Robin-Subaru PTX301D - Manual

3 ENGLISH FRANÇAISE ESPAÑOL ■ Do not touch the ignition cable when starting and operating theengine. ■ Operate the pump on a stable, level surface.If the engine is tilted, fuel spillage may result. ■ Do not transport the pump with fuel in tank or with fuel strainer cock open. ■ Keep the unit dry (do...

SYMBOLS COMPONENTS(See Fig. 1 1 ) Please refer to the illustrations on the back page of the front cover or back coverfor Fig. 1 1 to 8 8 indicated in the sentence. NOTE q Oil filler (with Oil guage) w Pump body e Gear case r Fuel tank t Muffler y Air cleaner u Spark plug i Drain plug (at two places)...

5 ENGLISH FRANÇAISE ESPAÑOL Always use a strainer with the suctionhose. Gravel or debris sucked into thepump will cause serious damage to theimpeller and the pump casting. CAUTION Do not refuel while smoking, near an openflame or other such potential fire hazards.Otherwise fire accident may occur. W...

6 ENGLISH FRANÇAISE ESPAÑOL OPERATING YOUR PUMP 1. STARTING (See Fig. 3 3 ) 1. DAILY INSPECTION 3. STOPPING (See Fig. 5 5 ) (1) Open the fuel cock. (See Fig. 3 - q ) (2) Turn the STOP SWITCH to the position “ I ” (ON). (See Fig. 3 - w ) (3) Set the speed control lever 1/3 of the way towards the high...

7 ENGLISH FRANÇAISE ESPAÑOL 2. PERIODIC INSPECTION Periodic maintenance is vital to the safe and efficient operation of your pump. Check the table below for periodic maintenance intervals. IT IS ALSO NECESSARY FOR THE USER OF THIS PUMP TO CONDUCT THE MAINTENANCE AND ADJUSTMENTS ON THE EMISSION- RELA...

8 ENGLISH FRANÇAISE ESPAÑOL 3. INSPECTING THE SPARK PLUG (See Fig. 7 7 - q q ) (1) Clean off carbon deposits on the spark plug electrode using a plug cleaner or wire brush. (2) Check electrode gap. The gap should be 0.6 mm to 0.7 mm (0.02 inch.-0.03 inch.).Adjust the gap, if necessary, by carefullyb...

9 ENGLISH FRANÇAISE ESPAÑOL Take extreme caution when replacingfuel hose ; gasoline is extremelyflammable. WARNING 7. FUEL HOSE REPLACEMENT (See Fig. 7 7 - y y ) Replace the fuel hose every 1,000 hours or every year. If fuel leaks from fuel hose, replace the fuel hose immediately. Flame Prohibited W...

10 ENGLISH FRANÇAISE ESPAÑOL 1. FUNCTION OF OIL SENSOR The engine will stop automatically when the oil level falls below the safety limit. The engine cannot be started unless the level is raised above the prescribed limit. (See Fig. 2 - t ) In a dry or wooded area, it is recommendable to use the pro...

11 ENGLISH FRANÇAISE ESPAÑOL 1. PUMP DOES NOT RUN. ■ Engine dose not start. (See “ WHEN ENGINE DOES NOT START ”) ■ Solid object preventing pump-rod from completing stroke. (Disassemble and clean.) (1) Is there a strong spark across the electrode ? ■ Is the stop switch at position “ I ” (ON)? ■ Remov...