Page 2 - Complete this page for quick reference when service is required:; Date of Installation:; Information found on the data label:; Voltage; Taylor Company
Complete this page for quick reference when service is required: Taylor Distributor: Address: Phone: Service: Parts: Date of Installation: Information found on the data label: Model Number: Serial Number: Electrical Specs: Voltage Cycle Phase Maximum Fuse Size: A Minimum Wire Ampacity: A E 2002 Carr...
Page 3 - Table of Contents
Table of Contents Models 750, 751, 754, 774, 791, 794 Table of Contents Section 1 To the Installer 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Section 2 To the Operator 4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....
Page 4 - Table of Contents - Page 2
Models 750, 751, 754, 774, 791, 794 Table of Contents Table of Contents - Page 2 Draining Product From The Freezing Cylinder 29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . Rinsing 29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....
Page 5 - Installer Safety
1 Models 750, 751, 754, 774, 791, 794 To the Installer 131206 Section 1 To the Installer The following information has been included in the manual as safety and regulatory guidelines. For complete installation instructions, please see the Installation Checklist. Installer Safety In all areas of the ...
Page 7 - Beater Rotation; Refrigerant
3 Models 750, 751, 754, 774, 791, 794 To the Installer 130819 Supply cords used with this unit shall be oil-resistant, sheathed flexible cable not lighter than ordinary polychloroprene or other equivalent synthetic elastomer-sheathed cord (Code designation 60245 IEC 57) installed with the proper cor...
Page 8 - Compressor Warranty Disclaimer
4 Models 750, 751, 754, 774, 791, 794 To the Operator 131206 Section 2 To the Operator The freezer you have purchased has been carefully engineered and manufactured to give you dependable operation. The Taylor soft- serve models covered in this manual consist of the following: 750, 751, 754, 774, 79...
Page 11 - Section 4
7 Models 750, 751, 754, 774, 791, 794 Operator Parts Identification 101217 Section 4 Operator Parts Identification Model 750 Item Description Part No. 1 Cover A.- Hopper X38458- SER 2 Gasket- Hopper Cover 038375 3 Tube A.- Feed X29429- 2 4 Panel- Rear 020891 5 Panel- Upper Side Right 042317 6 Pan- D...
Page 18 - Models 750 & 751 Single Spout Door and Beater Assembly
14 Models 750, 751, 754, 774, 791, 794 Operator Parts Identification Models 750 & 751 Single Spout Door and Beater Assembly ITEM DESCRIPTION PART NO. 1 HANDLE A.- DRAW X55096 1a DRAW HANDLE 028804 1b SCREW-ADJUST 055092 1c O-RING 1/4OD X .070W 015872 1d NUT-JAM 029639-BLK 2 NUT-STUD FLAT LONG 02...
Page 20 - Model 791 Three Spout Door and Beater Assembly
16 Models 750, 751, 754, 774, 791, 794 Operator Parts Identification 120124 Model 791 Three Spout Door and Beater Assembly ITEM DESCRIPTION PART NO. 1 HANDLE A.- DRAW X55096 1a DRAW HANDLE 028804 1b SCREW- ADJUST 055092 1c O- RING 1/4OD X .070W 015872 1d NUT- JAM 029639- BLK 2 PLUG- PRIME 028805 3 R...
Page 21 - Accessories
17 Models 750, 751, 754, 774, 791, 794 Operator Parts Identification 140718 Accessories Item Description Part No. 1 Tool- O- Ring Removal 048260- WHT 2 Brush- Rear Bearing 1” D x 2”L 013071 3 Brush- Double Ended 013072 4 Brush- Draw Valve 1” x 2” x 17” 013073 5 Brush- Mix Pump Body 3” x 7” White 023...
Page 22 - Section 5; Symbol Definitions
18 Models 750, 751, 754, 774, 791, 794 Important: To the Operator Section 5 Important: To the Operator 750/751 754/774/791/794 ITEM DESCRIPTION 1 MIX LOW INDICATOR LIGHT 2 MIX REFRIGERATION KEY 3 STANDBY KEY 4 WASH KEY 5 AUTO KEY 6 POWER ON/OFF (TOGGLE) 7 RESET BUTTON Symbol Definitions To better co...
Page 25 - Section 6; Assembly
21 Models 750, 751, 754, 774, 791, 794 Operating Procedures 080602 Section 6 Operating Procedures The Model 751 has been selected to illustrate the step- by- step operating procedures for all models contained in this manual. These models, for all practical purposes of operation, are the same. Each u...
Page 30 - Sanitizing
26 Models 750, 751, 754, 774, 791, 794 Operating Procedures 130118 Install the air orifice into the hole in the top of the air tube (in the end without the small hole on the side). Figure 21 Step 11 Lay the air tube (with the air orifice installed) and the hopper gasket in the bottom of the mix hopp...
Page 32 - Priming
28 Models 750, 751, 754, 774, 791, 794 Operating Procedures Step 9 Assemble the hopper gasket around the top edge of the mix hopper. Stand the air tube in the corner of the hopper. Figure 30 Repeat steps 1 through 9 for the other side of the freezer on Models 754, 774, 791, and 794. Priming Step 1 W...
Page 33 - Rinsing
29 Models 750, 751, 754, 774, 791, 794 Operating Procedures 140718 Step 7 Place the mix hopper cover in position over the mix hopper. Repeat steps 1 through 7 for the other side of the freezer on Models 754, 774, 791, and 794. Closing Procedure To disassemble your unit, the following items will be n...
Page 34 - Disassembly; Brush Cleaning
30 Models 750, 751, 754, 774, 791, 794 Operating Procedures 080324 Step 6 When a steady stream of cleaning solution is flowing from the prime plug opening in the bottom of the freezer door, lower the draw handle. Draw off all of the solution. Step 7 Once the cleaner stops flowing from the door spout...
Page 35 - During Cleaning and Sanitizing; Troubleshooting Bacterial Count
31 Models 750, 751, 754, 774, 791, 794 Important: Operator Checklist 061122 Section 7 Important: Operator Checklist During Cleaning and Sanitizing Cleaning and sanitizing schedules are governed by federal, state, or local regulatory agencies, and must be followed accordingly. If the unit has a “Stan...
Page 36 - Winter Storage
32 Models 750, 751, 754, 774, 791, 794 Important: Operator Checklist 080324 j 6. If your machine is air cooled, check the condensers for accumulation of dirt and lint. Dirty condensers will reduce the efficiency and capacity of the machine. Condensers should be cleaned monthly with a soft brush. Nev...
Page 37 - Section 8; PROBLEM
33 Models 750, 751, 754, 774, 791, 794 Troubleshooting Guide Section 8 Troubleshooting Guide PROBLEM PROBABLE CAUSE REMEDY PAGE REF. 1. No product is being dispensed with draw valve open and the machine in the AUTO mode. a. Freeze- up in mix inlet hole. a. Call service technician to adjust the mix h...
Page 40 - Section 9
36 Models 750, 751, 754, 774, 791, 794 Parts Replacement Schedule Section 9 Parts Replacement Schedule PART DESCRIPTION EVERY 3 MONTHS EVERY 6 MONTHS ANNUALLY Drive Shaft Seal X Scraper Blade X Freezer Door Gasket X Front Bearing X Draw Valve O- Ring X Pivot Pin O- Ring X Prime Plug O- Ring X Air Tu...
Page 41 - Limited Warranty on Equipment
37 Models 750, 751, 754, 774, 791, 794 Limited Warranty on Equipment 131206 Section 10 Limited Warranty on Equipment TAYLOR COMPANY LIMITED WARRANTY ON FREEZERS Taylor Company, a division of Carrier Commercial Refrigeration, Inc. (“Taylor”) is pleased to provide this limited warranty on new Taylor-b...
Page 43 - Limited Warranty on Parts
39 Models 750, 751, 754, 774, 791, 794 Limited Warranty on Parts 131206 Section 11 Limited Warranty on Parts TAYLOR COMPANY LIMITED WARRANTY ON TAYLOR GENUINE PARTS Taylor Company, a division of Carrier Commercial Refrigeration, Inc. (“Taylor”) is pleased to provide this limited warranty on new Tayl...
Page 46 - Models
Section 12 Parts List + Available Separately 42 Parts List Models 750, 751, 754, 774, 791, 794 121031 Models 750, 751, 754, 774, 794 (H P 62 R ef ri g eran t: 750 - J61 10454, 751 - J6080596, 754 - J6080465, 774 - J6092382, an d 794 - J4094101/ u p ) DE S CRI P T IO N PART NUM BE R 750 QTY . 751 QTY...
Page 55 - OPT
51 + Available Separately Models 750, 751, 754, 774, 791, 794 Parts List DE S CRI P T IO N PART S UP DA T E RE M ARKS W ARR. CL AS S 794 QTY . 774 QTY . 754 QTY . 751 QTY . 750 QTY . PART NUM BE R VAL VE-E.P.R . 022665 1 1 1 1 1 103 VAL VE A.-D R A W X 18303 1 1 3 3 3 103 J 7060000 (R E P L A C E S ...
Page 60 - Model
+ Available Separately 56 Parts List Models 750, 751, 754, 774, 791, 794 121031 Model 791 DE S CRI P T IO N PART NUM BE R 791 QTY . W ARR. CL AS S RE M ARKS 079127R W 00 - 208 -230V 60HZ 1PH, 079133R W 00 - 208 -230V 60HZ 3PH - 3 W IRE, W /C -BRI ST O L (R 404A) ,RO HS CO M P LI ANT - S TD AR M -D R...
