Vulcan ML-136096 - Manual
Vulcan ML-136096 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – IMPORTANT FOR YOUR SAFETY
- Page 3 – CONTENTS
- Page 4 – INSTALLATION, OPERATION AND; SAVE THESE INSTRUCTIONS FOR FUTURE USE; GENERAL; MODEL CHART
- Page 5 – INSTALLATION; UNPACKING; Vapor Removal from Cooking Equipment
- Page 6 – GAS CONNECTIONS; water solution. Do not use an open flame.
- Page 7 – in gas piping systems are provided for reference.
- Page 8 – GAS AND ALTITUDE CONVERSION
- Page 9 – Remove the right side controls compartment side panel.; FLUE; All kettles are supplied with a 120 Volt power cord.
- Page 10 – LOCATION; The kettle draw off valve should be located near a floor drain.; Stationary Kettle
- Page 11 – Tilting Kettle; LEVELING
- Page 12 – OPERATION; CONTROLS AND INDICATORS; Control
- Page 13 – Check to make sure gas supply valve is turned on.
- Page 15 – STAINLESS STEEL EQUIPMENT CARE AND CLEANING; Enemies of Stainless Steel; Mechanical abrasion; and scrapers are prime examples.; Water; Here are a few steps that can help prevent stainless steel rust.
- Page 16 – Job
- Page 17 – CLEANING; COMPRESSION DRAW-OFF VALVE CLEANING INSTRUCTIONS
- Page 18 – PLUG VALVE CLEANING INSTRUCTIONS; Leave assembly apart to air dry.
- Page 19 – MAINTENANCE; VENTING; With the kettle empty, place the power switch to the ON position.; or servicing the kettle.; If the reading is not correct, repeat steps 1 through 3.; FILLING THE RESERVOIR JACKET; Set the thermostat and power switch to OFF position.; SHUTDOWN; Parts and service are also available at
- Page 20 – TROUBLESHOOTING; Problem
INSTALLATION &
OPERATION MANUAL
GAS 2/3 JACKETED
STATIONARY AND
TILTING KETTLES
MODELS
K20GL
ML-136090
K40GL
ML-136091
K60GL
ML-136092
K20GLT
ML-136094
K40GLT
ML-136095
K60GLT
ML-136096
K40GL
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at www.vulcanequipment.com
VULCAN-HART
DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC
3600 NORTH POINT BLVD.
BALTIMORE, MD 21222
FORM 35461 (June 2012)
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
GAS KETTLES — 2 — IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GAS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. POST IN A PROMINENT LOCATION THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT...
GAS KETTLES — 3 — CONTENTS GENERAL ...........................................................................................................................................4 INSTALLATION ..................................................................................................................
GAS KETTLES — 4 — INSTALLATION, OPERATION AND MAINTENANCE OF KGL AND KGLT SERIES GAS KETTLES SAVE THESE INSTRUCTIONS FOR FUTURE USE GENERAL Vulcan gas 2/3 jacketed kettles are produced with quality workmanship and material. Proper installation, usage and maintenance will result in many years of sati...
