Senco PC1005 Manual - Free PDF Download

Page 2 - TABLE OF CONTENTS

2 TABLE OF CONTENTS INTRODUCTION ................................................................... 3 SAFETY ALERT ..................................................................... 3 INSPECTION ......................................................................... 3 SAFETY WARNINGS ............

Page 3 - INTRODUCTION; COULD result in death or serious injury.; INSPECTION

3 INTRODUCTION Congratulations on the purchase of your new SENCO ® Air Compressor! You can be assured your SENCO AirCompressor was constructed with the highest level of precision and accuracy. Each component has been rigorouslytested by technicians to ensure the quality, endurance and performance of...

Page 4 - SAFETY WARNINGS; READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR

4 POTENTIAL CONSEQUENCE Serious injury or death could occur ifthe air compressor is not properlygrounded. Your air compressor ispowered by electricity and may causeelectric shock or electrocution if notused properly. Electrical shock may occur fromelectrical cord. Electrical shock may occur if airco...

Page 8 - COMPRESSOR FEATURES

8 COMPRESSOR FEATURES 1 Motor/Pressure Switch 2 Thermal Overload / Reset 3 Air Intake Filter 4 Air Compressor Pump 5 Air tank drain valve 6 Tank Pressure Gauge 7 Outlet Pressure Gauge 8 Pressure Regulator 9 Oil Dipstick 10 Oil Drain11 Discharge Line 12 115 Volt Electric Power Cord13 Quick Disconnect...

Page 10 - PREPARATION; CAUTION

10 PREPARATION INITIAL SET-UP:1. Read safety warnings before setting-up air compressor. 2. Ensure the oil level is above the minimum notch and below the maximum notch on the dipstick. If low, addcompressor pump oil. LOCATION: CAUTION In order to avoid damaging the air compressor, do not incline the ...

Page 11 - OPERATION; more than 10 PSI of air pressure is in the air tank!; MAINTENANCE; MAINTENANCE CHART

11 OPERATION PRE-START CHECKLIST: 1. Check oil level. Add if necessary.2. Remove any moisture in the air compressor air tank. Remove excessive pressure with an air tool, then open the air tank drain valve in the bottom of the air tank. Close tightly when drained. WARNING: Risk of bodily injury. NEVE...

Page 12 - TROUBLESHOOTING; Symptom 1. Motor will not run or restart.

12 TROUBLESHOOTING Symptom 1. Motor will not run or restart. Symptom 2. Noisy operation. Power cord not plugged in. Motor/Pressure switch in “OFF” position. M o t o r t h e r m a l o v e r l o a d s w i t c h h a stripped. Fuse blown or circuit breaker has tripped. Wrong gauge wire or length of exte...

Page 13 - Symptom 6. Air leaks from safety relief valve.

13 PROBABLE CAUSEMotor/Pressure switch does not shut off motor whenair compressor reaches “cut-out” pressure and safetyrelief valve activates. Air compressor is incorrectly sized. PROBABLE CAUSEDefective pilot valve, the check valve is stuck open. PROBABLE CAUSEDefective motor/pressure switch. PROBA...

Page 14 - Symptom 13. Excessive oil consumption in pump.

14 TROUBLESHOOTING Symptom 13. Excessive oil consumption in pump. PROBABLE CAUSERestricted air intake filter. Air compressor on unlevel surface. Crankcase overfilled with oil. Plugged oil dipstick vent. Oil leaks. Worn piston rings or scored cylinder. REMEDYClean or replace. Do not incline the air c...

Page 15 - SPECIFICATIONS

15 SPECIFICATIONS Model # PC 1005 Motor Horsepower 1,0 Voltage 115 Amperage 12 Hz. 60 Phase Single RPM 3400 Compressor Pump Number of Cylinders 1 Compression Stage 1 Lubrication Oil-splah Oil Type SENCO PC 0344 Crankcase Aluminium Bearings Ball Cylinder Aluminium + steel sleewer Valves Reed-Single H...

Page 16 - SENCO COMPRESSOR AND PARTS WARRANTY

16 SENCO COMPRESSOR AND PARTS WARRANTY This compressor has been designed and constructed using the highest standards of material and workmanship. COMPRESSOR WARRANTY: The length of this guarantee is one year from date of purchase by the original retail purchaser. During this period, Senco Products, ...