Robin-Subaru PKV101 - Manual

Page 5 - F E DE R A L E MIS S IO N S C O MP O N E N T DE F E C T W A R R A N T Y

U S G B G B G B G B G B G B G B G B G B G B G B G B G B G B G B F E DE R A L E MIS S IO N S C O MP O N E N T DE F E C T W A R R A N T Y E MIS S IO N S C O MP O N E N T D E F E C T W A R R A N T Y C O V E R A G E – T his e mis s ion wa rra nty is a pplica ble in a ll S ta te s , e xce pt the s ta te ...

Page 8 - FOREWORD; Thank you very much for purchasing a ROBIN PUMP.; cover or back cover for Fig.; CONTENTS

GB 1 FOREWORD Thank you very much for purchasing a ROBIN PUMP. This manual covers operation and maintenance of ROBIN PUMP. All information in this publication is based on the latest product information available at thetime of approval for printing. Please read this manual carefully before operating....

Page 9 - SAFETY PRECAUTIONS

GB 2 : EXHAUST PRECAUTIONS ■ Never inhale exhaust gasses. They contain carbon monoxide, a colorless, odorless and extremely dangerous gas which can cause unconsciousness or death. ■ Never operate the pump indoors or in a poorly ventilated area, such as tunnel, cave, etc. ■ Exercise extreme car...

Page 10 - CAUTION

GB 3 ■ Do not touch the spark plug and ignition cable when starting and operating the engine. ■ Operate the pump on a stable, level surface. If the engine is tilted, fuel spillage may result. ■ Drain the fuel when transporting the pump. ■ Keep the unit dry (do not operate it in rainy conditi...

Page 11 - li

GB 4 2. COMPONENTS (See Fig. 1 1 1 1 1 ) SYMBOLS q Plug (drain) w Suction e Delivery r Plug (priming) t Handle y Spark plug cover u Spark plug i Air cleaner o Carburetor !0 Primer button !1 Tank cap !2 Fuel tank !3 Casing cover !4 Speed control lever !5 Stop Switch !6 Set base !7 Oil filler (with oi...

Page 12 - OPERATING YOUR PUMP

GB 5 3. PRE-OPERATION FOR STARTING (See Fig. 2 2 2 2 2 ) ■ Stop the engine and open the cap. ■ Incline the engine as fuel inlet upward, then refill fuel to the upper level. Do not fill fuel too much. ■ Use unleaded automotive gasoline only. Fuel Tank Capacity (This engine is 4-stroke gasolinee...

Page 13 - INSPECTING THE SPARK PLUG; Recommended Spark Plug : NGK CMR6A; PERIODIC INSPECTION; Periodic Maintenance Schedule table

GB 6 3. INSPECTING THE SPARK PLUG (See Fig. 7 7 7 7 7 - q q q q q ) (1) Clean off carbon deposits on the spark plug electrode using a plug cleaner or wire brush. (2) Check electrode gap. The gap should be 0.7 mm to 0.8 mm (0.03 inch.). Adjust the gap, if necessary, by carefully bending the side elec...

Page 14 - : Every 50 hours of operation; CLEANING FUEL FILTER; CLEANING AIR CLEANER; Flame Prohibited

GB 7 4. ENGINE OIL CHANGE (See Fig. 7 7 7 7 7 - w w w w w 〜 t t t t t ) Initial oil change : After 20 hours of operationThereafter : Every 50 hours of operation (1) When changing oil, stop the engine and loosen the drain plug. Drain the used oil while the engine is warm. Warm oil drains quickly and ...

Page 15 - PREPARATIONS FOR STORAGE; When retightening drain plug, be sure to clean; FUEL HOSE REPLACEMENT; Take extreme caution when replacing fuel hose ; WARNING; ADJUSTING CARBURETOR

GB 8 1. WATER (See Fig. 8 8 8 8 8 - q q q q q ) Drain all water from the drain plug. 6. PREPARATIONS FOR STORAGE In case the engine is not going to be used for more than 1 month, discharge fuel thoroughly from fuel tank and carburetor in order to prevent from hard starting and/or poor engine operati...

Page 16 - EASY TROUBLESHOOTING; Before testing, carefully wipe off spilled fuel.

GB 9 7. EASY TROUBLESHOOTING 1. PUMP DOES NOT RUN . ■ Engine dose not start. (See 7.-4 “4. WHEN ENGINE DOES NOT START”) ■ Sticking of impeller (Disassemble and clean.) 2. PUMPING VOLUME IS SMALL. ■ Sucking air at suction side. (Check piping at suction side.) ■ Drop off engine output (Consult your ne...

Robin-Subaru PKV101 - Manual

Table of Contents:

Summary

Other Robin-Subaru Models