Zephyr AK7536ASX - Manual - manualsarea.com

Page 3 - able of Contents

1 SAFETY NOTICE ................................................................. 2-3 LIST OF MATERIALS ....................................................... 4 INSTALLATION Ducting Calculation Sheet ....................................... 5 Mounting Height & Clearance ............................

Page 4 - Important Safety Notice; READ AND SAVE THESE INSTRUCTIONS

Important Safety Notice READ AND SAVE THESE INSTRUCTIONS 2 www.zephyronline.com WARNING TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, DO NOT USE THIS FAN WITH ANY SOLID-STATE CONTROL DEVICE. WARNING TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK, OR INJURY TO PERSONS, OBSERVE THE FOLLOWING: a. Use this u...

Page 6 - List of Materials

List of Materials 4 www.zephyronline.com MODELS: AK7500ASX, AK7536ASX, AK7548ASX PARTS SUPPLIED 1 - Hood2 - Bafﬂ e ﬁ lters AK7500ASX, 3 - AK7536ASX, 4 - AK7548ASX2 - Halogen light bulbs 3 - AK7548ASX ( pre-installed ) 1 - 10” round transition adapter ( for dual internal and external blowers ) 1 - Ex...

Page 8 - DUCTING

Installation – Mounting Height & Clearance 6 www.zephyronline.com DUCTING A minimum of 6” round or 3-1/4” x 10” rectangular duct must be used to maintain maximum air ﬂ ow efﬁ ciency for single blower and 10” round duct for dual and external blower. Always use rigid type metal ducts only. Flexibl...

Page 9 - WARNING FIRE HAZARD; Installation –

7 WARNING FIRE HAZARD NEVER exhaust air or terminate duct work into spaces between walls, crawl spaces, ceiling, attics or garages. All exhaust must be ducted to the outside. Use metal ductwork only. Fasten all connections with sheet metal screws and tape all joints with certiﬁ ed Silver Tape or Duc...

Page 10 - ext; CL; top

8 www.zephyronline.com Installation – Speciﬁ cations 29 15/16 ” (30”) 35 15/16 ” (36”) 47 15/16 ” (48”) 24” (30”)30” (36”)42” (48”) 12” *10 ” 24” 4” 18” 1 3/8 ” 9 15/16 ” 2 3/4 ” 2 3/16 ” 1 1/8 ” 8 9/16 ” 13 3/16 ” 2 5/16 ” 6 7/16 ” 2” 2 1/16 ” CL 5 9/16” ext blwr k/o elec k/o 2 11/16 ” 3 7/16 ” 1 3...

Page 16 - External Blower

14 www.zephyronline.com Installation – External Blower Preparation 1. Place 10” round adapter on top of hood and secure with (4) M4x8 screws. Connect 10” round duct work to 10” round adapter. 2. Install threaded end of external blower wiring through external blower wiring knock outlocated inside the...

Page 17 - Display; Features & Controls –

15 Blower On/Off By pressing , the blower is switched On and Off. When switched on, the blower turns on at the samespeed it was switched off at. When switched off the entire hood powers off, including the lights. Speed Selection The 3 speed levels are selected by pressing to decrease and to increase...

Page 18 - Maintenance –

16 www.zephyronline.com SURFACE MAINTENANCE: Clean periodically with hot soapy water and clean cotton cloth. Do not use corrosive or abrasive detergent, or steel wool/scouring pads which will scratch and damage surface. Do not use products containing chlorine bleach or orange cleaners. For heavier s...

Page 19 - REPLACING LIGHT BULBS

17 REPLACING LIGHT BULBS CAUTION: Light bulb becomes extremely hot when turned on. DO NOT touch bulb until switched off and cooled. Touching hot bulbs could cause serious burns. Make sure all power is turned off and bulbs are not hot. Remove by turning bulb counter clockwise. Note: Bulb does not uns...

Page 20 - roubleshooting; TROUBLESHOOTING PROCEDURES FOR TEMPEST I AND TEMPEST II

T roubleshooting 18 www.zephyronline.com TROUBLESHOOTING PROCEDURES FOR TEMPEST I AND TEMPEST II Issue Cause What to do After installation, the unit doesn’t work. 1. The power source is not turned ON. 1. Make sure the circuit breaker and the unit’s power is ON. 2. The power line and the cable lockin...

Page 21 - DESCRIPTION PART #; List of Parts and

19 DESCRIPTION PART # Replacement Parts Light Bulb MR16 (GU10) 35W (each) Z0B-0023 Bafﬂ e Filter (each) 50210004 Optional Accessories Single Internal Blower CBI-600B Dual Internal Blower PBI-1100A External Blower CBE-1000 Heat Lamp Kit (30”) AK0700B Heat Lamp Kit (36”) AK0706B Heat Lamp Kit (48”) AK...

Page 22 - STAPLE YOUR RECEIPT HERE; Te n Ye a r L i m i t e d Wa r r a n t y f o r P a r t s :; S o m e s t a t e s o r p r o v i n c e s d o n o t; To O b t a i n S e r v i c e U n d e r L i m i t e d Wa r r a n t y :; L i m i t e d Wa r r a n t y; P r o o f o f t h e o r i g i n a l p u r c h a s e

1-888-880-8368 STAPLE YOUR RECEIPT HERE TO OBTAIN SERVICE UNDER WARRANTY OR FOR ANY SERVICE RELATED QUESTIONS, please call: Z e p h y r C o r p o r a t i o n ( r e f e r r e d t o h e r e i n a s “ w e ” o r “ u s ” ) w a r r a n t s t o t h e o r i g i n a l c o n s u m e r p u r c h a s e r ( r e ...

Zephyr AK7536ASX - Manual

Table of Contents:

Summary

Other Zephyr Models