Vulcan 1GR45AF - Manual
Vulcan 1GR45AF – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – IMPORTANT FOR YOUR SAFETY
- Page 3 – TABLE OF CONTENTS
- Page 4 – INTRODUCTION; GENERAL; ORDERING PARTS; FRYER CAPACITY; UNPACKING
- Page 5 – PLUS®; INSTALLATION
- Page 6 – CODES AND STANDARDS; In the United States:
- Page 7 – Local; ASSEMBLY; Make the flue connection as follows:
- Page 8 – GAS CONNECTION; All gas supply connections and any pipe joint compound must be; Prior to lighting, check all joints in the gas supply line for leaks.
- Page 9 – The fryer must be installed with the casters provided.; ELECTRICAL CONNECTION; Electrical Grounding Instructions:
- Page 10 – LEVELING THE FRYER; Hot oil and parts can cause burns. Use care when operating,; OVER-TEMPERATURE SHUTDOWN; Do not use chlorine or sulfate/sulfide cleaners.
- Page 11 – FILLING TANK WITH SHORTENING
- Page 12 – Fry Basket Capacity:; EXTENDING SHORTENING LIFE
- Page 13 – TURNING ON THE FRYER; Set temperature by turning the knob to the desired temperature.; TURNING OFF THE FRYER
- Page 15 – EXTENDED SHUTDOWN; Hot oil and hot parts can cause burns. Use care when operating,
- Page 16 – DRAINING THE TANK; Then clean-out as described under CLEANING.; BOIL OUT PROCEDURE; Drain the tank as described under FILTERING THE OIL.
- Page 17 – CLEANING
- Page 18 – KleenScreen Plus® Filtration System; Installation and Operational Manual for “AF” Models
- Page 19 – Filtering Instructions for KleenScreen PLUS® Fryers; General; The KleenScreen; Assembly; Filter Insert
- Page 20 – Fully assembled filter screen assembly:; Same Suction Tube
- Page 22 – Operation; will void your fryer warranty.
- Page 24 – REMOVING EXCESS DEBRIS FROM THE SCREEN FILTER:; insert by unlatching the latch. Clean all parts thoroughly.
- Page 25 – Do not allow water to run through the motor / pump.; Boil Out By-PassTM Extension Tube
- Page 26 – MAINTENANCE; FLUE VENT INSPECTION; Probable
INSTALLATION & OPERATIONAL MANUAL
1GRA & GRAF SERIES GAS FRYERS
VFRY18 & VFRY18F HDR FRYERS
With KleenScreen PLUS® Filtration Systems
MODELS:
1GR45A ML-136647
1GR65A
ML-136648
1GR85A
ML-136649
1GR45AF
ML-136798
1GR65AF
ML-136795
1GR85AF
ML-136796
2GR45AF
ML-136650
3GR45AF
ML-136653
4GR45AF
ML-136656
2GR65AF
ML-136651
3GR65AF
ML-136654
2GR85AF
ML-136652
3GR85AF
ML-136655
1GR45A Shown -
Solid State Control
VFRY18
Secured Behind the Door
VFRY18F
VFRY18
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at
www.VulcanHart.com
VULCAN-HART
3600
NORTH
POINT
BLVD.
DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC
BALTIMORE, MD 21222
www.VulcanHart.com
F-32934 REV. J (August 2012)
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
GRA, GRAF, & VFRY GAS FRYERS & VFRY SERIES HD FRYERS VULCAN-HART F-32934 Rev. J (August 2012) -2- IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GAS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED B...
GRA, GRAF, & VFRY GAS FRYERS & VFRY SERIES HD FRYERS VULCAN-HART F-32934 Rev. J (August 2012) -3- TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY………………………………………. 2 INTRODUCTION…………………………………………………………… 4 GENERAL…………………………………………………………… 4 ORDERING PARTS………………………………………………… 4 FRYER CAPACITIES………………………...
GRA, GRAF, & VFRY GAS FRYERS & VFRY SERIES HD FRYERS VULCAN-HART F-32934 Rev. J (August 2012) -4- INTRODUCTION GENERAL Vulcan Fryers are produced with quality workmanship and material. Proper installation, usage and maintenance will result in years of satisfactory performance. Before install...
