TOA SSDVT-4035CNM - Manual

TOA SSDVT-4035CNM

TOA SSDVT-4035CNM – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
Page: / 40

Table of Contents:

  • Page 2 – TABLE OF CONTENTS; Please read and understand these; Millivolt; INTRODUCTION; Approved Vent Components; Manufactured Home Requirements; PACKAGING; WARNING; GENERAL INFORMATION; Installation and repair should be per-; The use of other
  • Page 3 – greater; by closing their; less than; Table 7; show the appliances' gas; the electronic gas control valve.; Manifold Pressure Tap
  • Page 4 – Requirements for the Commonwealth of Massachusetts; “GAS VENT DIRECTLY
  • Page 5 – SAFETY & WARNIING INFORMATION
  • Page 6 – Do; Figure 9; Figure 4; Typical Locations
  • Page 7 – VENT TERMINATION CLEARANCES; Figure 5; Horizontal Vent Termination Clearances; Figure 6; Side Elevation View; Horizontal Vent Termination Clearances; • Manufactured Home Construction and; CAUTIONS
  • Page 8 – EXTERIOR HORIZONTAL VENT TERMINATION CLEARANCE REQUIREMENTS; Minimum Clearances
  • Page 9 – MINIMUM CLEARANCES TO COMBUSTIBLES; Table 8; for clearance
  • Page 10 – TYPICAL INSTALLATION SEQUENCE; Pressure Relief Plates; STEP 2. ROUTING GAS LINE; on; DETAILED INSTALLATION STEPS; Remove the cardboard from; See; DO NOT
  • Page 11 – FIREPLACE SPECIFICATIONS; Vent Size; Notes; Frame ceiling opening; Top View; Right Side View; positioned in louvered
  • Page 12 – Proper Sizing of Gas Line; Table 9; FIREPLACE FRAMING SPECIFICATIONS
  • Page 13 – or rear fl ue outlet as shown in; Step 3. INSTALL THE VENT SYSTEM
  • Page 14 – and their associated; Model
  • Page 15 – Dimple; An elbow may also be attached to the; Blocking
  • Page 17 – A Vent Restrictor, as shown in; Ratio V to H ratio is 1:2; VERTICAL VENT FIGURES/TABLES; Secure Vent
  • Page 18 – ) horizontal run up to; Top Vent - THREE ELBOWS; and their associated Horizontal Vent
  • Page 19 – TYPICAL HORIZONTAL VENT INSTALLATION; refer to Figure
  • Page 20 – Step B; IMPORTANT; Termination Guard; Page 33. This can be
  • Page 21 – Wall; components (rigid vent pipe and terminal) are shown in; HORIZONTAL VENT FIGURES/TABLES; Termination Kit Only
  • Page 22 – to a maximum horizontal run of 20 feet.
  • Page 23 – horizontal run of 20 feet.
  • Page 24 – SECURE FLEX; Secure Flex
  • Page 25 – Step 4. FIELD WIRING; A. SIT and Honeywell Millivolt Wiring; Figures; WIRING - OPTIONAL FORCED AIR; B. Electronic Wiring
  • Page 26 – Schematic Representation Only; CAUTION; Step 6. CONNECTING GAS LINE; Figure; Gas Flex Line Connector; GAS CONNECTION
  • Page 27 – Piezo
  • Page 28 – Glowing Embers; Bag of Glowing; Remove the front glass enclosure panel; Electronic Appliance Checkout
  • Page 29 – LOG SET
  • Page 30 – Place Embers and Volcanic Stone as Shown
  • Page 31 – Reinstalling Control
  • Page 32 – Main Burner Factory Air Shutter; HOOD INSTALLATION; Page 6; for Cold Climate Insulation; Burner Air Shutter Adjustment Procedure
  • Page 33 – INSTALLATION ACCESSORIES
  • Page 34 – Item; Open Top Shroud Kits; Closed Top Shroud Termination Kits
  • Page 35 – GAS CONVERSION KITS; * All compressed fl ex vents can be expanded up to two times.
  • Page 36 – NAT
  • Page 37 – . Reassemble all removed components; Spring; Inlet Pressure Test Port
  • Page 38 – NOTES
Loading the manual

RETAIN THESE INSTRUCTIONS

FOR FUTURE REFERENCE

OTL Report No. 116-F-29-5

INSTALLATION
INSTRUCTIONS

Millivolt Models

Electronic Models

MODELS

P/N 700,029M REV. E 11/2006

DIRECT VENT GAS FIREPLACE HEATERS

DIRECT VENT

SSDV-35/40 SERIES

SSDVT-3530CNM
SSDVR-3530CNM
SSDVT-4035CNM
SSDVR-4035CNM

SSDVT-3530CNE
SSDVR-3530CNE
SSDVT-4035CNE
SSDVR-4035CNE

A French manual is available upon request. Order P/N 700,029CF

Ce manuel d’installation est disponible en francais, simplement en
faire la demande. Numéro de la pièce 700,029CF.

This appliance may be installed in an aftermarket
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
local codes. This appliance is only for use with
the type of gas indicated on the rating plate. This
appliance is not convertible for use with other
g a s e s , u n l e s s a c e r t i fi e d k i t i s u s e d .

In the Commonwealth of Massachusetts:

•

Installation must be performed by a licensed plumber or

gas fi tter;

• See Table of Contents for location of additional Com-

monwealth of Massachusetts requirements.

FOR YOUR SAFETY: Do not store or use gasoline
or other fl ammables or liquids in the vicinity of
this or any other appliance.

FOR YOUR SAFETY: What to do if you smell gas:

• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• Do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow your gas suppliers
instructions.
• If your gas supplier cannot be reached, call
the fi re department.

Installation and service must be performed by
a qualifi ed installer, service agency or the gas
supplier.

WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAMAGE,
PERSONAL INJURY OR LOSS OF LIFE.

POUR VOTRE SÉCURITÉ: Ne pas entreposer ni
utiliser d'essence ni d'autre vapeurs ou liquides
infl ammables dans le voisinage de cet appareil ou
de tout autre appareil.

POUR VOTRE SÉCURITÉ: Que faire si vous sentez
une odeur de gaz:

• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous

servir des téléphones se trouvant dans le bati-
ment où vous vous trouvez.

• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de

gaz depuis un voisin. Suivez les instructions du
fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de

gaz, appelez le service dos incendies.

L'installation et service doit être exécuté par un
qualifi é installeur, agence de service ou le fournis-
seur de gaz.

AVERTISSEMENT: ASSUREZ-VOUS DE BIEN
SUIVRE LES INSTRUCTIONS DONNÉ DANS CETTE
NOTICE POUR RÉDUIRE AU MINIMUM LE RISQUE
D'INCENDIE OU POUR ÉVITER TOUT DOMMAGE
MATÉRIEL, TOUTE BLESSURE OU LA MORT.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - TABLE OF CONTENTS; Please read and understand these; Millivolt; INTRODUCTION; Approved Vent Components; Manufactured Home Requirements; PACKAGING; WARNING; GENERAL INFORMATION; Installation and repair should be per-; The use of other

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. 2 TABLE OF CONTENTS Packaging ......................................... Page 2Introduction ...................................... Page 2General Information .......................... Page 2New York City Approval ..................... Page 3Requirement...

Page 3 - greater; by closing their; less than; Table 7; show the appliances' gas; the electronic gas control valve.; Manifold Pressure Tap

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. 3 New York City, New York (MEA) Installation of these fi replaces are approved for installation in New York City in the US state of New York. These appliances and their individual shut-off valves must be disconnected from the gas supply piping system ...

Page 4 - Requirements for the Commonwealth of Massachusetts; “GAS VENT DIRECTLY

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. 4 Note: The following requirements reference various Massachusetts and national codes not contained in this document. Requirements for the Commonwealth of Massachusetts For all side wall horizontally vented gas fueled equipment installed in every dwel...

Other TOA Models

All TOA Other