Superior SLBV-40NE - Manual

Superior SLBV-40NE

Superior SLBV-40NE – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
Page: / 28

Table of Contents:

  • Page 2 – PACKAGING; Millivolt; Use Only These Approved Vent Components:; GENERAL INfORMATION; Les enfants et les adultes devraient; WARNING; TABLE Of CONTENTS
  • Page 3 – Ne pas utiliser cet appareil s’il a été
  • Page 4 – Sea Level to High Altitude; deration
  • Page 5 – COLd CLIMATE INSULATION; When the unit is installed with one side
  • Page 6 – VENT TERMINATION; Multiple Terminations; provided that any discharge opening on; Figure 4; Minimum Height from Roof to; Gas Vent Rule; Table 5
  • Page 7 – MINIMUM CLEARANCES TO COMBUSTIBLES; Appliance and Vent Clearances; on all sides (as detailed in; Hearth Extension; is used, do not block the lower control compartment door. Any hearth
  • Page 8 – PRE-INSTALLATION STEPS; To remove the glass enclosure panel:; safe location to protect it from inadvertent; TYPICAL INSTALLATION; a. Millivolt Appliances: Install the; dETAILEd INSTALLATION STEPS; Step 1. Construct Appliance; fireplace secured to framing; Bend up the
  • Page 9 – fIREPLACE ANd fRAMING SPECIfICATIONS; photographs are not to scale. Product; Natural & Propane Gas; framing dimensions; fIREPLACE fRAMING SPECIfICATIONS; Construct framing with 2x4 or larger lumber.; Corner framing dimensions; CORNER fRAMING dIMENSIONS
  • Page 10 – VERTICAL VENTING THROUGH CEILING; fIREPLACE SPECIfICATIONS
  • Page 11 – Proper Sizing of Gas Line; Also see; Left Side Front; Step 2. Route the Gas Line; Step 3. Install Venting System; Required Pipe diameter; WARNING: EDGES OF SHEET METAL ARE; • Sheet Metal-resistant Gloves
  • Page 12 – Step 4. Install field Wiring; CAUTION; Verify proper operation after installing.
  • Page 13 – MILLIVOLT WIRING dIAGRAM; ELECTRONIC IGNITION WIRING dIAGRAM; Schematic Representation Only
  • Page 14 – Install Outside; at right; INSTALLATION ACCESSORIES; Outside Combustion Air Kits; do not operate the shutoff lever; Left Side of; IMPORTANT: Do NOT move Air Control
  • Page 15 – Step 6. Connect the Gas Line; Figure; Gas; Turn valve handle
  • Page 16 – A. Light the appliance (refer to the lighting; Never use an open flame to; Step 7. Verify Appliance; Electronic Appliance Checkout
  • Page 17 – Place the glowing ember material; Separate into individual; and Logs; Remove the front glass enclosure panel
  • Page 18 – SLBV-35 LOG PLACEMENT INSTRUCTIONS; To prevent sooting, make sure logs do not cover any burner openings.
  • Page 19 – SLBV-40 LOG PLACEMENT INSTRUCTIONS
  • Page 20 – Only doors certified with the appliance; • Handle this glass with extreme; . To access the spring; Step 9. Install the Glass Enclosure; Step 10. Burner Air Shutter
  • Page 21 – Main Burner factory Air Shutter; Locate adjustment rod and adjust air shutter to the standard set-; Move the adjustment rod DOWN to decrease air; When satisfied that the burner flame appearance is normal, re-; Burner Air Shutter Adjustment Procedure
  • Page 22 – Step 11. Perform Spillage Test; Manually-Reset Safety Limit Switch; low to access the switch (also see; is between the
  • Page 23 – Step 12. Install Hood; NOTE: All models must have a hood installed; Step 13. finishing Requirements; Wall details; Top of Appliance; Figure 30: Combustible Wall Framing; Combustible finished; Combustible material; Hood; Bend up standoffs; Header
  • Page 24 – WARNINGS; ). To properly complete the installation of; Figure A; APPOSITION dES MISES EN GARdE RELATIVES
  • Page 25 – GAS CONVERSION KITS; Gas Conversion Kit Installation; Electronic; assume les responsabilités liées à la conversion.
  • Page 26 – Electronic Appliances; All Models
  • Page 27 – Notes
  • Page 28 – LENNOX HEARTH PROdUCTS
Loading the manual

SLBV-35NE
SLBV-40NE

SLBV-35NM
SLBV-35PM

SLBV-40NM
SLBV-40PM

ITS Report No. 100017854

Please read and understand these instructions

BEFORE starting installation.

MODELS

INSTALLATION INSTRUC

TIONS

B-Vent Gas Fireplaces

SLBV 35/40 Models

MILLIVOLT:

ELECTRONIC:

P/N 506009-02 Rev. B 06/2011

This manual is one of a set of two supporting this product.

Refer to P/N 506010-02 for Care and Operation Instructions.
Ce manuel est disponible en francais, simplement

en faire la demande. Numéro de la pièce 506223-19.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.
INSTALLATEUR : Laissez cette notice avec l'appareil.

CONSOMMATEUR : Conservez cette notice pour

consultation ultérieure.

AVERTISSEMENT : Assurez-vous de bien suivre les

instructions données dans cette notice pour réduire au

minimum le risque d’incindie ou d’explosion ou pour

éviter tout dommage matériel, toute blessure ou la mort.

WARNING: If the information in these instructions

is not followed exactly, a fire or explosion may

result, causing property damage, personal injury,

or death.

WARNING /AVERTISSEMENT/AVISO

• HOT GLASS WILL CAUSE

BURNS.

• DO NOT TOUCH GLASS

UNTIL COOLED.

• NEVER ALLOW CHILDREN

TO TOUCH GLASS.

• UNE SURFACE VITRÉE CHAUDE

PEUT CAUSER DES BRÛLURES.

• LAISSER REFROIDIR LA SURFACE

VITRÉE AVANT D'Y TOUCHER.

• NE PERMETTEZ JAMAIS À UN ENFANT

DE TOUCHER LA SURFACE VITRÉE.

• EL VIDRIO CALIENTE

CAUSARÁ QUEMADURAS.

• USTED DEBE NUNCA

TOCAR EL VIDRIO CALIENTE.

• LOS NIÑOS DEBEN NUNCA

TOCAR EL VIDRIO.

- Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any other

appliance.

- WHAT TO DO IF YOU SMELL GAS:

• Do not t

ry to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

• Immediately call your gas supplier from a

neighbor’

s phone. Follow the gas supplier

’s

instructions.

• If you cannot reach your gas supplier, call the fire

department.
- Installation and service must be performed by a

qualified installer, service agency or the gas supplier.

- Ne pas entreposer ni utilizer d’essence ni d’autres vapeurs

ou liquides inflammables dans le voisinage de cet appareil

ou de tout autre appareil.

- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :

• Ne pas tenter d’allumer d’appareil.

• Ne touchez à aucan interrupteu

r. Ne pas vous servir des

téléphones se trouvant dans le bâtiment où vous trouvez.

• Appelez immédiatement votre fournisseur de gaz depuis

un voisin. Suivez les instructions du fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de gaz,

appelez le service des incindies.
-

L

’installation et l’entretien doivent être assurés par un

installateur ou un service d’entretien qualifié ou par le

fournisseur de gaz.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - PACKAGING; Millivolt; Use Only These Approved Vent Components:; GENERAL INfORMATION; Les enfants et les adultes devraient; WARNING; TABLE Of CONTENTS

SUPERIOR ® B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS Packaging .........................................Page 2Introduction ......................................Page 2General Information ..........................Page 2Gas Pressure Requirements ..............Page 4O...

Page 3 - Ne pas utiliser cet appareil s’il a été

SUPERIOR ® B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS Note: Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least annually by a professional service person. More frequent cleaning may be requir...

Page 4 - Sea Level to High Altitude; deration

SUPERIOR ® B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS Figure 2 - Dexen Electronic Gas Valve Pilot Stage Terminal Pressure-Tap (Inlet) Pilot Gas Outlet Supply Gas Inlet Pressure-Tap (Manifold) Burner Stage Terminal Ground (TP) PILOT OUT VENT LO TH TP TH TP HI IN IN Re...

Other Superior Models

All Superior Other