Robin-Subaru EX 21D - Manual

Page 3 - US; NOTICE

US NOTICE FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIA EMISSION CONTROL WARRANTY are applicable to only those engines complied with EPA (Environmental Protection Agency) and CARB (California Air Resources Board) emission regulations. The engine exhaust from this product contains chemica...

Page 4 - FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY

US FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE This emission warranty is applicable in all States, except the State of California. Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein “ROBIN AMERICA”) warrant(s) to the initial re...

Page 7 - CONTENTS; Page; FOREWORD; Thank you very much for purchasing a ROBIN ENGINE.; cover or back cover for Fig.

US 1 CONTENTS Page 1. SAFETY PRECAUTIONS… ............................................................................. 2 2. COMPONENTS ................................................................................................ 4 3. PRE-OPERATION CHECKS… ...........................................

Page 8 - : EXHAUST PRECAUTIONS; SAFETY PRECAUTIONS

US 2 : EXHAUST PRECAUTIONS ■ Never inhale exhaust gasses. They contain carbon monoxide, a colorless, odorless and extremely dangerous gas which can cause unconsciousness or death. ■ Never operate the engine indoors or in a poorly ventilated area, such as tunnel, cave, etc. ■ Exercise extreme care...

Page 9 - CAUTION

US 3 ■ Do not touch the spark plug and ignition cable when starting and operating the engine. ■ Never make adjustments on the machinery while it is connected to the engine, without first removing the ignition cable from the spark plug. Turning the crankshaft by hand during adjusting or cleaning mi...

Page 11 - ELECTRIC STARTER MODELS; WARNING

US 5 F o r e l e c t r i c s t a r t e r o p e r a t i o n , p r o p e r e l e c t r i c w i r i n g arrangements are needed before normal engine operation. 1. BATTERY ■ Use a battery rated 12V - 24AH or larger. 4. ELECTRIC STARTER MODELS 2. BATTERY CABLE 3. KEY SWITCH CABLE Cable length Cable dia....

Page 12 - OPERATING YOUR ENGINE

US 6 1. STARTING (1) Open the fuel cock. (See Fig. 4 - q ) (2) Turn the STOP SWITCH to the position “ I ” (ON). (See Fig. 4 - w ) (3) Set the speed control lever 1/3 of the way towards the high speed position. (See Fig. 4 - e ) (4) Close the choke lever. (See Fig. 4 - r ) ■ If the engine is cold or...

Page 13 - PERIODIC INSPECTION; Periodic Maintenance Schedule table

US 7 Maintenance Items Every 8 hours (Daily) Every 20 hours Every 50 hours (Weekly) Every 200 hours (Monthly) Every 500 hours Every 1000 hours CLEAN ENGINE AND CHECKBOLTS AND NUTS ● (Daily) CHECK AND REFILL ENGINE OIL CHANGE ENGINE OIL (*Note 1) ● (Initial) ● CLEAN SPARK PLUG ● CLEAN AIR CLEANER ● R...

Page 14 - Flame Prohibited; Flame Prohibited

US 8 (1) Inspect fuel cup for water and dirt. (See Fig. 7 - t - q ) (2) To remove water and dirt, close the fuel cock and remove the fuel cup. (3) After removing dirt and water, wash the fuel cup with kerosene or gasoline. Reinstall securely to prevent leakage. 6. CLEANING AIR CLEANER(See Fig. 7 7 7...

Page 15 - PREPATIONS FOR STORAGE; FUNCTION OF OIL SENSOR; OIL SENSOR INSTRUCTIONS; WHEN ENGINE WILL NOT START :; EASY TROUBLESHOOTING

US 9 1. DISCHARGE FUEL (See Fig. 8 8 8 8 8 - q q q q q ) 7. PREPATIONS FOR STORAGE If you do not use the engine more than 1 month, discharge fuel to prevent gum in the fuel system and carburetor parts. ■ Remove the fuel cup, place it over a container and open the fuel cock to discharge fuel from th...

Page 18 - MODEL

ISSUE EMD-EU1622 2ZZ9990063 PRINTED IN JAPANJune 2002 CE‑ Y E X 1 3 D / E X 1 7 D E X 2 1 D / E X 2 7 D MODEL

Robin-Subaru EX 21D - Manual

Table of Contents:

Summary

Other Robin-Subaru Models