UNIQUE UGP-10C SM W - User Manual

Table of Contents Chapters Welcome 1 Safety and Warnings 1 Appliance Installation 2 General Operating Instructions 3 How to use the Refrigerator 3 Maintenance & Service 4 Troubleshooting & Suggested Spares 5 Door Reversal and Removal Instructions 6 Temperature Controls, Food Storage and Clea...

U G P - 6 C / 8 C / 1 0 C 1 Welcome & Congratulations ongratulations on your purchase of a UNIQUE refrigerator!. We are very proud of our product and we are completely committed to providing you with the best service possible. Your satisfaction is our #1 priority. Please read this manual very ca...

2 Safety and Warnings If you smell gas • Open Windows • Don’t touch electrical switches • Extinguish any open flame • Immediately call your gas supplier For your Safety • Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this unit or any other appliance Warning • ...

3 Installation For best performance at high ambient temperatures, there must be free air circulation over the cooling unit at the rear of the refrigerator. Ensure that there is a free air space above the refrigerator and that the flue (chimney) on top of the cabinet is not covered in any way. Do not...

4 Air Flow - to release heat trap 6” 6” Clearances Minimum clearances to combustible materials are: Top – 6” Sides – 2” Rear – 1” as shown in Figures. 1, 2 & 3. Note: DO NOT install the appliance directly on carpeting. Carpeting must be removed or protected by a metal or wood panel beneath the a...

5 connections should be checked for leaks with a non-corrosive leak detector and/or soap and water for a bubble check. W ARNING – D O NOT USE FLAME TO CHECK FOR GAS LEAKS The gas supply system must incorporate a pressure regulator to maintain a supply pressure of not more than 12” water column and n...

6 General Operating Instructions Importance of Leveling a Refrigerator The refrigerator must be adjusted to a vertical position in both directions. In an absorption refrigeration system, ammonia is liquefied in the finned condenser coil at the top rear of the refrigerator. The liquid ammonia then fl...

7 Gas Operation – for models with electronic ignition “Start-Up” Procedure Electronic Ignition (battery) 1. To start the refrigerator, turn the thermostat knob E to the maximum setting, #4. 2. Turn button G to “Gas” position, then push B button in first and hold, proceed to push in and hold the D bu...

8 4. Adjust the thermostat knob to desired temperature setting after 8 hours of operation. CONTROLS – See Fig. #5 for a description of controls Thermostat The refrigerator cooling temperature is controlled by a thermostat that can be adjusted by turning knob E to different settings to maintain the d...

9 The setting of the thermostat is critical and we recommend it be adjusted to maintain a dry frost on the cooling fins (approx. 38 ° Fahrenheit or 3 ° Celsius). Adjust the thermostat knob closer to “Max” (clockwise) when the outside temperature rises. NOTE: When first turning the refrigerator on, m...

10 F RIDGE S ECTION Inside the refrigerator compartment, the defrost water runs from a collector channel to a drip tray/cup at the rear of the refrigerator where it normally evaporates. If heavy frost has built up on the cooling fins creating a lot of defrost water. Be aware your water reservoir may...

11 Shut Down Procedure A. Turn gas valve knob to the “off” position B. If the refrigerator will not be in operation for a period of weeks, it should be emptied, defrosted, cleaned and the doors left open. The ice tray should also be dried and kept outside the cabinet, also turn off gas at the main s...

12 Maintenance & Service The user should be aware of service that must be done on a regular schedule to keep the refrigerator operating properly. Installation must be by a licensed gas fitter in accordance with local codes or in the absence of local national Fuel Gas Code, ANSI Z233.1 and in Can...

13 Check burner flame for proper appearance. The flame should be light blue with no yellow at the tip. See figure #6 • The LP gas pressure should be checked and the main regulator readjusted if pressure is incorrect. The correct operating pressure is 11” W.C. (water column). • Inspect the flue baffl...

14 Warning - DO NOT use a pin or wire when cleaning the burner orifice as damage can occur to the precision opening. This can cause damage to the refrigerator or create a fire hazard. It will also create extremely dangerous levels of carbon monoxide. o The inlet & outlet gas fittings on the refr...

15 TROUBLESHOOTING INSTRUCTIONS & SUGGESTED SPARE PARTS TO KEEP ON HAND REFRIGERATOR DOES NOT COOL, CHECK LIKELY CAUSES: 1. Burner orifice clogged. Clean. See section Maintenance & Service, C HAPTER 4, 2. Check to ensure refrigerator is level – (left to right and front to back). 3. Restricti...

16 Spare Parts The following is a list of commonly used parts which are available: • Burner orifice • Burner • Electrode with wire • Thermocouple • Safety valve & Thermostat • Baffle Contact your dealer or an authorized service center for parts and repairs as needed. Quote Model & Serial # -...

17 Door Removal & Reversal Instructions NOTE: The direction in which your refrigerator doors open (door swing) can be reversed, from left to right or right to left, by moving the door hinges from one side to the other. Reversing the door swing should be performed by a qualified person. 1. Remove...

18 Temperature Controls NOTE: Due to the nature of a gas operated absorption fridge, temperatures in the fridge compartment will drop to freezing even on the lowest setting when the ambient temperature surrounding the fridge drops to or below 60 ° F/ 15.0 ° C overnight and will freeze your food or d...

19 Looking Inside SHELF ADJUSTMENT Refrigerator shelves are easily adjusted to suit individual needs. Before adjusting the shelves, remove all food. Crispers & Deli Drawers The crispers, located under the bottom refrigerator shelf, are designed for storing fruits, vegetables, and other fresh pro...

20 • A freezer operates most efficiently when it is slowly loaded to 2/3 full. P ACKAGING F OODS FOR F REEZING • To minimize dehydration and quality deterioration, use aluminum foil, freezer wrap, freezer bags or airtight containers. • Force as much air out of the packages as possible and seal them ...

21 NOTES: Do not use razor blades or other sharp instruments, which can scratch the appliance surface when removing adhesive labels. Any glue left from tape or labels can be removed with a mixture of warm water and mild detergent, or, touch the glue residue with the sticky side of tape you have alre...

26 UNIQUE – UGP 6C No. Item Code 1 Cabinet N/A 2 Heat sink UGP-DL22502524 3 Drip tray UGP-DL22501294 4 Drainage hose UGP-DL00009088 5 Drip pan UGP-DL10001155 6 Hinge cover UGP-DL22001080 7 Screw UGP-DL00003005 8 Screw cap UGP-DL10001193 9 Top hinge UGP-DL22001079 10 Top hinge cover UGP-DL22001074 11...

30 UNIQUE UGP 8C Parts List No. Item Code 1 Cabinet N/A 2 Heat sink UGP-DL22502524 3 Drip tray UGP-DL22501294 4 Drainage hose UGP-DL00009088 5 Drip pan UGP-DL10001155 6 Hinge cover UGP-DL22001080 7 Screw UGP-DL00003005 8 Screw cap UGP-DL10001193 9 Top hinge UGP-DL22001079 10 Top hinge cover UGP-DL22...

34 UNIQUE – UGP 10C Parts List No. Item Code 1 Cabinet N/A 2 Heat sink UGP-DL22502524 3 Drip tray UGP-DL22501294 4 Drainage hose UGP-DL00009088 5 Drip pan UGP-DL10001155 6 Hinge cover UGP-DL22001080 7 Screw UGP-DL00003005 8 Screw cap UGP-DL10001193 9 Top hinge UGP-DL22001079 10 Top hinge cover UGP-D...

40 UNIQUE – UGP 14C Parts List M1 UGP-9RV-SSO-C CO Detector 9RV SSO-C M2 QMP-Interrupter Block Interrupter Block for CO-Monitored fridges M3 QMP-Mosfet-C Mosfet Assembly - for CO-Monitored Models

41 Limited Warranty UNIQUE Model 9RV-SSO-C UNIQUE Appliances (“Unique”) offers you this limited warranty on your new carbon monoxide alarming device with safety shut-off, including all of its components (the Product”). This limited warranty extends solely to the original end-user purchaser of this P...

42 Warranty    UNQIUE UGP-6C/8C/10C/14C PROPANE REFRIGERATOR - 3 YEAR LIMITED WARRANTY Unique Appliances warrants that the UNIQUE UGP-6C/8C/10C/14C refrigerator is free from defects in material and workmanship under normal usage and service under the following terms: 1. This Warr...