Vermont Casting 2477 - Manual

Table of Contents:

• Page 2 – Dutchwest Non-Catalytic Convection Heater; Proposition 65 Warning:; Table of Contents; PLEASE NOTE
• Page 3 – Specifications; Dutchwest Convection Heater specifications.
• Page 4 – Installation; Failure to follow these installation instruc-; Chimney Types; The chimney should be thoroughly cleaned before use.; If in sound condition and approved for use, either a
• Page 5 – chimney connector; Sections of a steel chimney connector of at least 24
• Page 6 – Double-Wall Connector; Crimped sections always point toward the stove so; Securing the Connector to a; Joining the chimney connector to a prefabricated
• Page 7 – Securing the Connector; Double-check connector clearance from the ceiling.; The thimble, made of either ceramic or metal, must be; The connector enters flue above the fireplace. If the; The connector passes through the fireplace to enter
• Page 8 – Fireplace Installations -; If the stove is installed without legs, we recommend; Wall pass-through enclosed with noncombustible
• Page 9 – Floor Protection; hr. °F or an equivalent material with; Combustible supporting timbers (A) may lie beneath; combustible support; Model; Be sure to follow exactly the minimum floor protection; Canada; Do not vent your Dutchwest stove into a factory-
• Page 10 – Floor Protection for Fireplace
• Page 11 – Keep the Stove a Safe Distance; Clearances; Fireplace Installation Clearances; Extra floor protection may be required for the fire-; Minimum clearances for fireplace installation. Recom-
• Page 12 – Alcove Installations; ALCOVE INSTALLATION OF THE DUTCHWEST; Construction Requirements; Alcove floor plan. Sheetrock on front face butts to; Alcove side view; Alcove side section.; Cutaway perspective of alcove installation.; Alcove Ceiling plan; Reflected ceiling plan.
• Page 13 – Designing a Safe Installation; exit diagram; Unprotected Surfaces; Parallel Installations
• Page 14 – Stove and Chimney Connector Clearance Charts; Model 2477 Small Convection Heater
• Page 15 – dutchwest
• Page 16 – Wall Heat Shield Dimensions; DutchWest Non-Catalytic Convection Heater Model #2477; Sidewall protection.; Corner wall protection.; Rear wall protection.
• Page 17 – Unpack the Parts; Assembly; Remove bands holding stove to pallet and remove; Rotate stove on pallet to expose front left corner.
• Page 18 – Reposition stove so one rear leg can be attached.; Fan Kit Installation
• Page 19 – Heater Controls and Features; Air Control Lever; is located at the lower front; Operation; The heater controls.; Turn primary air control lever clockwise to open.; Turn primary air control lever counterclockwise to
• Page 20 – Successful Wood Burning; The; Damper; is operated by moving the handle on; Load Doors; Side Loading Door; allows the easiest loading of; Front Door; opens for adding an occa-; Damper operating positions.; Open
• Page 21 – Use the Air Control Settings; Position the primary air control lever for different burn; air settings; High
• Page 22 – Reloading and Reviving the Fire
• Page 23 – Remove Ashes Frequently; Hot ashes can be dangerous and must be stored; ash pail; Check the ash compartment before reloading the; Safe Ash Handling; Note; : It may take days for these
• Page 24 – Never use liquid cleaning; If you wish to clean the glass; Maintenance; door gasket; door latch; Door latch adjustment.
• Page 25 – Avoid Damaging the Glass Door Panel; damper rod; primary air control; Primary air control adjustment.
• Page 26 – Cleaning the Chimney System; Maintenance Schedule; Clear any ash build-up from around the air holes and; ANNUAL SPRING CLEANING:; Check gasketing for wear, and replace if necessary.
• Page 27 – The Chimney Connector; Thoroughly clean the chimney.; Inspect and clean out ash accumulation on either
• Page 28 – Masonry Chimney; Draft Management
• Page 30 – Dutchwest Convection Heater; Ref. Description; Primary Air Manifold to Inner Bottom Gasket (1/4” Rd Fiberglass)
• Page 32 – CFM Corporation; LIMITED LIFETIME Warranty; Limited Lifetime Warranty