Raypak 6300 - Manual - manualsarea.com

Page 2 - PRODUCT SAFETY SIGNS AND LABELS; AUDIENCE; The audience for this manual is twofold:; WARRANTY CLAIMS; CAUTION

i PRODUCT SAFETY SIGNS AND LABELS This manual, as well as the pool/spa heat pump itself, contains ANSI-approved product safety signs and labels. Please read these signs and labels, as they convey important safety information about hazards that may be potentially present in and around the heat pump. ...

Page 3 - ii; Swimming Pool Heat Pump; CONTENTS

ii Swimming Pool Heat Pump OWNER’S MANUAL - Models 5300, 6300, 8300 CONTENTS Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 I. Installation Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

Page 4 - WARNING

1 Introduction This pool heat pump is an electromechanical machine that incorporates a pressurized refrigerant gas in a sealed system. ONLY trained and qualified service personnel are authorized to install or service this equipment. Without proper training and knowledge of such equipment, any attemp...

Page 5 - II. Electrical Connections; Table 1: Typical System Electrical Power Requirements; Model

2 Situate the pool heat pump carefully to minimize installation costs while providing maximum efficiency of operation, and to allow adequate service access, as follows: • For unrestricted air intake and service access, position each side of the unit at least 1 ft (30 cm) from walls, pipes and other ...

Page 6 - III. Water Connections; WATER IN; IV. Controls and Indicator Lamps; Water Pressure Switch

3 III. Water Connections The heat pump inlet and outlet connections are NOT interchangeable. They must be connected as instructed below. 1. Connect the heat pump in the return water line between the filter and the pool/spa. See page 10, Plumbing Diagrams. 2. Connect the filter outlet to the fitting ...

Page 7 - : There are 6 indicator lamps located on the unit control panel:; ON

4 interruption, this solid state device will prevent compressor restart for approximately 5 minutes. Upon power failure or interruption, a 6 to 8 minute delay will also be initiated. Refrigerant Low Pressure Control : Stops the compressor if refrigerant suction (low side) pressure falls too low as a...

Page 9 - IX. Freeze Protection; Remote; Continuous Pump Operation

6 VII. Heat Pump Running Time 1. Determine the length of pump and heat pump operating time necessary for your particular requirements. Minimum run time should be the required hours to attain proper water filtration. Maximum run time obviously is 24 hours per day, or as required to reach desired wate...

Page 10 - coverage; must

7 X. Maintenance NOTE: The heat pump MANUFACTURER IS NOT RESPONSIBLE for maintenance adjustments. The following maintenance procedures are designed to keep your heat pump operating at a high level of reliability. Maintenance must be performed on a periodic basis to maintain warranty coverage and pre...

Page 11 - Power; Verify that the breaker is set and; Water Flow

8 • Is water condensing on the evaporator and internal copper pipes? This is also evidence of heat removal from the air. When the air is cool with low humidity, condensation may not be evident. • How long has the unit been operating? During initial pool heating in cold weather, it may require a week...

Page 12 - C. CONDENSATION SEEMS EXCESSIVE; not; XII. Service Call Verification; first

9 C. CONDENSATION SEEMS EXCESSIVE Heat pumps can produce a large amount of condensation (water) during operation. If you suspect that the heat pump is leaking: a. Use a pool chemistry test kit to confirm there is no chlorine in the condensation. Or, b. Shut the heat pump OFF and leave the filter pum...

Page 13 - Plumbing Diagrams

10 Plumbing Diagrams For systems with pumps of 2 HP or greater (over 80 gpm), an external bypass is required. Adjust the bypass valve to divert a minimum of 40 gpm through the heat pump. Connections are 2-inch unions. Plumb the heat pump after the filter and before any chlorinators. Water In (from p...

Raypak 6300 - Manual

Table of Contents:

Summary

Other Raypak Models