Page 2 - WARNING; This symbol indicates information concerning your; WARNING; CAUTION; This symbol indicates information on how to avoid damaging; IMPORTANT; This symbol indicates tips and information about use; ENVIRONMENTAL TIPS; ENVIRONMENT; This symbol indicates tips and information about economical; CONTENTS
2 CONTENTS Important safety instructions .......................................................3Product description ......................................................................6Assembling the barbecue ........................................................... 7Using your barbecue ..........
Page 3 - Important – check for any damages or marks; Information on disposal for users; Note to the installer; IMPORTANT SAFETY INSTRUCTIONS
3 SAFETY Please read the user manual carefully and store in a handy place for later reference. TIPS & INFORMATION IMPORTANT Important – check for any damages or marks If you find the barbecue is damaged or marked, you must report it within 7 days if you wish to claim for damage/marks under the m...
Page 4 - Failure to follow these instructions and observe the; To the installer
4 SAFETY IMPORTANT SAFETY INSTRUCTIONS WARNING WARNING Failure to follow these instructions and observe the warnings provided in this operations manual could result in fire, explosion or burn hazard, which could cause property damage, personal injury or death. Gas vapour is highly explosive and can ...
Page 5 - Do
5 SAFETY IMPORTANT SAFETY INSTRUCTIONS • Allow children to operate this appliance. • Use charcoal or any other solid fuel in this appliance. • Disconnect any gas fittings while the appliance is operating. • Use a rusty or dented gas cylinder or cylinder with a damaged gas valve. • Fill the gas cylin...
Page 7 - ASSEMBLING THE BARBECUE; General
7 ASSEMBLY ASSEMBLING THE BARBECUE ASSEMBLY General This barbecue can be mounted onto a mobile trolley. The Trolley is packed in a separate carton. Please refer to the Trolley instruction booklet for assembly of the trolley, and barbecue mounting. Once the barbecue had been properly installed, pleas...
Page 8 - Excess yellow tipping means the combustion is not right, if
8 USING YOUR BARBECUE USING YOUR BARBECUE Before you light the barbecue Perform the following checks: • Make sure all connections are tight, and leak-tested. Gas regulators fitted with a hand-tightened wheel must be checked to ensure they are secured. • Check that all control knobs are in the ‘Off’ ...
Page 9 - After Use
9 USING YOUR BARBECUE USING YOUR BARBECUE After Use It is a good idea to leave the barbecue on for about 10 minutes after you have finished cooking. This helps to burn away any excess food residues and oil, and makes cleaning easier. 1. Be sure to turn off all control knobs and the gas supply. 2. Al...
Page 10 - PRODUCT DESCRIPTION FOR TROLLEY; Bolt pack content
10 PRODUCT DESCRIPTION FOR TROLLEY PRODUCT DESCRIPTION FOR TROLLEY 6 14 13 8 7 3 9 5 15 10 4 16 11 1 2 1 Base Panel 2 Right Hand Side Panel 3 Left Hand Side Panel 4 Rear Panel 5 Top Front Brace 6 Left Hand Side Door 7 Right Hand Side Door 8 Door Handle x 2 9 Side Shelf 10 Side Burner 11 Wheels Axel ...
Page 11 - ASSEMBLING THE TROLLEY
11 ASSEMBLY ASSEMBLING THE TROLLEY 1. Turn the Base Panel upside-down, insert the Wheel Axel through the 2 holes, and place a wheel on each side. Secure with a circlip on outside of wheel. Place Cap. insert each castor to its place in the other 2 corners. 2 x ‘A’ 2. Turn the base back upright, and a...
Page 12 - If required, attach the hinge blocks to front of side
12 ASSEMBLY ASSEMBLING THE TROLLEY 3. If required, attach the hinge blocks to front of side panels. Note: the block should be on the inside, with only the small bends protruding out. 8 x ‘D’ 4. Attach the Top Brace. Do not tighten. That will be done after fitting the doors. Insert magnets. 4 x ‘B’, ...
Page 13 - opening at door internal skin over the hinge block
13 ASSEMBLY ASSEMBLING THE TROLLEY 5. Hold each door at ~60° open angle, and insert through opening at door internal skin over the hinge block pins. Ensure correct engagement in both brackets simultaneously. Secure the Cylinder Shield (if included) in place on top, RH side of trolley. 6. Remove all ...
Page 15 - Connect hose and regulator assembly to point C of side
15 CONTENTS ASSEMBLING THE TROLLEY 10. Connect hose and regulator assembly to point C of side burner manifold as shown below and the other end to the gas cylinder. PERFORM LEAK TEST ON ALL CONNECTION POINTS BEFORE PROCEEDING FURTHER B C
Page 16 - TECHNICAL INFORMATION; NOTE: Do not modify this appliance. Any deviation from; Main barbecue
16 TECHNICAL INFORMATION TECHNICAL INFORMATION NOTE: Do not modify this appliance. Any deviation from factory settings could result in a safety hazard. Barbecue manifold inlet thread: 3/8 SAE male flare fitting. Gas Pressure: LPG – 2.75 Kpa; 11”WCNG – 1.0 Kpa; 4” WC Main barbecue Gas Nozzle size:LPG...
Page 17 - LOCATING YOUR BARBECUE; Outdoor Use Only; Verify ‘Gas Type’ label & data plate attached to side of; Maintenance
17 LOCATING YOUR BARBECUE LOCATING YOUR BARBECUE Most importantly, this is an outdoor appliance. Ensure your barbecue is positioned safely away from anything that can catch fire. Outdoor Use Only Under no circumstances is this barbecue to be used indoors. This includes garages or any other enclosed ...
Page 18 - GAS SPECIFICATIONS; Choosing a location
18 GAS SPECIFICATIONS GAS SPECIFICATIONS Choosing a location • The vertical clearance above the cooking surface to any combustible materials must be at least 1000mm. • Cooking with roasting hood closed vents the hot flue gases out the rear of the appliance. A minimum clearance of 450mm to any combus...
Page 19 - Natural gas conversion
19 GAS SPECIFICATIONS GAS SPECIFICATIONS Before proceeding, you need to establish the gas type which your barbecue will run on, and the style of installation you need. Natural gas or LPG/Propane. Before beginning installation or assembly, check that the gas type which the barbecue is designed for is...
Page 20 - Regulator connection; Hose and regulator replacement must be a genuine part; Gas leak test procedure
20 GAS SPECIFICATIONS GAS SPECIFICATIONS TIPS & INFORMATION IMPORTANT When disconnecting and removing the gas cylinder for the purpose of refilling, always observe the following procedure: • Ensure that all gas control valves on the appliance and the gas cylinder are turned off before disconnect...
Page 21 - TROUBLESHOOTING
21 TROUBLESHOOTING TROUBLESHOOTING CONDITION POSSIBLE CAUSE SOLUTION Flame goes out while in use Empty gas cylinder Replace cylinder Air mixed in hoses Re-ignite and allow operating for a short while, till clears out Blockage Seek professional assistance Ignition failure Gas cylinder valve close Tur...
Page 22 - NOTES
Page 23 - Warranty
23 WARRANTY This document sets out the terms and conditions of the product warranties for Electrolux Appliances. It is an important document. Please keep it with your proof of purchase documents in a safe place for future reference should there be a manufacturing defect in your Appliance. This warra...
Page 24 - Beefeater. We are part of the Electrolux Family.
AUSTRALIAphone: 1300 307 939 fax: 1800 356 669 email: customercare @ electrolux.com.au web: beefeaterbbq.com NEW ZEALANDphone: 0800 436 245 fax: 0800 225 088 email: customercare @ electrolux.co.nz web: beefeaterbbq.com For more information on all Beefeater products, or for dimension and installation...
