Raypak RAY014781 - User Manual

Raypak RAY014781

Raypak RAY014781 Heater – User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
Page: / 36

Table of Contents:

  • Page 3 – CONTENTS
  • Page 4 – DANGER; substantial property damage if ignored.; WARNING; death or substantial property damage if ignored.; or product or property damage if ignored.; CAUTION; not related to personal injury hazards.
  • Page 5 – resulting from chemical imbalance is not covered by; Automatic chemical dosing devices and salt; and Chemical Feeders; Water Temperature
  • Page 6 – BEFORE INSTALLATION; AVERT; Components
  • Page 8 – AVERTISS; Dégagements minimaux à assurer entre les parois de; FLOOR; Heater must be mounted on a level base, such as
  • Page 9 – Figure 5. Florida Building Code Tie-Down Method; Figure 4. Heater Dimensions
  • Page 10 – High Wind Conditions (Outdoor Units Only)
  • Page 11 – Ia plaque signalétique.; Minimum Air Net Free Area - Exterior Source; Appliance Categories
  • Page 12 – All gas piping should be tested after installation in; Manifold Gas
  • Page 14 – To set bypass: With clean filter, adjustment is made by
  • Page 15 – ATTENTIO; 40 Volt Installation Instructions; HEATER; SUPPLY
  • Page 16 – Figure 19. Water Temperature Thermostat
  • Page 18 – Resets board to factory default; Figure 27. Programmable Events
  • Page 20 – Operation; CAUTI; Figure 30. The remote works by either making or breaking; OFF Mode; ATTENTION; OBSERVE PRECAUTIONS; ELECTROSTATIC; Important Installation Notes for Remote or External
  • Page 22 – meme partiellement. Faites inspecter l’appareil par un; AVERTISSEMENT; Moderate Climate
  • Page 24 – Water Pressure Switch Adjustment; Adjustment Knob
  • Page 25 – Figure 41. Gas Valve Removal
  • Page 28 – END; PV; YES
  • Page 30 – ILLUSTRATED PARTS LIST
  • Page 34 – NOTES
Loading the manual

CATALOG NO. 6100.62G

Effective: 06-08-18

Replaces: 04-15-18

P/N 241519 Rev. 8

A

A

WARNING:

If the information in these

instructions are not followed exactly, a fire or

explosion may result causing property damage,

personal injury or death.

FOR YOUR SAFETY:

Do not store or use

gasoline or other flammable vapors and

liquids or other combustible materials in the

vicinity of this or any other appliance. To do

so may result in an explosion or fire.

WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not

use any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas suppli-

er’s instructions.

• If you cannot reach your gas supplier, call

the fire department.

Installation and service must be performed by

a qualified installer, service agency or the gas
supplier

.

Atmospheric

Above-Ground
Pool & Spa Heater

(Chauffe-Piscine)

English/French

A

A

AVERTISS

EMENT: Assurez-vous de bien

suivre les instructions données dans cette notice

pour réduire au minimum le risque d’incendie ou

d’explosion ou pour éviter tout dommage matériel,

toute blessure ou la mort.

Ne pas entreposer ni utiliser d’essence ou ni

d’autres vapeurs ou liquides inflammables à

proximité de cet appareil ou de tout autre appareil.

CE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:

• Ne pas tenter d’allumer d’appareil.

• Ne touchez á aucun interrupteur; ne pas

vous servir des téléphones se trouvant dans

la bâtiment.

• Appelez immédiatement votre fournisseur

de gaz depuis un voisin. Suivre les instruc-

tions du fournisseur.

• Si vous ne pouvez rejoindere le fournisseur,

appelez le service es incendies.

L’installation et l’entretien doivent être assurés

par un installeur qualifié ou par le fournisseur

de gaz.

INSTALLATION AND

OPERATION MANUAL

Models 106 and 156

This manual should be maintained in legible condition and kept adjacent to the heater or in a safe place for future

reference.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - CONTENTS

3 CONTENTS 1. WARNINGS ................................................................... 4 1.1. Pay Attention to These Terms .............................. 4 2. WATER CHEMISTRY ................................................... 5 2.1. Automatic Chlorinators and Chemical Feeders......................

Page 4 - DANGER; substantial property damage if ignored.; WARNING; death or substantial property damage if ignored.; or product or property damage if ignored.; CAUTION; not related to personal injury hazards.

4 A A DANGER: Failure to install the drafthood on indoor installation and properly vent the heater to the outdoors as outlined in the venting section of this manual can result in unsafe operation of the heater. To avoid the risk of fire, explosion, or asphyxiation from carbon monoxide, never operate...

Page 5 - resulting from chemical imbalance is not covered by; Automatic chemical dosing devices and salt; and Chemical Feeders; Water Temperature

5 2. WATER CHEMISTRY NOTE: Corrosive water voids all warranties. Chemical imbalance can cause severe damage to your heater and associated equipment. Maintain your water chemistry according to Table A. If the mineral content and dissolved solids in the water become too high, scale forms inside the he...

Other Raypak Heaters Models

All Raypak Heaters