Page 2 - SEZ S; SAFETY PRECAUTIONS
SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 2 O PERATOR ’ S M ANUAL 1183437 SAFETY PRECAUTIONS Before installing and operating this equipment, be sure everyone involved in its operation is fully trained andaware of precautions. Accidents and problems can be caused by failure to follow fundamental rules ...
Page 3 - ABLE OF; Table of Contents
SEZ S ERIES C OUNTERTOP S TEAMERS T ABLE OF C ONTENTS O PERATOR ’ S M ANUAL 1183437 P AGE 3 Congratulations! You have purchased one of the finest pieces of heavy-duty commercial cooking equipmenton the market. You will find that your new equipment, like all Southbend equipment, has been designed and...
Page 4 - PECIFICATIONS; P E C I F I C A T I O N S; DIMENSIONS
S PECIFICATIONS SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 4 O PERATOR ’ S M ANUAL 1183437 S P E C IFIC ATIO N S S P E C I F I C A T I O N S DIMENSIONS Figure 1 16.3" 31.4" See table below 2.0" 15.2" 0.8" 13.8" 2.1" SIDE VIEW FRONT VIEW REAR VIEW Water Drain Water Inlet Elec...
Page 6 - NSTALLATION; N S T A L L A T I O N; CAUTION; IMMEDIATELY INSPECT FOR SHIPPING DAMAGE
I NSTALLATION SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 6 O PERATOR ’ S M ANUAL 1183437 IN S TA LLA TI ON I N S T A L L A T I O N ! CAUTION Do not locate unit adjacent to any high heat or grease producing piece of equipment, such as a rangetop, griddle, fryer, etc., that could allow radiant heat to ra...
Page 7 - Figure 2
SEZ S ERIES C OUNTERTOP S TEAMERS I NSTALLATION O PERATOR ’ S M ANUAL 1183437 P AGE 7 IN S TA LLA TI ON Step 2: Installation 1. Uncrate carefully. Report any hidden damage to the freight carrier IMMEDIATELY. 2. Do not remove any tags or labels until unit is installed and working properly. 3. If unit...
Page 8 - Figure 3
I NSTALLATION SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 8 O PERATOR ’ S M ANUAL 1183437 IN S TA LLA TI ON Figure 3 BOTTOM VIEW Sealant Sealer Steamer
Page 9 - Step 3: Electrical Connection; WARNING; Figure 4
SEZ S ERIES C OUNTERTOP S TEAMERS I NSTALLATION O PERATOR ’ S M ANUAL 1183437 P AGE 9 IN S TA LLA TI ON Step 3: Electrical Connection A field connection Fuse Block is located at the rear of the unit, lower left side when facing the back of the unit(see Figure 4 below). A hole is provided for a 3/4&#...
Page 10 - Step 4: Water Connection; Figure 5
I NSTALLATION SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 10 O PERATOR ’ S M ANUAL 1183437 IN S TA LLA TI ON Step 4: Water Connection ! WARNING Do not connect steamer to a hot water line. A hot water connection will damage the steamer. NOTICE To meet warranty requirements, the supply water must meet the...
Page 11 - Step 3: Drain Connection
SEZ S ERIES C OUNTERTOP S TEAMERS I NSTALLATION O PERATOR ’ S M ANUAL 1183437 P AGE 11 IN S TA LLA TI ON Step 3: Drain Connection The drain outlet is located on the back of the steamer, as shown in Figure 4 on page 9. The drain connectoron the unit is 3/8" NPT male. Position the unit near, but n...
Page 12 - PERATION; P E R A T I O N; STARTUP; NOTICE: WATER SPECIFICATION; OPERATION; SHUTDOWN; NOTICE
O PERATION SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 12 O PERATOR ’ S M ANUAL 1183437 OP E R ATIO N O P E R A T I O N STARTUP 1. Turn lever to “ON” position. 2. Unit will fill automatically and be ready for operation in 11 minutes. NOTICE: WATER SPECIFICATION To meet warranty requirements, supply wate...
Page 13 - OOKING; O O K I N G; COOKING TIPS
SEZ S ERIES C OUNTERTOP S TEAMERS C OOKING H INTS O PERATOR ’ S M ANUAL 1183437 P AGE 13 COO K IN G HINTS C O O K I N G H I N T S COOKING TIPS Schedule cooking of fresh vegetables so that they will be served soon after they are cooked. If it isnecessary to prepare them in advance, they can be plunge...
Page 16 - LEANING; L E A N I N G; WARNING: BURN HAZARD; DAILY CLEANING; PERIODIC CLEANING
C LEANING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 16 O PERATOR ’ S M ANUAL 1183437 CL E ANI NG C L E A N I N G Southbend equipment is constructed with the best quality materials and is designed to provide durableservice when properly maintained. To expect the best performance, your equipment must be...
Page 17 - SEMIANNUAL CLEANING
SEZ S ERIES C OUNTERTOP S TEAMERS C LEANING O PERATOR ’ S M ANUAL 1183437 P AGE 17 CLE ANING • To remove grease and food splatter or condensed vapors that have baked on the equipment, applycleanser to a damp cloth or sponge and rub cleanser on the metal in the direction of the polishing lineson the ...
Page 18 - ROUBLESHOOTING; R O U B L E S H O O T I N G; TROUBLESHOOTING KEY; TROUBLESHOOTING FIGURES AND PROCEDURES
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 18 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G T R O U B L E S H O O T I N G This section contains a troubleshooting key and referenced flowcharts to assist a qualified service technicianin the servicing of an SEZ Series Countertop Ste...
Page 19 - Unit Not Heating Up, “ON” Light Not Lit
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 19 TROU BLE S H OOTI N G Unit Not Heating Up, “ON” Light Not Lit Unit not heating up, “ON” light not lit. Check that circuit breaker is ON and that proper voltage is available at main fuse block. DISCONNECT POWER ...
Page 20 - Unit Not Heating Up Properly or Not Cooking Properly, “ON” Light Lit
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 20 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G Unit Not Heating Up Properly or Not Cooking Properly, “ON” Light Lit Unit not heating up properly or not cooking properly, “ON” light lit. Reconnect power to unit. Turn unit on. WAIT 5 MIN...
Page 21 - Excessive Steam Coming from Pressure Relief Vent
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 21 TROU BLE S H OOTI N G Excessive Steam Coming from Pressure Relief Vent Excessive steam coming from pressure relief vent. DISCONNECT POWER AT CIRCUIT BREAKER. Check pressure switch for proper operation (see Figu...
Page 22 - “Service Request” Light Comes On During Operation
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 22 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G “Service Request” Light Comes On During Operation “Service Request” light comes on during operation. Is water level at normal level in cavity? Yes No Check for adequate water pressure to u...
Page 23 - Buzzer Does Not Come On
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 23 TROU BLE S H OOTI N G Buzzer Does Not Come On Buzzer does not come on. DISCONNECT POWER AT CIRCUIT BREAKER. Remove control panel. Does timer time down? No Replace timer. Continuity? Replace buzzer. Yes No Yes R...
Page 24 - Figure 7; Voltage Check at Control Panel Fuse Block
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 24 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G Figure 7 Voltage Check at Control Panel Fuse Block Door Switch Control PanelFuse Block Power Switch Terminal Block “SERVICE REQUEST” Light “ON” Light 1. DISCONNECT POWER AT CIRCUIT BREAKER...
Page 25 - Figure 8; Heating Element Resistance Check (at Contactor)
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 25 TROU BLE S H OOTI N G Figure 8 Heating Element Resistance Check (at Contactor) B A Contactor(top view) C 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove control panel. 3. DO NOT REMOVE HEATING ELEMENT LEAD W ...
Page 26 - Figure 9; Main Fuse Replacement
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 26 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G Figure 9 Main Fuse Replacement Shown with Rear Cover Removed 3/4" Conduit Fitting Hole Water Inlet Connection Main Fuse Block Drain Connection 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2...
Page 27 - Power Switch Continuity Check
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 27 TROU BLE S H OOTI N G Figure 10 Power Switch Continuity Check Control Panel Fuse Block “ON” Light Power Switch 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove control panel. 3. Turn Lever to “ON” from “OFF” a...
Page 28 - Contactor and MOV Check
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 28 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G Figure 11 Contactor and MOV Check A B C D E F Actuator MOV TOP VIEW LEFT SIDE VIEW 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove control panel and disconnect twelve-pin plug PL1. 3. De...
Page 29 - Timer and Buzzer Check
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 29 TROU BLE S H OOTI N G Figure 12 Timer and Buzzer Check Buzzer Timer 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove control panel. 3. Set timer for one minute and allow to time out. If timer does not run, the...
Page 30 - Door Switch Continuity Check
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 30 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G Figure 13 Door Switch Continuity Check 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove control panel. 3. Depress and release door switch actuator rod to make sure door switch is properly...
Page 31 - Float Switch Continuity Check
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 31 TROU BLE S H OOTI N G Figure 14 Float Switch Continuity Check Float Control Box Float Switch Float Switch Fitting 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove rear cover from unit. 3. Disconnect float swit...
Page 32 - Controller Check
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 32 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G Figure 15 Controller Check 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove control panel, but leave plugged in. 3. Disconnect wires from positions 2, 3, 4, 7, 8, and 9 on controller. Cov...
Page 33 - Water Solenoid Check
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 33 TROU BLE S H OOTI N G Figure 16 Water Solenoid Check 1. DISCONNECT POWER AT CIRCUITBREAKER. 2. Remove rear cover. 3. Disconnect water solenoid lead wires from wires B60 and B61. 4. Place test leads into water s...
Page 34 - Pressure Switch Check
T ROUBLESHOOTING SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 34 O PERATOR ’ S M ANUAL 1183437 TROU BLE S H OOTI N G Figure 17 Pressure Switch Check COM Float Control Box Pressure Switch SWITCH DETAIL NONC 1. DISCONNECT POWER AT CIRCUIT BREAKER. 2. Remove rear cover. 3. Remove wires B40 and B42 from pres...
Page 35 - High-Limit Thermostats Check
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 35 TROU BLE S H OOTI N G Figure 18 High-Limit Thermostats Check 1. Note: Allow cavity bottom to cool before performing this test. 2. Disconnect left thermostat lead wire from wire B62. 3. Disconnect center thermos...
Page 37 - Electric Schematic for 480 Volt Model SEZ/3
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 37 TROU BLE S H OOTI N G Figure 20 Electric Schematic for 480 Volt Model SEZ/3
Page 39 - Electric Schematic for 480 Volt Model SEZ/5
SEZ S ERIES C OUNTERTOP S TEAMERS T ROUBLESHOOTING O PERATOR ’ S M ANUAL 1183437 P AGE 39 TROU BLE S H OOTI N G Figure 22 Electric Schematic for 480 Volt Model SEZ/5
Page 40 - ARTS; A R T S
P ARTS SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 40 O PERATOR ’ S M ANUAL 1183437 PA RT S P A R T S NOTICE INSTALLATION OF OTHER THAN GENUINE SOUTHBEND PARTS WILL VOID THE W ARRANTYON THIS EQUIPMENT. The serial plate with voltage, model, and serial information is located on the right side of the steam...
Page 41 - Cavity and Heater Parts
SEZ S ERIES C OUNTERTOP S TEAMERS P ARTS O PERATOR ’ S M ANUAL 1183437 P AGE 41 PARTS Cavity and Heater Parts 1 2 3 4 5 6 Part Number Key Model SEZ/3 Model SEZ/5 Qty Description 1 1 1 8 1 5 0 8 1 1 8 1 7 7 1 6 Heater, cartridge, 208V (1500W for SEZ/3, 1834W for SEZ/5) 1 1 8 1 5 0 9 1 1 8 1 7 7 2 6 H...
Page 44 - Control Panel Parts (Front and Isometric Views)
P ARTS SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 44 O PERATOR ’ S M ANUAL 1183437 PA RT S Control Panel Parts (Front and Isometric Views) 1 2 3 4 5 6 7 8 9 10 11 NOTE: The entire Control Panel Assembly can be ordered as part number 1183428. Key Part Number Qty Description 1 1 1 7 8 3 3 1 1 Switch, doo...
Page 45 - Door Assembly Parts
SEZ S ERIES C OUNTERTOP S TEAMERS P ARTS O PERATOR ’ S M ANUAL 1183437 P AGE 45 PARTS Door Assembly Parts 1 2 3 4 5 6 7 Part Number Key Model SEZ/3 Model SEZ/5 Qty Description 1 1 1 7 7 3 1 7 1 1 7 7 3 1 7 1 Latch assembly 2 1 1 7 7 0 8 0 1 1 7 7 0 8 0 1 Cast striker 3 1 1 7 8 1 7 1 1 1 8 1 0 1 8 1 ...
Page 46 - Water Inlet and Drain Parts
P ARTS SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 46 O PERATOR ’ S M ANUAL 1183437 PA RT S Water Inlet and Drain Parts See drawing on following page. Key Part Number Qty Description 1 1 1 8 1 5 7 9 1 Elbow 1/4CC x 1/4 MPT 2 1 1 8 1 5 8 9 1 Tube, water inlet 3 P P - 2 8 5 1 Fitting, 1/4 NPT male 4 1 1 8...
Page 48 - Float Tank Parts
P ARTS SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 48 O PERATOR ’ S M ANUAL 1183437 PA RT S Float Tank Parts See drawing on following page. Key Part Number Qty Description 1 1 1 8 3 4 1 3 1 Fitting, float 2 1 1 7 4 9 2 4 1 Float switch, water fill 3 1 1 8 3 4 0 2 1 Box, float control weld assembly 4 1 1...
Page 52 - SUPER SIMPLE STEAM
SEZ S ERIES C OUNTERTOP S TEAMERS P AGE 52 O PERATOR ’ S M ANUAL 1183437 SUPER SIMPLE STEAM SEZ SERIES COUNTERTOP STEAMERS A product with the Southbend name incorporates the best in durability and low maintenance. Weall recognize, however, that replacement parts and occasional professional service m...
