Vermont Casting 3340 - Manual
Vermont Casting 3340 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Radiance Natural Vent Gas Heater; Table of Contents; Installation & Operating Instructions
- Page 4 – Stove Dimensions
- Page 5 – • Always maintain required; Stove Clearance; Fig. 3 Corner installation requirements.
- Page 6 – Venting Requirements and Options; Input; Gas Inlet and Manifold Pressures
- Page 7 – Passing Through a; Venting Requirements; Venting Runs; = Acceptable venting configuration; (Measured from top of the unit before any elbow)
- Page 8 – Tools Required; WARNING; Assembly Procedures
- Page 9 – Fig. 12 Position fan behind rear shroud.
- Page 10 – Fig. 13 Attach rear shroud cover plate to the rear shroud.; Install the Optional Fan; Fig. 16 Attach the fan assembly to the fan bracket.
- Page 11 – Fig. 20 Attach rheostat to left side of valve.
- Page 12 – Venting System Assembly
- Page 13 – Connect the Gas Supply Line; do not over apply. NEVER test with an open; CAUTION; Run wires down back of stove, under bottom of rear; Fig. 25 Attach switch assembly to rear shroud.; Burner Information
- Page 14 – Install Rear Bracket and Log Set; Thermostat; Install the Mesh and Grille; Fig. 27 Radiance firebox and rear log bracket.
- Page 15 – Fig. 28 Install the left and right rear logs and the right log.; Top View
- Page 16 – Operable Doors; Operation; Your First Fire; LO; Flame Characteristics
- Page 17 – FOR YOUR SAFETY READ BEFORE LIGHTING; To Turn Off Gas To Heater; Lighting and Operating Instructions; Lighting Instructions; Euro SIT
- Page 18 – Troubleshooting / Honeywell #8420 Gas Control System; SYMPTOM
- Page 19 – Fuel Conversion Instructions; Fig. 37 Attach the gas line to the left side of the valve.; Conversion Precautions; Fig. 39 Remove and replace injector orifices.
- Page 20 – Conversion to Natural Gas; Table 2. Injector Orifice Size Matrix; Model; RNVOD; Table 3. Air Shutter Adjustment; NOTE: It is very critical to keep the left burner leg,
- Page 21 – Maintenance
- Page 22 – Gasket Replacement; Determine the correct length of gasket by laying it; Inspect the Vent System Annually; Fig. 45 Release the latches to remove the glass frame.
- Page 23 – C WIRE OR ITS EQUIVALENT.; Schematic Diagram; Wiring Diagrams
- Page 25 – Description
- Page 27 – Optional Accessories
- Page 30 – IF WARRANTY SERVICE IS NEEDED...; ) DO NOT ATTEMPT TO DO ANY SERVICE WORK; LIMITED LIFETIME WARRANTY
- Page 31 – SI UN SERVICE SOUS GARANTIE EST REQUIS...; GARANTIE À VIE LIMITÉE
- Page 32 – CFM Specialty Home Products
INSTALLER / CONSUMER
SAFETY INFORMATION
20004409 12/04 Rev. 10
PLEASE READ THIS MANUAL BE-
FORE INSTALLING AND USING
APPLIANCE.
WARNING!
IF THE INFORMATION IN THIS
MANUAL IS NOT FOLLOWED EX-
ACTLY, A FIRE OR EXPLOSION MAY
RESULT CAUSING PROPERTY
DAMAGE, PERSONAL INJURY OR
LOSS OF LIFE.
—
Do not store or use gasoline or
other flammable vapors and
liquids in the vicinity of this or
any other appliance.
—
WHAT TO DO IF YOU SMELL
GAS:
•
Do not try to light any appliance.
•
Do not touch any electric switch; do
not use any phone in your building.
•
Immediately call your gas supplier
from your neighbor’s phone. Follow
the gas supplier’s instructions.
•
If you cannot reach your gas supplier,
call the fire department.
Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
This appliance may be installed in an after
market permanently located manufactured
(mobile) home where not prohibited by
local codes.
This appliance is only for use with the type
of gas indicated on the rating plate.
This appliance is not convertible for use
with other gases unless a certified kit is
used.
Radiance
Natural Vent Gas
Heater
Homeowner’s Installation
and Operating Manual
INSTALLER: DO NOT DISCARD THIS MANUAL -LEAVE FOR HOMEOWNER
C E R T I F I E D
DESIGN
C E R
T I F I E D
Model RNVOD: 3340 thru 3349,
3355, 3356
4409
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777
www.majesticproducts.com • www.vermontcastings.com
CFM Specialty Home Products
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 2 Radiance Natural Vent Gas Heater 20004409 PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE. Thank you and congratulations on your purchase of a Vermont Castings stove. IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to...
4 4 Radiance Natural Vent Gas Heater 20004409 Stove Dimensions See Page 5 for Flue CollarCenterline Dimensions. 4409 Fig. 1 Radiance dimensions. R A D I A N C E 29 ³⁄₄ " (756mm) 31" (787mm) 14 ⁷⁄₈ " (378mm) 4" Inner Dia.(100mm) 4 ¹⁄₂ " (114mm) CL 28" (711mm) 5" (127mm) 9 ...
5 Radiance Natural Vent Gas Heater 20004409 Clearance Requirements Minimum Clearances to Combustible Materials Measure side clearances as shown in Figures 2through 5 from the outer edge of the cast iron stovetop. Measure rear clearances from the rear sheet metalshroud. The Radiance heater is approve...
