Razor 15130760 - Manual - manualsarea.com

Page 2 - SAFETY WARNINGS

WARNING: Riding the electric chopper can be a hazardous activity. Certain conditions may cause the equipment to fail without fault of the manufacturer. Like other electric vehicles, the electric chopper can and is intended to move, and it is therefore possible to lose control, fall off and/or get in...

Page 3 - Estimated Assembly and Set-Up Time; BEFORE YOU BEGIN; WARNING; Required Tools; or call toll-free at

Remove contents from box. Remove the foam separators that protect the components from damage during shipping. Inspect the contents of the box for scratches in the paint, dents or kinked cables that may have occurred during shipping. Because the electric chopper was 95 percent assembled and packed at...

Page 5 - Attaching the Handlebars; REPAIR AND MAINTENANCE; Adjusting the Brakes; Mini Chopper; Rebellion Chopper; Testing the Brakes

1 Press the spring buttons on each side of the handlebars and tap the bars until the spring buttons slide inside and engage the corresponding holes in the fork. 2 When correctly engaged, the handlebars will not disengage from the fork. 3 Tighten all four pinch clamp screws (two in the upper and two ...

Page 6 - Chain and Sprocket Adjustment – Mini Chopper; Infl ating the Tires; Note

5 REPAIR AND MAINTENANCE Chain and Sprocket Adjustment – Mini Chopper Note : Late model Mini Electric Choppers and Rebellion Electric Choppers are equipped with a chain tensioner, are self adjusting and will not use this method to adjust the chain. The chain will typically have a “loose spot” and “t...

Page 7 - Chain and Tire Replacement – Mini Chopper

6 REPAIR AND MAINTENANCE Chain and Tire Replacement – Mini Chopper WARNING: To avoid a pinch or injury, keep ﬁ ngers away from moving sprockets and chain. WARNING: Increasing the tension too much can snap the chain or bend the motor output shaft. To avoid this, use caution where tightening and caref...

Page 10 - TROUBLESHOOTING GUIDE

9 Vehicle does not run Vehicle was running but suddenly stopped Short run time (less than 30 minutes per charge) Vehicle runs sluggishly Problem Possible Cause Solution Undercharged battery Charger is not working Loose wires or connectors Burned out fuse Motor or electrical switch damage Undercharge...

Page 11 - or

10 Sometimes the vehicle doesn’t run, but other times it does Charger gets warm during use Vehicle does not stop when applying the brake Vehicle makes loud noises or grinding sounds Problem Possible Cause Solution Loose wires or connectors Motor or electrical switch damage Normal response to charger...

Page 12 - MINI ELECTRIC CHOPPER PARTS; Electronic control module

Keep your Mini Electric Chopper running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability. (Speciﬁ cations subject to change without notice.) MINI ELECTRIC CHOPPER PARTS 1. Handlebar, drag-style 2. Valve stem extender/inﬂ ator 3. Hand...

Page 14 - REBELLION ELECTRIC CHOPPER PARTS; Steering bolt assembly

Keep your Rebellion Electric Chopper running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability. (Speciﬁ cations subject to change without notice.) REBELLION ELECTRIC CHOPPER PARTS 13 1. Front wheel, tire, tube, axle, nut 2. Front fend...

Page 16 - Razor Limited Warranty; WARRANTY; Mini Electric Chopper; Loose Parts; SAFETY REMINDERS

Tire Inﬂ ation Periodically inspect the tires for excess wear and replace as required, and regularly check the tire pressure and re- inﬂ ate as necessary. If you get a ﬂ at tire, the inner tube can be patched or a new tube can be purchased from Razor or an authorized repair center. Safety Gear Alway...

Razor 15130760 - Manual

Table of Contents:

Summary

Other Razor Models