Page 3 - INTRODUCTION; Welcome to the Yamaha world of motorcycling!
EAU00001 INTRODUCTION 1 2 4 5 6 7 8 9 Welcome to the Yamaha world of motorcycling! As the owner of a YP250, you are benefiting from Yamaha’s vast experience in and newest technolo-gy for the design and the manufacture of high-quality products, which have earned Yamaha a reputa-tion for dependability...
Page 4 - IMPORTANT MANUAL INFORMATION
EAU00005 IMPORTANT MANUAL INFORMATION 1 2 3 4 5 6 7 8 9 Particularly important information is distinguished in this manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETYIS INVOLVED! Failure to follow WARNING instructions could result in severe injury o...
Page 7 - TABLE OF CONTENTS
EAU00009 TABLE OF CONTENTS 1 GIVE SAFETY THE RIGHT OF WAY 2 DESCRIPTION 3 INSTRUMENT AND CONTROL FUNCTIONS 4 PRE-OPERATION CHECKS 5 OPERATION AND IMPORTANT RIDING POINTS 6 PERIODIC MAINTENANCE AND MINOR REPAIR 7 SCOOTER CARE AND STORAGE 8 SPECIFICATIONS 9 CONSUMER INFORMATION INDEX 9 8 7 6 5 4 3 2 1...
Page 9 - GIVE SAFETY THE RIGHT OF WAY
GIVE SAFETY THE RIGHT OF WAY GIVE SAFETY THE RIGHT OF WAY ................................................1-1FURTHER SAFE RIDING POINTS FOR THIS MODEL ....................1-2 1 5GM-9-E0 4/13/0 9:05 PM Page 7
Page 11 - FURTHER SAFE RIDING POINTS FOR THIS MODEL; Be sure to signal clearly when making turns.
1-2 Q GIVE SAFETY THE RIGHT OF WAY 1 2 3 4 5 6 7 8 9 EAU03099* FURTHER SAFE RIDING POINTS FOR THIS MODEL 8 Be sure to signal clearly when making turns. 8 Braking can be extremely difficult on a wet road. Avoid hard braking, because the scooter couldslide. Apply the brakes slowly when stopping on a w...
Page 13 - DESCRIPTION
DESCRIPTION Left view .............................................................................................2-1Right view ...........................................................................................2-2Controls/Instruments ...........................................................
Page 14 - Rear storage compartment; Left view
EAU00026 DESCRIPTION 1 2 3 4 5 6 7 8 9 2-1 1. Rear storage compartment (page 3-14) 2. Grab bar (Page 5-2) 3. Rear shock absorber spring preload adjusting ring (page 3-15) 4. Air filter (page 6-16) 5. V-belt case air filter (page 6-17) 6. Centerstand (page 6-24) 7. Sidestand (page 3-16) 8. Fuel tank ...
Page 15 - Coolant reservoir tank; Right view
DESCRIPTION 1 2 3 4 5 6 7 8 9 2-2 9. Rider seat (page 3-12) 10. Air flow louver (page 6-18) 11. Headlight (page 6-28) 12. Radiator13. Battery (page 6-26) 14. Fuse box (page 6-27) 15. Coolant reservoir tank (page 6-15) 16. Coolant level check window (page 6-15) 17. Engine oil dipstick (page 6-11) 9 1...
Page 17 - INSTRUMENT AND CONTROL FUNCTIONS
INSTRUMENT AND CONTROL FUNCTIONS Main switch/steering lock....................................................................3-1Indicator lights ....................................................................................3-2Oil change indicator light circuit check .............................
Page 18 - Main switch/steering lock; clockwise until it stops.
3-1 I G N I TI O N P LOCK ON OFF OPEN PUSH PUSH EAU00029 Main switch/steering lock The main switch controls the ignitionand lighting systems. Its operation isdescribed below. EAU00036 ONElectrical circuits are switched on.The engine can be started. The keycannot be removed in this position. EAU00038...
Page 19 - Indicator lights
3-2 0.0 1.00 . 1 3 4 2 EAU00056 Indicator lights EAU00078 Oil change indicator light “ 7 ” When this indicator light comes on,the engine oil should be changed. Itwill come on at the initial 1,000 kmand every 3,000 km thereafter. (Referto “Engine oil replacement” for reset-ting procedures.)The oil ch...
Page 20 - Oil change indicator light circuit check
3-3 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 EAU00076 Oil change indicator light circuit check Electrical circuit is OK.Go ahead with riding. Turn the main switch to “ON”.Turn the engine stop switch to “ # ”. Indicator light comeson for a few secondsand then goes off. Indicator light doesn...
Page 21 - Diagnosis device
3-4 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 0.0 1.00 . 1 2 3 EAU01586 Speedometer The speedometer shows ridingspeed. This speedometer is equippedwith a digital odometer and a tripodometer.Pushing the “TRIP” reset button willchange the display from one to theother.When set to “ODO”, the di...
Page 22 - Coolant temperature gauge
3-5 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 1 EAU00109 Antitheft alarm (optional) An antitheft alarm can be equipped tothis scooter. Consult your Yamahadealer to obtain and install the alarm. EAU00110 Fuel gauge This model is equipped with an elec-tric fuel gauge so the rider can moni-tor...
Page 23 - Digital clock; To set the clock; Handlebar switches; Pass switch “; ” for the high
3-6 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 1.00 . 1 2 3 1. Hour button “h” 2. Minute button “m” 3. Digital clock EAU03089* Digital clock This digital clock shows the timeregardless of the main switch posi-tion. To set the clock 1. Turn the key to “ON”.2. The time (hour) setting can be ma...
Page 24 - turn, push the switch to “; Horn switch “; Press the switch to sound the horn.
3-7 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 1 2 3 4 EAU00127 Turn signal switchTo signal a right-hand turn, push theswitch to “ 6 ”. To signal a left-hand turn, push the switch to “ 4 ”. Once the switch is released it will return tothe center position. To cancel the sig-nal, push the swit...
Page 25 - Headlight beam variation
3-8 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 1 2 % % & & Left Right Aux Bulb to be used Destination 2 1 1 3 1 3 2 1 Halogenbulb Halogenbulb Germany, Belgium, Switzerland, SpainFrance, Greece, Italy, Netherlands,Norway, Portugal, Sweden England 3 : High beam light on 2 : Low beam li...
Page 26 - Start switch “; Front brake lever; ” to start the
3-9 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 EAU00143 Start switch “ , ” The starter motor cranks the enginewhen pushing the start switch. EC000005 c C See starting instructions prior tostarting the engine. 1 1. Front brake lever EAU00158 Front brake lever The front brake lever is located ...
Page 27 - Rear brake lever
3-10 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 1 1. Rear brake lever EAU00163 Rear brake lever The rear brake lever is located on theleft handlebar. Pull it toward the han-dlebar to apply the rear brake. 1 2 EAU03090* Fuel tank cap The fuel tank cap is located under thelid in front of the s...
Page 28 - Fuel
3-11 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 To close the cap, align the matchmarks and push down on the cap.Then, turn the key to the originalposition and remove it. Close the lid. EWA00028* w Be sure the cap is properlyinstalled and locked in placebefore riding the scooter. 1 2 EAU01183...
Page 29 - Catalyzer; Rider seat
3-12 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 EAU03098* Catalyzer This scooter is equipped with a cat-alytic converter in the muffler. EW000128 w The exhaust system is hot duringand directly after engine operation.Make sure the exhaust system hascooled down before making anyadjustment to o...
Page 30 - Rider seat adjustment
3-13 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 NOTE: 8 Place the scooter on the center-stand before opening the riderseat. 8 Make sure the rider seat issecurely closed before riding thescooter. 1 EAU03096* Rider seat adjustment The rider seat can be adjusted tochange the riding position. 1....
Page 31 - Storage compartments
3-14 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 1 2 1. Button 2. Lid EAU03110* Storage compartments Front storage compartment ATo open the storage compartmentwhen it is locked, insert the key, turnit counterclockwise, grasp the lockwhile pushing the button in.To open the storage compartmentw...
Page 32 - to decrease spring pre-
3-15 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 ECA00051* c C Do not leave the rider seat openfor an extended period of time asthe light may cause the battery todischarge. EWA00030* w Do not exceed the loading limits:Front storage compartment A: 2 kgRear storage compartment: 5 kg EW000040 w ...
Page 33 - Sidestand
3-16 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 EAU03092* Carrier (optional) An optional carrier can be obtainedand installed at a Yamaha dealer foradding cargo or accessories to thisscooter. EAU00330 Sidestand This model is equipped with an igni-tion circuit cut-off system. The scoot-er mus...
Page 34 - Put the sidestand up.
3-17 INSTRUMENT AND CONTROL FUNCTIONS 1 2 3 4 5 6 7 8 9 1 EAU00337 Sidestand switch operationcheck Check the operation of the sidestandswitch against the information below. EW000046 w 8 8 Be sure to use the centerstandduring this inspection. 8 8 If improper operation is noted,consult a Yamaha dealer...
Page 36 - PRE-OPERATION CHECK LIST
4-1 Owners are personally responsible for their vehicle’s condition. Your scooter’s vital functions can start to deterioratequickly and unexpectedly, even if it remains unused (for instance, if it is exposed to the elements). Any damage, fluidleak or loss of tire pressure could have serious conseque...
Page 37 - OPERATION AND IMPORTANT RIDING POINTS
OPERATION AND IMPORTANT RIDING POINTS Starting a cold engine .........................................................................5-1Starting off ..........................................................................................5-2Acceleration ...............................................
Page 38 - Never start your engine or let; Starting a cold engine; Turn the main switch to “ON” and; OPERATION AND IMPORTANT RIDING POINTS
5-1 EAU01118 w 1. Before riding this scooter, become thoroughly familiarwith all operating controls andtheir functions. Consult aYamaha dealer regarding anycontrol or function that you donot thoroughly understand. 2. Never start your engine or let it run for any length of time ina closed area. The e...
Page 39 - Starting off
5-2 OPERATION AND IMPORTANT RIDING POINTS 1 2 3 4 5 6 7 8 9 EAU00433 Starting off After warming up the engine: 1. Apply the rear brake lever with your left hand and hold the grabbar with you right hand. Thenpush the scooter off the center-stand. 2. Sit astride the seat and adjust the rear view mirro...
Page 41 - Parking
5-4 1,600 km and beyondProceed with normal riding. EC000049 c C If any engine trouble should occurduring the break-in period, consulta Yamaha dealer immediately. EAU00461 Parking When parking the scooter, stop theengine and remove the ignition key. EW000059 w The muffler and exhaust pipe arehot. Par...
Page 43 - PERIODIC MAINTENANCE AND MINOR REPAIR
PERIODIC MAINTENANCE AND MINOR REPAIR Tool kit ....................................................................6-1Periodic maintenance and lubrication .....................6-3Panel removal and installation ................................6-6Panel A ..................................................
Page 46 - PERIODIC MAINTENANCE AND LUBRICATION
6-3 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU00473 PERIODIC MAINTENANCE AND LUBRICATION Initial EVERY ANNUAL No. ITEM CHECKS AND MAINTENANCE JOB (1,000 km) 10,000 km 20,000 km CHECK 1 * Fuel line 9 Check fuel hoses and vacuum hose for cracks or damage. √ √ 9 Replace if necessary. 2...
Page 48 - Hydraulic brake service
6-5 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 * Since these items require special tools, data and technical skills, they should be serviced by a Yamaha dealer. EAU03206 NOTE: 8 The annual checks must be performed every year, except if a 10,000 km or 20,000 km maintenance is performedin...
Page 50 - To install; Insert the tabs on the panel into; Panel A; To remove
6-7 2 1 1. Tab ( × 2) 2. Slot ( × 2) To install 1. Insert the tabs on the panel into the slots as shown, and thenpush the panel in until it snapsinto place. 2. Install the screws. PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU03114* Panel A To remove 1. Remove the screws. 2. Pull the pa...
Page 51 - Pull up the left floorboard mat as
6-8 1 2 EAU03121* Panel B To removeRemove the bolts, and then pull thepanel out as shown. To installPlace the panel in the original posi-tion, and then install the bolts. EAU03122* Panel C To remove 1. Pull up the left floorboard mat as shown. 1. Bolt ( × 2) 2. Panel B PERIODIC MAINTENANCE AND MINOR...
Page 53 - Spark plug; Removal; Use the spark plug wrench in the; Specified spark plug:
6-10 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 1 EAU01833 Spark plug Removal 1. Remove the spark plug cap. 2. Use the spark plug wrench in the tool kit to remove the spark plugas shown. 1. Spark plug cap 1. Spark plug wrench InspectionThe spark plug is an importantengine component an...
Page 54 - Installation; Measure the electrode gap with; Engine oil; Oil level measurement
6-11 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 NOTE:If a torque wrench is not availablewhen you are installing a spark plug,a good estimate of the correct torqueis 1/4 to 1/2 turn past finger tight.Have the spark plug tightened to thespecified torque as soon as possible. 4. Install the...
Page 55 - Stop the engine and remove the; Engine oil replacement; Warm up the engine for a few
6-12 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 1. Drain bolt 2. Stop the engine and remove the oil filler cap. NOTE:Wait a few minutes until the oil settlesbefore checking. 3. Wipe the oil off the dipstick. Insert the dipstick back into theengine oil filler hole, but do notscrew it i...
Page 56 - Fill the engine with oil and install; II; Start the engine and warm it up
6-13 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 6. Fill the engine with oil and install the oil filler cap. EC000030 c C 8 8 Do not put in any chemicaladditives or use oils with agrade of CD or higher. Also, besure not to use oils labeled“ENERGY CONSERVING II ” or higher. 8 8 Be sure ...
Page 57 - Final gear oil replacement
6-14 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 1 1. Final gear oil filler cap 1. Drain bolt EAU03120* Final gear oil replacement 1. Put the scooter on the center- stand. 2. Place an oil pan under the final gear case to catch the oil. 3. Remove the oil filler cap and the drain bolt to...
Page 58 - Coolant; Reservoir tank capacity:
6-15 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 2 1 EAU01587 Coolant The coolant reservoir tank is locatedunder the battery cover. (See page 6-26 for battery cover removal proce-dures.)Check the coolant level in the reser-voir tank when the engine is cold.The coolant level will vary w...
Page 60 - cover by removing the screws.
6-17 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 2 1 1 1. V-belt case air filter cover 2. Screw ( × 3) 1. V-belt case air filter 8. Remove the V-belt case air filter cover by removing the screws. 9. Remove the V-belt case air filter element and blow out the dirtwith compressed air from t...
Page 61 - Tires
6-18 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU00675 Tires To ensure maximum performance,long service and safe operation, notethe following:Tire air pressureAlways check and adjust the tirepressure before operating the scoot-er. EAU03094* Air flow louver Opening the air flow louver ...
Page 63 - Wheels
6-20 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EW000079 w Operating the scooter with exces-sively worn tires decrease ridingstability and can lead to loss ofcontrol. Have excessively worntires replaced by a Yamaha dealerimmediately. Brakes, tires, andrelated wheel parts replacementshou...
Page 64 - to
6-21 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 2 b a 3 The rear brake lever free play shouldbe adjusted to 2 ~ 5 mm at the brakelever end.Loosen the locknut and turn theadjusting bolt in direction a to increase free play and in direction b to decrease free play.Be sure to tighten the...
Page 65 - Recommended brake fluid:
6-22 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 EAU00731 Inspecting the brake fluidlevel Insufficient brake fluid may let airenter the brake system, possiblycausing the brakes to become inef-fective.Before riding, check that the brakefluid is above the minimum level andreplenish when ...
Page 66 - Brake fluid replacement; Brake lever lubrication; Recommended lubricant:
6-23 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU00742 Brake fluid replacement The brake fluid should be replacedonly by trained Yamaha service per-sonnel. Have the Yamaha dealerreplace the following componentsduring periodic maintenance or whenthey are damaged or leaking: 8 oil seals...
Page 67 - Front fork inspection; Visual check; Place the scooter on a level
6-24 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU02965 Center and sidestand lubrication Lubricate the pivoting and matingjoints.Check to see that the center andsidestand move up and downsmoothly. EW000114 w If the center and/or sidestand doesnot move smoothly, consult aYamaha dealer. ...
Page 68 - Steering inspection
6-25 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU00794 Steering inspection Periodically inspect the condition ofthe steering. Worn out or loose steer-ing bearings may be dangerous.Place a stand under the engine toraise the front wheel off the ground.Hold the lower end of the front for...
Page 69 - Battery cover removal; Battery
6-26 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU00796 Battery cover removal Pull up the right floorboard mat asshown. Then remove the screws andthe battery cover. NOTE:The battery cover needs to beremoved to access the fuse box andthe coolant reservoir tank cap. 1 2 1. Screw ( × 2) 2...
Page 70 - Fuse replacement; Remove the battery cover by
6-27 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EW000116 w Battery electrolyte is poisonousand dangerous, causing severeburns, etc. It contains sulfuricacid. Avoid contact with skin, eyesor clothing.ANTIDOTE: 8 8 EXTERNAL: Flush with water. 8 8 INTERNAL: Drink large quanti-ties of water...
Page 71 - Headlight bulb replacement; Disconnect the headlight coupler
6-28 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 2. If a fuse is blown, turn off the ignition switch and the switch ofthe circuit in question. Install anew fuse of specified amperage.Turn on the switches, and see ifthe electrical device operates. Ifthe fuse immediately blowsagain, consul...
Page 72 - Unhook the bulb holder to
6-29 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 1 4. Unhook the bulb holder to remove the defective bulb. EW000119 w Keep flammable products and yourhands away from a bulb while it ison, as it is hot. Do not touch a bulbuntil it cools down. 1. Bulb holder ( × 2) 5. Put a new bulb into p...
Page 73 - Remove the defective bulb by
6-30 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU03115* Tail/brake light bulb replacement 1. Place the scooter on the center- stand. 2. Remove panel A. (See page 6-6 for panel removal and installationprocedures.) 1 1. Bulb socket ( × 2) 3. Turn the tail/brake light bulb socket counter...
Page 75 - Remove the screws holding the
6-32 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU03117* License light bulb replacement 1. Place the scooter on the center- stand. 2. Remove panel A. (See page 6-6 for panel removal and installationprocedures.) 1 3. Remove the screws holding the license light lens. 1. Screw ( × 2) 1 4....
Page 76 - Troubleshooting
6-33 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU01008 Troubleshooting Although Yamaha scooter receive arigid inspection before shipment fromthe factory, trouble may occur duringoperation.Any problem in the fuel, compres-sion, or ignition systems can causepoor starting and loss of pow...
Page 77 - Troubleshooting charts
6-34 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 EAU01581* Troubleshooting charts EW000125 w Never check the fuel system while smoking or in the vicinity of an open flame. 1. Fuel 2. Compression 3. Ignition 4. Battery Remove spark There is compression. Go to ignition check. No compressio...
Page 78 - Engine overheating
6-35 PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 7 8 9 Engine overheating EW000070 w Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may beblown out under pressure, which could cause serious injury. Open the radiator cap as follows. Wait until ...
Page 79 - SCOOTER CARE AND STORAGE
SCOOTER CARE AND STORAGE Care ....................................................................................................7-1Storage ...............................................................................................7-4 7 5GM-9-E0 4/13/0 9:10 PM Page 77
Page 80 - Care; Before cleaning; Cover up the muffler outlet with a
7-1 Care The exposure of its technologymakes a scooter charming but alsovulnerable. Although high-qualitycomponents are used, they are notall rust-resistant. While a rustyexhaust pipe may remain unnoticedon a car, it does look unattractive ona scooter. Frequent and proper care,however, will keep you...
Page 81 - Clean your scooter with cold
7-2 SCOOTER CARE AND STORAGE 1 2 3 4 5 6 7 8 9 8 8 Improper cleaning can damagewindshields, cowlings, panelsand other plastic parts. Useonly a soft, clean cloth orsponge with mild detergentand water to clean plastic. 8 8 Do not use any harsh chemicalproducts on plastic parts. Besure to avoid using c...
Page 82 - After cleaning
7-3 SCOOTER CARE AND STORAGE 1 2 3 4 5 6 7 8 9 After cleaning 1. Dry the scooter with a chamois or an absorbing cloth. 2. Use a chrome polish to shine chrome, aluminum and stainless-steel parts, including the exhaustsystem. (Even the thermallyinduced discoloring of stainless-steel exhaust systems ca...
Page 83 - Storage
7 SCOOTER CARE AND STORAGE 7-4 Storage Short-termAlways store your scooter in a cool,dry place and, if necessary, protect itagainst dust with a porous cover. ECA00015 c C 8 8 Storing the scooter in a poorlyventilated room or covering itwith a tarp while it is still wetwill allow water and humidityto...
Page 84 - Lubricate all control cables and
7-5 SCOOTER CARE AND STORAGE 1 2 3 4 5 6 7 8 9 6. Lubricate all control cables and the pivoting points of all leversand pedals as well as of thesidestand/centerstand. 7. Check and, if necessary, correct the tire air pressure, then raisethe scooter so that both of itswheels are off the ground.Alterna...
Page 85 - SPECIFICATIONS
SPECIFICATIONS Specifications .....................................................................................8-1How to use the conversion table ........................................................8-5 8 5GM-9-E0 4/13/0 9:10 PM Page 83
Page 86 - Specifications
Specifications Model YP250 Dimensions Overall length 2,140 mm Overall width 780 mm Overall height 1,350 mm Seat height 730 mm Wheelbase 1,535 mm Ground clearance 120 mm Minimum turning radius 2,700 mm Basic weight (with oil and fullfuel tank) 168 kg Engine Engine type Liquid-cooled 4-stroke, SOHC Cy...
Page 90 - HOW TO USE THE CONVERSION TABLE; METRIC
1 2 3 4 5 6 7 8 9 8-5 SPECIFICATIONS EAU01064 HOW TO USE THE CONVERSION TABLE All specification data in this manual are listed in SI andMETRIC UNITS.Use this table to convert METRIC unit data to IMPERIAL unit data. Ex. METRIC MULTIPLIER IMPERIAL ** mm × 0.03937 = ** in 2 mm × 0.03937 = 0.08 in METRI...
Page 91 - CONSUMER INFORMATION
CONSUMER INFORMATION Identification number records .............................................................9-1Key identification number ...................................................................9-1Vehicle identification number...............................................................
Page 94 - INDEX
INDEX EEngine break-in .......................................5-3Engine oil...............................................6-11Engine stop switch ..................................3-9 FFinal gear oil replacement .....................6-14Front brake lever .....................................3-9Front ...
