506A 10 HW Owner’s Manual PROPULSION This unit is self-propelled, and is controlled by a lever control. To engage the wheel drive, pull up and squeeze it against operator's handle. The drive is disengaged by releasing this lever.(See Fig. 3 & 3.1) GROUND SPEED can be v...

Page 11 - ERIODIC; BLADE Removal / Sharpening; Tighten the jam nut until it is flush with the end of the shaft; BELT REPLACEMENT

Part No 510267 Form No F070506A 11 HW Owner’s Manual MAINTENANCE P ERIODIC M AINTENANCE Periodic maintenance should be performed at the following intervals: Maintenance Operation Every Use (daily) Every 5 hrs or (daily) Every 25 Hours Every 100 Hours Inspect for loose, worn or damaged parts. z Check...

Page 12 - SELF PROPELLED DRIVE ADJUSTMENT; : If the drive clutch begins to squeal or slip, do not continue

Part No 510267 Form No F070506A 12 HW Owner’s Manual BELT REPLACEMENT continued Drive Belt Tools required: 3/8 inch socket, 1/2 inch socket, 3/8" torque wrench. 1. Follow steps 1 through 5 above to remove the blade drive belt. 2. Set the unit on its side to allow access to both pulley and the bl...

Page 13 - WARRANTY CLAIM PROCEDURE; For online product registration go to

Part No 510267 Form No F070506A 13 HW Owner’s Manual Troubleshooting When servicing engine refer to specific manufacturers engine owner's manual. All engine warranty is covered by the specific engine manufacturer. If your engine requires warranty or other repair work contact your local servicing eng...

Page 14 - PARTS DRAWING HW

Part No 510267 Form No F070506A 14 HW Owner’s Manual PARTS DRAWING HW

Page 15 - PARTS LIST

Part No 510267 Form No F070506A 15 HW Owner’s Manual PARTS LIST ITEM PART NO. NO. 1 510263 LEVER DRIVE CLUTCH W/CABLE 1 2 510262 LEVER ENGINE BRAKE W/CABLE 1 34 900407 TY WRAP 3 5 510274 GRIP HANDLE 1” ID X 5” BLACK 2 6 510127 CONTROL SHIFT 3 SPEED 1 7 510261 HANDLE UPPER HW 1 8 830533 ROPE GUIDE 2 ...

Page 16 - MAINTENANCE RECORD; Date Service

Part No 510267 Form No F070506A 16 HW Owner’s Manual MAINTENANCE RECORD Date Service Performed