Wells 9421 (SS2-HE) - Manual

Page 2 - WARRANTY STATEMENT; xi

NOTE: For your protection, please note that equipment in this shipment was carefully inspected and packaged by skilled personnel before leaving the factory. Upon accep-tance of this shipment, the transportation company assumes full responsibility for its safe delivery. IF SHIPMENT ARRIVES DAMAGED: 1...

Page 3 - not provided

TABLE OF CONTENTS Thank You for purchasing this Bloomfield Industries appliance. Proper installation, professional operation and consistent maintenance of this appliance will ensure that it gives you the very best performance and a long, economical service life. This manual contains the information ...

Page 4 - FEATURES AND OPERATING CONTROLS; Fig 1. SS-2 Satellite Brewing System Features & Operating Controls

FEATURES AND OPERATING CONTROLS 2 Fig 1. SS-2 Satellite Brewing System Features & Operating Controls

Page 5 - ON MODE

FEATURES AND OPERATING CONTROLS (continued) Brewer Adjustable Legs Brewing Controls Digital Readout Bypass Nozzle Hot Water Faucet Nameplate Power Key System Switch (not shown) Satellite Locator/Warmer Warmer Switches Brew Chamber Brew Chamber Wire Rack Satellite Brew-Thru Lid Handles Nameplate Serv...

Page 6 - DO NOT submerge satellites in water.; GENERAL INFORMATION AND PRECAUTIONS

This appliance is intended for use in commercial establishments only. This appliance is intended to brew hot beverage, specifically coffee, for human consumption. No other use is recommended or authorized by the manufacturer or its agents. Operators of this appliance must be familiar with the applia...

Page 7 - INSTALLATION INSTRUCTIONS; INSTALL LEGS; If water pressure varies greatly, or exceeds 90 psi at any; ELECTRICIAN’S INSTALLATION INSTRUCTIONS; Brewer requires a dedicated single-phase circuit:

5 INSTALLATION INSTRUCTIONS INSTALL LEGS The brewer is provided with 4" adjustable legs and rubber feet. Be sure the legs are securely screwed into the base of the brewer, and that the rubber feet are properly installed. LEVEL THE UNIT The adjustable legs allow the brewer to be leveled. Set the ...

Page 8 - INITIAL SET-UP INSTRUCTIONS; ON; FINAL CHECKS

INSTALLATION INSTRUCTIONS (continued) 6 IMPORTANT: Initial set-up must be performed by a qualified installer or qualified service technician. Improper set-up will damage the brewer and void the warranty. DO NOT CONNECT POWER TO BREWER WITH SATELLITES IN PLACE. NOTE: If “NO WATER SENSED” error messag...

Page 9 - GETTING STARTED; Check the brewer and satellites:; OPERATING INSTRUCTIONS; Fig. 3 Control Panel

7 NOTE: If water is not sensed at the water level sensor within 20 minutes: Heater will be disabled Error message NO WATER SENSED will be displayed Call the PHONE NUMBER displayed for service. GETTING STARTED Check the brewer and satellites: Check that the brewer is clean and the drip tray (if used)...

Page 10 - GALLON; or; START BREW; the selected side will glow.; BREW STOP

OPERATING INSTRUCTIONS (continued) Fig. 4 Operating Controls Fig. 5 Brew Basket CAUTION: Burn Hazard Basket and contents are hot to the touch and may cause burns on contact. BREWING COFFEE Prepare the Brew Baskets: Make sure the wire rack is properly installed in each brew chamber. Insert one (1) Bl...

Page 11 - WATER FLOW; Fig. 6 Water Flow Diagram; INLET

9 OPERATING INSTRUCTIONS (continued) WATER FLOW Fig. 6 Water Flow Diagram INLET The INLET VALVE is controlled by a signal from the CONTROL BOARD. If the WATER LEVEL PROBE does not detect water, the inlet solenoid is opened until water is again sensed. BREW The BREW VALVE fed by gravity from the hot ...

Page 12 - CLEANING INSTRUCTIONS

CLEANING INSTRUCTIONS 10 CLEANING INSTRUCTIONS CAUTION: Burn Hazard Brewing and serving temperatures of coffee are extremely hot. Hot coffee will cause serious skin burns. WARNING: Electric Shock Hazard DO NOT immerse or submerge satellites. Fluid may saturate the insulation and short-circuit the re...

Page 13 - PROCEDURE: Clean Satellite; Sight Glass

11 CLEANING INSTRUCTIONS (continued) PROCEDURE: Clean Satellite PRECAUTIONS: Drain Satellite before Cleaning FREQUENCY: Twice Weekly TOOLS: Sight Glass Brush, Sanitizer Soft Clean Cloth, Bucket 1. Remove and drain satellites. Remove lids. 2. Place 1 packet of Sanitizer into 2-1/2 gallons of warm tap...

Page 14 - PROGRAMMING INSTRUCTIONS; Fig. 7 Function Keys; NEW MENU SETTINGS

PROGRAMMING INSTRUCTIONS Fig. 7 Function Keys NEW MENU SETTINGS Menu Program: Press POWER key to enter OFF mode. Press and hold 3rd & 6th keys for 3 seconds Advance thru menus by pressing the 1st key Advance thru items by pressing the 3rd key To exit, press 2nd key Clock Settings: Press POWER ke...

Page 15 - Brew Wait; FEATURES; Energizing the Brewer:; POWER; filling...

PROGRAMMING INSTRUCTIONS (continued) 13 PRECISE BREWING TEMPERATURE™: The brew cycle will not start until the water in the tank is at the proper temperature. If START BREW key is pressed and held for 3 seconds during “ Brew Wait ” the brew will proceed immediately. Note: the following safety feature...

Page 19 - TROUBLESHOOTING SUGGESTIONS; DESCRIPTION OF PROBLEM

17 TROUBLESHOOTING SUGGESTIONS DESCRIPTION OF PROBLEM POSSIBLE CAUSE SUGGESTED REMEDY No lights or heat Unit not plugged in or circuit breaker tripped Reset circuit breaker Plug brewer into electric power Power switch OFF Turn power switch ON No heat Hi-limit safety tripped Allow brewer to cool, ver...

Page 22 - EXPLODED VIEW CABINET AND EXTERIOR COMPONENTS

Page 24 - EXPLODED VIEW INTERIOR COMPONENTS

EXPLODED VIEW INTERIOR COMPONENTS 22 26 32 38 39 36 33 3 41 1 14 30 29 21 19 16 17 47 18 5 8 6 7 37 42 43 45 31 3 9 15 40 48 49 30 34 46 10 34 50 13 4 27 3 28 24 22 44 12 25 27 20 35 11 2 23 29

Page 26 - WIRING DIAGRAM

Page 27 - SATELLITE EXPLODED VIEW & PARTS LIST; DESCRIPTION

25 SATELLITE EXPLODED VIEW & PARTS LIST SATELLITE MODEL 9440 ITEM PART NO. DESCRIPTION QTY 1 WELDMENT, SATELLITE 1 2 83863 TANK LID ASSY 1 3 84313 HANDLE / FAUCET GUARD 1 4 84341 FAUCET & SHANK ASSY 1 4.1 84390 FAUCET, MODEL ES 1 4.2 8700-25L SEAT CUP, #3S10 1 4.3 84392 HANDLE, #13SBE-SNAP 1...

Wells 9421 (SS2-HE) - Manual

Table of Contents:

Summary

Other Wells Models