Zephyr ZRM-E36AS - Manual - manualsarea.com

Page 3 - able of Contents

1 SAFETY NOTICE ................................................................. 2-3 LIST OF MATERIALS ....................................................... 4 INSTALLATION Ducting Calculation Sheet ....................................... 5 Mounting Height & Clearance ............................

Page 4 - Important Safety Notice; READ AND SAVE THESE INSTRUCTIONS

Important Safety Notice READ AND SAVE THESE INSTRUCTIONS 2 www.zephyronline.com WARNING TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, DO NOT USE THIS FAN WITH ANY SOLID-STATE CONTROL DEVICE. WARNING TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK, OR INJURY TO PERSONS, OBSERVE THE FOLLOWING: a. Use this u...

Page 6 - List of Materials

List of Materials 4 www.zephyronline.com MODEL: ZRM-E36AS, ZRM-E42AS 2 Top Duct Covers 1 Top Support Frame 2 Bottom Duct Covers 1 Bottom Support Frame 2 Thin Trim Pieces 2 Thick Trim Pieces 1 Hood 4 Halogen Light Bulbs (pre-installed) 2 Metal Filters ( 3 - ZRM-E42AS) 3 Wire Nuts 4 ø14 OD / ø6.5 ID W...

Page 7 - Installation –

5 Duct pieces Total Equivalent numberlength x used = 3-1/ 4” x 10”Rect.,straight 1 Ft. x ( ) = Ft. 8” Round,straight 1 Ft. x ( ) = Ft. 3-1/ 4” x 10”Rect. 90 0 elbow 15 Ft. x ( ) = Ft. 3-1/ 4” x 10”Rect. 45 0 elbow 9 Ft. x ( ) = Ft. 3-1/ 4” x 10”Rect. 90 0 flat elbow 24 Ft. x ( ) = Ft. 3-1/ 4” x 10”R...

Page 8 - DUCTING

Installation – Mounting Height & Clearance 6 www.zephyronline.com DUCTING A minimum of 6” round or 3-1/4 x 10” rectangular GXFWPXVWEHXVHGWRPDLQWDLQPD[LPXPDLUÀRZHI¿FLHQF\ Always use rigid type metal ducts only. Flexible GXFWVFRXOGUHVWULFWDLUÀRZE\XSWR Use calculation worksheet to compute total duc...

Page 9 - WARNING FIRE HAZARD; Soffit or crawl space

7 WARNING FIRE HAZARD NEVER exhaust air or terminate duct work into spaces between walls, crawl spaces, ceiling, attics or garages. All exhaust must be ducted to the outside, unless using the recirculating option. Use single wall rigid Metal ductwork only. )DVWHQDOOFRQQHFWLRQVZLWKVKHHWPHWDOVFUHZVDQG...

Page 10 - or

8 www.zephyronline.com Installation – +RRG6SHFL¿FDWLRQV 3/4” 7 1/8 ” 10 3/4 ” 7 7/8 ” 10 1/8 ” 12 3/8 ” 8 3/4 ” FRONT 36” or 42” 27” 12” 14” 4” Top Support Frame (ceiling bracket) Top of Hood (blower housing) Side of Hood Front of Hood C/L 4 1/2 ” 3” 1 5/8 ” electrical K/O 1 1/8 ” 1/4” ø5 7/8” 11 5/...

Page 13 - RECIRCULATING KIT (REQUIRED IF NO DUCTING IS USED)

11 Ductless recirculating is intended for applications where an exhaust duct work is not possible to be installed. When converted, the hood functions as a recirculating hood rather than an exhaust hood. Fumes and exhaust IURPFRRNLQJDUHGUDZQDQG¿OWHUHGE\DVHWRIRSWLRQDOFKDUFRDO¿OWHUV7KHDLULVWKHQSXUL¿HGD...

Page 14 - The blower will be switched off by pressing:; Controls

12 www.zephyronline.com Blower Off Lights On/Off Blower On/Speed Selection Blower Off Blower On/Speed Selection Lights On/Off The blower will be switched off by pressing: Switch blower on and select speeds 1 - 3 by pressing: Switch lights on and off by pressing: Controls

Page 15 - Maintenance –

13 SURFACE MAINTENANCE: Clean periodically with hot soapy water and clean cotton cloth. Do not use corrosive or abrasive detergent , or steel wool/scouring pads which will scratch and damage surface. For heavier soil use liquid degreaser. After cleaning it is recommended that you use non-abrasive st...

Page 16 - REPLACING LIGHT BULBS

14 www.zephyronline.com REPLACING LIGHT BULBS CAUTION: Light bulb becomes extremely hot when turned on. DO NOT touch bulb until switched off and cooled. Touching hot bulbs could cause serious burns. Make sure all power is turned off and bulbs are not hot. 5HPRYHE\WXUQLQJEXOEFRXQWHUFORFNZLVH1RWH%XOEG...

Page 17 - roubleshooting; TROUBLESHOOTING PROCEDURES FOR ROMA

T roubleshooting 15 TROUBLESHOOTING PROCEDURES FOR ROMA Issue Cause What to do After installation, the unit doesn’t work. 1. The power source is not turned ON. 1. Make sure the circuit breaker and the unit’s power is ON. 2. The power line and the cable locking connector is not connecting properly. 2...

Page 18 - DESCRIPTION; List of Parts and

16 www.zephyronline.com DESCRIPTION PART# Replacement Parts /LJKW%XOE05*8:HDFK =%6 0HWDO)LOWHUHDFK Optional Accessories Recirculating Kit, ZRM-E36AS ZRC-0150 Recirculating Kit, ZRM-E42AS ZRC-0151 5HSODFHPHQW&KDUFRDO)LOWHUHDFK =)& Duct Cover Extension Kit Z1C-00RM To order parts, visit us onl...

Page 19 - STAPLE YOUR RECEIPT HERE; Tw o Ye a r L i m i t e d Wa r r a n t y f o r P a r t s :; S o m e s t a t e s o r p r o v i n c e s d o n o t; To O b t a i n S e r v i c e U n d e r L i m i t e d Wa r r a n t y :; L i m i t e d Wa r r a n t y; P r o o f o f t h e o r i g i n a l p u r c h a s e

1-888-880-8368 STAPLE YOUR RECEIPT HERE TO OBTAIN SERVICE UNDER WARRANTY OR FOR ANY SERVICE RELATED QUESTIONS, please call: Z e p h y r C o r p o r a t i o n ( r e f e r r e d t o h e r e i n a s “ w e ” o r “ u s ” ) w a r r a n t s t o t h e o r i g i n a l c o n s u m e r p u r c h a s e r ( r e ...

Zephyr ZRM-E36AS - Manual

Table of Contents:

Summary

Other Zephyr Models