Toastmaster 1427 - Manual - manualsarea.com

Page 2 - Table of Contents; OUNTERTOP

C OUNTERTOP F RYERS Congratulations! You have purchased one of the finest pieces of heavy-duty commercial cookingequipment on the market. You will find that your new equipment, like all Toastmaster equipment, has been designed and manufacturedto meet the toughest standards in the industry. Each piec...

Page 4 - Do not lift the heating assembly out of the shortening; SECTION 1 - DESCRIPTION

C OUNTERTOP F RYERS Component Location & Function. Refer to Figure 1-2. Toastmaster fry kettles are deep fryers designed to efficiently fry a wide variety of food products by immersion into heatedliquified shortening. Power “ON/OFF” Switch located at front of fryer and equipped with a green sign...

Page 11 - A. Inspect for Shipping Damage; Electrical Connection

C OUNTERTOP F RYERS A. Inspect for Shipping Damage All shipping containers should be examined for damage before and during unloading. This equipment was carefullyinspected and packaged at the factory. The freight carrier has assumed responsibility for its safe transit and delivery.If equipment is re...

Page 12 - SECTION 2 - INSTALLATION

C OUNTERTOP F RYERS Figure 2-1 Caution: Certain models cannot be wired for single phase at certain voltages as shown in the specifications and wire schematics in this manual. c. Remove access cover of electrical compartment (Refer to Figure 2-1). Connect power supply to terminal block.The fryer is w...

Page 14 - Do not touch heating elements.

C OUNTERTOP F RYERS e. Check that all connections are tight. f. Reassemble fry kettle and turn the circuit breaker ON. 3. Installation Check. a. Place disconnect switch in “On” position, energizing the fry kettle. Turn thermostat dial to 250°F (121.1 °C)for five seconds; return to “Off” position. b....

Page 15 - Never stick fingers or any body parts into hot shortening.; Location of Controls

C OUNTERTOP F RYERS CAUTION: Never stick fingers or any body parts into hot shortening. Bodily injury will result. A. Location of Controls The following information provides a basic description of the fry kettle components, their location and the function theyperform. Figure 3-1 13 Toastmaster ®

Page 16 - SECTION 3 - OPERATION

C OUNTERTOP F RYERS B. Function of Controls 1. Power “ON/OFF” Switch is used to turn power to the heating elements “ON” or “OFF”. 2. Power Switch Green Light is lit when the power is “On”. 3. Thermostat Knob is used to set the temperature to your requirements. The minimum set point is 250°F (121.1°C...

Page 17 - D. Preparation for Operation; Daily Operation

C OUNTERTOP F RYERS 15 SECTION 3 - OPERATION D. Preparation for Operation 1. Choose a Shortening. Choose a shortening made especially for commercial deep frying. The investment in good quality shorteningw i l l b e r e w a r d e d w i t h a l o n g t i m e u s e a n d f r i e d f o o d s o f h i g h...

Page 18 - F. Deep Frying Guidelines; CAUTION

C OUNTERTOP F RYERS F. Deep Frying Guidelines 1. Whenever possible, drain and dry foods before frying. Excessively moist foods break down shortening, hydrolyzing fat, thus releasing fatty acids. Such fats will soon begin to smoke and its frying value is decreased considerably. CAUTION: Do not use wa...

Page 20 - IN CASE OF FIRE; FIRST; Spray the fire extinguisher over the blanket or cover

C OUNTERTOP F RYERS f. Remove any large food particles from the cooking vessel using a slotted spoon or spatula. g. Tie 2 or 3 thicknesses of cheesecloth over the top of an empty bucket, leaving a pocket at the center. CAUTION: Do not use plastic or glass bucket. Bucket must be large enough to hold ...

Page 24 - SECTION 4 - PARTS LIST

C OUNTERTOP F RYERS SECTION 4 - PARTS LIST 22 Toastmaster ® COUNTERTOP FRYER 1427 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Page 25 - K e y

C OUNTERTOP F RYERS SECTION 4 - PARTS LIST 23 Toastmaster ® COUNTERTOP FRYER 1427 K e y P a r t N u m b e r Q t y . D e s c r i p t i o n 1 T A 7 1 0 E 8 7 4 9 1 K N O B , T S T A T 2 5 0 - 4 0 0 F 2 T 1 4 2 7 B 8 7 0 1 1 T H E R M O S T A T , F R Y E R 2 0 0 - 4 0 0 F 3 T 1 4 1 4 B 8 7 0 7 1 T H E ...

Page 27 - Key; THERMOSTAT, LIMIT CONTROL

C OUNTERTOP F RYERS 25 SECTION 4 - PARTS LIST Toastmaster ® COUNTERTOP FRYER 1439 Key P a rt Num b e r Qty. Description 1 TA710E8749 2 KNOB, TSTAT 250-400F 2 T1421B8703 2 THERMOSTAT, FRYER 200-400F 3 T1414B8707 2 THERMOSTAT, LIMIT CONTROL 4 T1456A8739 1 BLOCK,TERMINAL 5 1000705 1 BLOCK,TERM BLK-RAW ...

Page 31 - SECTION 5 - SCHEMATICS

C OUNTERTOP F RYERS 29 SECTION 5 - SCHEMATICS Toastmaster ®

Page 32 - COUNTERTOP FRYERS; Middleby Philippines Corporation

C OUNTERTOP F RYERS COUNTERTOP FRYERS MODELS 1427 & 1439 A product with the Toastmaster name incorporates the best in durability and low maintenance. Weall recognize, however, that replacement parts and occasional professional service may be neces-sary to extend the useful life of this unit. Whe...

Toastmaster 1427 - Manual

Table of Contents:

Summary

Other Toastmaster Models