Page 2 - Statement of Commitment; Great Outdoors; the
Congratulations and thank you for your purchaseof your new Great Outdoors grill. We are pleasedthat you have recognized the value of the design,function, and quality of components used in thisproduct. We believe it is among the finest on themarket. We are committed to producing quality productsthat ...
Page 3 - Table of Contents; Chapter 1 - INSTALLATION
Table of Contents Chapter 1 - INSTALLATION Necessary Information . . . . . . . . . . . . . . . . . . . . . . . . . . .Choosing a Safe Location . . . . . . . . . . . . . . . . . . . . . . . . . Liquid Propane Gas Grills . . . . . . . . . . . . . . . . . . . . . . . . . . L.P. Gas Dealer Instructions ...
Page 4 - Installation; Chapter; Stainless Series Gas Grill; Choosing a Safe Location
· · · · · Operating this or any gas-fired appliance in an enclosed area can produce a build-upof carbon-monoxide, which could result ininjury or death. or, in the absence of local codes, with either the National Fuel Gas Code, ANSIZ223.1, NFPA 54 (USA), or CAN/CGA-B 149.2, Propane Installation Code ...
Page 8 - Take These Instructions to the L.P. Gas Dealer
Example B Type 1 (cut away to see fitting) Example A CGA-510 POL Filling a Type 1 Cylinder Valve Example A: shows a CGA-510 POL fitting. Example B: shows using a Type 1 POL fitting. The L.P. gas cylinder has a Type 1 cylinder valve with a back-check module in its outletthat will not permit gas to fl...
Page 9 - Assembly Instructions
10mm Getting Started Unpacking the Grill Parts 1. Please follow the steps in the order that they are presented. 2. Assemble the grill where you plan to use it. 3. You may want to place an old towel or cloth at the assembly site to prevent nutsand bolts from becoming lost. 4. For each step, loosely t...
Page 10 - Assembly Step 1 - Identifying the Grill Parts
10 Assembly Step 1 - Identifying the Grill Parts Side BurnerAssembly Side Pillar Panel Front Panel Warming Rack Pillar Cylinder Retainer Wire Grill Head Assembly Side Table Grease Pan Side Pillar Panel Cylinder Support Base Assembly Cooking Grids: KG432 Model: 4-Burner Unit (Shown) KG432 Model:KG540...
Page 11 - Assembly Step 2; - Assemble the Pillar Panels
3. 4. 11 Assembly Step 2 - Assemble the Pillar Panels Firmly tighten the nuts andbolts. Repeat steps 1 through 3for the second Side PillarPanel. Tools Needed: USE HARDWARE PACK A : 10mm wrench LOCATE THESE PARTS: Side Pillar Panel (2) Front Pillar Panel (1) M6x1x10mm Bolt (6) Phillips head screwdriv...
Page 12 - Assembly Step 3; - Assemble the Pillar to the Base
12 Assembly Step 3 - Assemble the Pillar to the Base Tools Needed: LOCATE THESE PARTS: Base Assembly USE HARDWARE PACK B : M6x1x16mm Bolt (10) Flat Washer (10) Lock Washer (10) 1. 2. 3. 4. Set the Cylinder Support into the hole in theBase as shown with the notch toward thefront. Set the assembled Pi...
Page 13 - Assembly Step 4; - Attach the Grill Head to the Pillar
13 Assembly Step 4 - Attach the Grill Head to the Pillar Tools Needed: LOCATE THESE PARTS: Grill Head Assembly USE HARDWARE PACK C : M6x1x16mm Bolt (7) Flat Washer (7) Lock Washer (7) 1. 2. 3. Set the Grill Head Assembly onto the top of theassembled Pillar and Base as shown. Ensurethat the hose and ...
Page 14 - Assembly Step 5; - Attach the Side Tables
14 Assembly Step 5 - Attach the Side Tables Tools Needed: LOCATE THESE PARTS: Side Burner Table Assembly USE HARDWARE PACK D : M6x1x16mm Bolt (8) Flat Washer (8) Lock Washer (8) Phillips head screwdriver 1. 2. 3. 4. Starting with the Side BurnerTable Assembly, line up themounting holes with thecorre...
Page 15 - Assembly Step 6; - Mount the Side Burner Knob
Burner Control Valve Valve Orifice Burner Tube 15 Assembly Step 6 - Mount the Side Burner Knob Tools Needed: USE HARDWARE PACK E : Burner Control Knob Match Holder and Chain Phillips head screwdriver 1. 2. 3. 4. 5. Working underneath the Side BurnerAssembly, locate and remove the two boltsthat are h...
Page 17 - Assembly Step 7; - Assemble Cooking Grids
17 Assembly Step 7 - Assemble Cooking Grids 1. 2. 3. Set the Heat Tents intothe tub of the grill, oneeach directly above eachburner. There are notches inthe shelf to keep the Heat Tentsin place. Make sure the slottedends of the Heat Tents aretowards the front of the grill. Place the Cooking Grids on...
Page 18 - Assembly Step 8
18 Assembly Step 8 - Grease Pan and L.P. Tank 1. Place the Grease Pan underneath the Grill Tub from the back sideas shown. There are bracketsmounted to the underneath sideof the tub to hold the Grease Panin place. LOCATE THESE PARTS: Grease Pan Cylinder Retainer Wire L.P. Gas Cylinder (filled) NOT I...
Page 21 - Natural Gas Grills - Connecting to Natural Gas
A quick-connect coupling sleeve with 3/8” female end is provided. Install the connectorsocket at the pipe end, after the shut-off valve.This must be installed where the grill will be inuse. It is important to observe the safety guidelines for choosing a safe location. Thegas supply must be shut off ...
Page 23 - Use and Care Directions; Lighting Instructions
2 3 Use and Care Directions 3 Chapter Stainless Series Gas Grill Lighting Instructions Leak Testing theFuel Supply System Replacement Parts
Page 24 - Leak Testing; Z Z
Perform a leak test each time the gas supply cylinder is connected to the regulator.Leak test any time a part of the gas systemis replaced. Perform a leak test at least onceeach year whether the L.P. gas supplycylinder has been disconnected or not. Have a dealer check the cylinder for deterioration ...
Page 27 - Side Burner Operation
To open the side burner, simply lift up and out on the side burner lid. The lid can be used asadditional side table space. To match light the side burner, follow steps 1and 2 above, then strike a match and set it inthe side burner, near the burner as shown tothe right. Turn the side burner control k...
Page 28 - Using Your Gas Grill
TO BREAK IN A NEW GRILL BURNER'S FLAME Before using it for the first time; operate the grill with lid closed on a low setting for about 30to 45minutes to “season” the grill. This will help burnaway oil and the smell of new paint. After the oilhas burned away, check the burner flame. Keep the grill l...
Page 29 - Caring for Your Gas Grill
CARING FOR YOUR GRILL REGULAR CLEANING AND UPKEEP Regular care of your grill will help keep it operating properly. Cleaning or maintenancemay be done only when the grill is cool and withthe fuel supply turned off. Clean grill parts andtighten loose hardware as needed. Do not put grill parts in a sel...
Page 30 - Cleaning and Maintenance
Inspect and clean the burners regularly. Remove grill components from the grill bottom necessary toget to the burner inside. Use a wire bristle brush toclean the burner surface. A straightened paper clip isuseful to remove debris or rust from the small burnerports. Spiders and other insects are know...
Page 31 - Stainless Series Replacement Parts
Stainless Series Replacement Parts Part No. AZ001200AZ001201 AZ001202 AZ001203 AZ001204 AZ001205 AZ001206 AZ001207 AZ001208 AZ001209 AZ001210 AZ001211 AZ001212 AZ001213 AZ001214 AZ001215 AZ001216 AZ001217 AZ001218 AZ001219 AZ001220 AZ001221 AZ001222 AZ001223 AZ001224 AZ001225 AZ001226 AZ001227 AZ000...
Page 32 - BEEF; Recipes; Outdoor Cooking
DISAPPEARING SHISH KEBOBS 1/2 cup ketchup1/2 cup sugar1/2 cup soy sauce1 teaspoon garlic powder1 teaspoon ground ginger2 pounds boneless beef sirloin steak (1-1/2 inches thick),cut into 1-1/2-inch cubes 1/2 fresh pineapple, trimmed and cut into 1-inch chunks 2 to 3 small zucchini, cut into 1-inch ch...
Page 33 - PORK; POULTRY
PORK BEST PORK RIBS HMM - HMM HAM STEAK GRILLED HAM & SWISS SANDWICHES 3 pounds country-style pork ribs1/2 teaspoon garlic salt1/2 teaspoon pepper1 cup ketchup1/2 cup packed brown sugar1/2 cup honey1/4 cup spicy brown mustard2 tablespoons Worcestershire sauce1-1/2 teaspoons liquid smoke, optiona...
Page 34 - SIDE DISHES
SIDE DISHES RICE ON THE SIDE AU GRATIN POTATO POUCHES GRILLED BREADS 1-1/3 cups uncooked instant rice1/3 cup sliced fresh mushrooms1/4 cup chopped green pepper1/4 cup chopped onion1/2 cup chicken broth1/2 cup water1/3 cup ketchup1 tablespoon butter or margarine 4 cups frozen O'Brien potatoes (16 oun...
Page 36 - Manufacturer’s Limited Warranty
Manufacturer’s Limited Warranty The Great Outdoors grill is guaranteed against broken or damaged parts at the time ofpurchase. Components are guaranteed against defect as follows: All cast-aluminumand stainless steel panel parts are warranted against burn through and structural failureexcluding pain...
