Raypak 195A - Manual

Raypak 195A

Raypak 195A – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
Page: / 28

Table of Contents:

  • Page 2 – Contents
  • Page 3 – TANK; SPECIFICATIONS AND DIMENSIONS
  • Page 4 – General Safety Precautions; DA N G E R
  • Page 5 – Feel water before bathing or showering.; TIME/TEMPERATURE RELATIONSHIPS IN SCALDS
  • Page 6 – INSTALLATION PROCEDURES; The heater should be located in an area where
  • Page 7 – VENTING CONNECTIONS
  • Page 8 – ANSI; or applicable provisions of the local building; COMMON VENTS
  • Page 9 – GAS SUPPLY CONNECTIONS; The heater and its manual shut off valve must; GAS PRESSURE-SPECIFICATIONS; Sediment Trap Gas Valve
  • Page 10 – downstream which is the same as the manifold pressure.; WATER CONNECTIONS & SYSTEM PIPING
  • Page 11 – ELECTRICAL WIRING; the heater, and a disconnecting means within sight of the heater.; WIRING DIAGRAM KEY; f it is necessary to replace any of the original
  • Page 12 – See page 11 wiring diagram key information.; WIRING DIAGRAM: STANDING PILOT; SHOCK HAZARD
  • Page 13 – SERVICING PROCEDURES; GENERAL LOCATION OF CONTROLS; CONTROL BOX COMPONENT LOCATIONS; SEQUENCE OF OPERATION; Circulator
  • Page 14 – Filling the System; Fill system with water. Purge all air from the system; SECTION 2; Before lighting the heater and after system is filled,
  • Page 15 – BEFORE LIGHTING; If you do not follow these instructions ex-; BEFORE OPERATING
  • Page 16 – HONEYWELL; GAS INLET; HONEYWELL PILOT; Should overheating occur or the gas supply
  • Page 17 – FOR AUTOMATIC IGNITION SYSTEMS
  • Page 18 – In extreme cases it may be necessary to remove
  • Page 20 – TROUBLE SHOOTING GUIDE; IMPORTANT NOTICE
  • Page 22 – HONEYWELL PILOT ROBERTSHAW PILOT; PILOT; Label all wires prior to disconnection when; DANGER - SHOCK HAZARD; Make sure pilot orifice is clear, but do not; CAUTION; To avoid damage to electrical components
  • Page 23 – REPLACEMENT PARTS LIST; To supply the correct part it is important that you
  • Page 27 – LIMITED PARTS WARRANTY ECONOPAK WATER HEATERS
  • Page 28 – Raypak Canada LTD
Loading the manual

CATALOG NO. 3000.50D
Effective: 01-01-03
Replaces: 03- 01-97

P/N 240687

INSTALLATION
AND OPERATING
INSTRUCTIONS

Models 090A, 135A, 195A
Type WH

This manual should be maintained in legible
condition and kept adjacent to the heater or kept
in a safe place for future reference.

ECONOPAK WATER
HEATERS

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids or other combustible
materials in the vicinity of this or any other appliance. To do so may result in an explosion or
fire.

WARNING:

Improper installation, adjustment, alteration, service or maintenance can cause

property damage, personal injury or loss of life. Refer to this manual. Installation and service must
be performed by a qualified installer, service agency or the gas supplier.

FOR YOUR SAFETY

WHAT TO DO IF YOU SMELL GAS
*Do not try to light any appliance.
*Do not touch any electrical switch; do not use any phone in your building.
*Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's
instructions.
*If you cannot reach your gas supplier, call the fire department.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Contents

These instructions are provided to assure the properinstallation and operation of Raypak water heaters.Should questions arise regarding the specifications,installation, operation or servicing of these water heat-ers, we suggest that the local Sales representative orthe factory be consulted. 2 3 1. R...

Page 3 - TANK; SPECIFICATIONS AND DIMENSIONS

3 1. RECEIVING EQUIPMENT On receipt of your equipment it is suggested that you visually check for external damage to the carton. If thecarton is damaged, it is suggested that a note be madeon the Bill of Lading when signing for equipment. Removethe heater from the carton and if it is damaged report ...

Page 4 - General Safety Precautions; DA N G E R

4 Be sure to read and understand the entire Instruction Manual before attempting to install or operate this water heater. Payparticular attention to the following general Safety Precautions. Failure to follow these warnings could result in a fire orexplosion, causing property damage, bodily injury o...

Other Raypak Models

All Raypak Other