Page 3 - CONTENTS
1 CONTENTS IMPORTANT SAFETY INFO 3 COMPONENT LIST 6 ASSEMBLY INSTRUCTIONS 8 INITIAL FIRING INSTRUCTIONS 17 SUBSEQUENT START-UP 18 OPERATING TIPS 19 MAINTENANCE & CLEANING 20 TROUBLESHOOTING 22 DIGITAL THERMOSTAT CONTROL WIRING DIAGRAM 24 Z GRILLS SUPPORT 25 3-Y LIMITED WARRANTY 26
Page 4 - SAVE THIS MANUAL FOR FUTURE REFERENCE
Page 5 - IMPORTANT SAFETY INFO; GENERAL WARNINGS
3 IMPORTANT SAFETY INFO GENERAL WARNINGS Please read this entire manual before installation and use of the pellet fuel-burning appliance. Failure to follow these instructions could result in property damage, bodily injury or even death. Contact local building or fire officials about restrictions and...
Page 6 - NOTE: A MAJOR CAUSE OF FIRES IS FAILURE TO MAINTAIN REQUIRED
4 DO NOT place anything heavy on top of hopper lid. It is not a shelf and is a tip hazard. Never use gasoline, gasoline-type lantern fuel, kerosene, charcoal lighter fluid, or similar liquids to start or ‘freshen up’ a fire in this appliance. Keep all such liquids well away from the appliance when i...
Page 7 - PELLET RESTRICTIONS; CARBON MONOXIDE WARNING
5 PELLET RESTRICTIONS This grill is designed for use of wood pellets only designed for burning in wood pellet grills. Do Not Use Pellet Fuel Labeled As Having Additives. We suggest that you use Z GRILLS BBQ WOOD PELLETS, which are specifically made to work in our grills. There is no guarantee that o...
Page 8 - COMPONENT LIST
6 COMPONENT LIST ITEM QTY DESCRIPTION ITEM QTY DESCRIPTION 1 1 Grill Chamber Assembly 27 1 Smoke Stack Gasket 2 2 Furnace Hinge 28 1 Smoke Stack Assembly 3 2 Lid Hinge 29 1 Chimney Cap Assembly 4 1 Lid 30 1 Upper Hopper Safety Grate 5 1 Lid Handle 31 1 Fixed Plate 6 1 Hopper Burner Lid 32 1 Fan 7 1 ...
Page 9 - HARDWARE PACKAGE LIST
7 HARDWARE PACKAGE LIST ITEM QTY DESCRIPTION ITEM QTY DESCRIPTION A 31 Bolt 1/4-20×1/2 K 2 Cap Nut 5/16-18 B 8 Bolt 1/4-20×32 L 6 Hexagon Kep Nut 8#-32 C 18 Bolt 8#-32×3/8 M 2 Open End Wrench D 2 Pin Shaft N 4 Gasket (Ø20*Ø6.5*2.0mm) E 3 Step Screw 8#-32 O 1 Gasket (Ø6.5*Ø12*1.2mm) F 4 Hexagon Bolt ...
Page 10 - ASSEMBLY INSTRUCTIONS
8 ASSEMBLY INSTRUCTIONS PARTS DIAGRAM HOPPER BURNER ASSEMBLY
Page 19 - INITIAL FIRING INSTRUCTIONS
17 INITIAL FIRING INSTRUCTIONS Please read this manual carefully and follow it step by step before starting your Z Grills for the first time and each time the grill runs out of pellets. 1.Remove the Porcelain Grills, Grease Drain Pan and Heat Baffle from the interior of the grill. 2.Open the Pellet ...
Page 20 - SHUTDOWN CYCLE
18 SUBSEQUENT START-UP ATTENTION: If the grill fails to light or the fire in the Firepot goes out while cooking, it is vital to follow these steps when sufficient pellets are still in the Pellet Hopper. Failure to follow the steps may cause a hazardous “ over-firing ” of your grill due to an excess ...
Page 21 - OPERATING TIPS
19 OPERATING TIPS 1.Like all grills, the actual temperature of this grill and the cooking times will be affected by external temperature, humidity, wind conditions, quality of pellets, etc. 2.It is beneficial to shelter your grill from the wind. This will aid in temperature output, heat retention an...
Page 22 - MAINTENANCE & CLEANING
20 MAINTENANCE & CLEANING Your Z GRILL requires regular maintenance. Make sure your grill is OFF, unplugged and completely cold before performing any maintenance and cleaning. Grease 1.With regular use your grill will accumulate grease on the Flue Lining, the Grease Drain Tube, the V-shaped Grea...
Page 24 - TROUBLESHOOTING
22 TROUBLESHOOTING CAUTION: Make sure the grill is completely cool and unplugged before you do any inspection, cleaning, maintenance or service work. Problem Potential Cause Solution Grill does not work properly Power Make sure the power cord is plugged in. Verify there is power at the electrical ou...
Page 25 - ERROR CODES
23 ERROR CODES LEr (Low Temperature Alarm ) Grill temperature was below 120 ℉ for more than 20 minutes. HEr (High Temperature Alarm ) Grill temperature reached 550 ℉ . Er 1 Ensure temperature probe is properly connected to the controller board. Er 2 Temperature dial security alarm. Turn the ...
Page 26 - DIGITAL THERMOSTAT CONTROL WIRING DIAGRAM
Page 27 - Z GRILLS SUPPORT
25 Z GRILLS SUPPORT Thank you for purchasing a Z GRILL! If you have any question, please contact customer support or your Z GRILL dealer. Z GRILLS, INC. offers the best technical and sales support in the industry. When calling customer please be prepared to provide the following information: 1.Deale...