Vulcan 1G6BDF ML-136795 - Manual

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -5- Check that the following have been included: Š Crumb Rack(s) Š Basket Hanger(s) Š Tank Brush Š Adjustable Casters (4) two locking, two non-locking for freestanding fryers. Fryer Batteries with the KleenScreen PLUS ® Filtration...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -6- Clearances: Š Minimum clearance from combustible construction: 6” (15 cm) from the sides of the fryer 6” (15 cm) from the back of the fryer The fryer may be installed on combustible floors. Š Minimum clearance from noncombusti...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -7- Š National Electrical Code, ANSI/NFPA-70 (latest edition). Copies may be obtained from The National Fire Protection Association, Batterymarch Park, Quincy, MA. 02169-7471. Š In the commonwealth of Massachusetts all gas applian...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -8- GAS CONNECTION All gas supply connections and any pipe joint compound must be resistant to the action of propane gases. The gas inlet is located on the lower rear of the fryer. Codes require that a gas shutoff valve be install...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -9- Š When installing a quick disconnect you must also install a means for limiting the movement of the fryer. This device will prevent the gas line or quick disconnect from being strained. The restraining device should be attache...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -10- LEVELING THE FRYER Check the level of the fryer by placing a level on top of the fryer after gas connections have been made. Ensure that the fryer is level front-to-back and side-to-side in the final installed position. If us...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -11- FILLING TANK WITH SHORTENING Š Close the drain valve. Š Fill the fryer tank with shortening. Vulcan recommends using liquid shortening. Š Shortening level should be between the MIN and MAX lines in the fryer tank. Š Shortenin...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -12- Fry Basket Guidelines Š Do not overfill baskets. (See fry basket capacity below) Carefully lower basket into oil. Š When frying doughnuts and fritters, turn product only once during frying. Š When cooking French fries or onio...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -13- Solid State Knob Control Temperature Knob Control Melt Switch Power Switch Filter Switch (For those models with KleenScreen PLUS ® Filter Systems) Start Button TURNING ON THE FRYER Š Open the door to the fryer. Select Liquid ...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -15- EXTENDED SHUTDOWN 1. Open the door to the fryer. Press the power switch to the OFF position. 2. Thoroughly drain the fryer. Refer to DRAINING THE FRYER. 3. Clean the fryer according to CLEANING. 4. Turn off the main gas shuto...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -16- DRAINING THE TANK 1. Open the door to the fryer. The power must remain ON for the fryer to filter correctly. 2. Insert the drain extension into the drain valve. Tighten only hand tight. 3. Direct the drain spout into the cont...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -17- 9. Drain the tank according to DRAINING THE TANK. Rinse thoroughly with clear, hot water. All traces of cleaner must be removed. Dry the tank thoroughly. 10. Close the drain valve and add shortening. Follow the FILLING TANK W...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -18- KleenScreen Plus ® Filtration System Installation and Operational Manual for “BDF” Models 2G4BDF Shown GAS KleenScreen PLUS® Models: 1G4BDF ML-136798 1G6BDF ML-136795 1G8BDF ML-136796 2G4BDF ML-136650 3G4BDF ML-136653 4G4BDF ...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -19- Filtering Instructions for KleenScreen PLUS ® Fryers General The KleenScreen PLUS ® filtration system filters the oil as it is pumped back into its’ respective tank(s). Only one tank can be drained and filtered at a time. Und...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -20- Fully assembled filter screen assembly: Fig. 2 Secure Tube with Suction Tube Clip Filter Screen Lays Flat On Bottom of Filter Pan Fig. 3 Micro-Filtration Fabric Envelope Assembly: Same Suction Tube Fabric Envelope Insert (Dif...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -21- INSTRUCTIONS TO REMOVE & REPLACE KLEENSCREEN PLUS ® FILTER ENVELOPE FOR ABSOLUTE FILTRATION & MAXIMUM FLOW RATE WE RECOMMEND YOU CHANGE YOUR FILTER ENVELOPES AT EVERY OIL CHANGE (10-14 DAYS DEPENDING ON OIL USAGE). St...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -22- Operation Hot oil and parts can cause burns. Use care when operating, cleaning and servicing the fryer. Spilling hot frying compound can cause severe burns. Do not move fryer without draining all frying compound from the tank...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -24- FILTERING TIP: Open the filtering drawer approximately 1” to allow any oil in the return line to run back into the filter pan. This will take about 30 seconds to complete. Then open the drawer completely to clean filter compo...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -25- BOIL OUT PROCEDURE: Use the Boil Out By-Pass™ drain extension allowing the boil out solution to exit the fry tank without using the filtering system. Do not allow water to run through the motor / pump. Drain the boil out solu...

GBD_GBDF SERIES GAS FRYERS VULCAN-HART F-32934 Rev. D (February 2009) -26- MAINTENANCE Hot oil and hot parts can cause burns. Use care when operating, cleaning, and servicing the fryer. Spilling hot fryer compound can cause severe burns. Do not move fryer without draining all frying compound from th...