Raypak 105B - Manual
Raypak 105B – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Contents; PART ONE - Owner's Operating Instructions
- Page 3 – PART ONE - OWNER'S OPERATING INSTRUCTIONS; BURNERS; Clean main burners and air louvers of dust, lint and; WATER; First thing, insure that system is filled with water and; FOR YOUR SAFETY - READ BEFORE OPERATING; WARNING: IF YOU DO NOT FOLLOW THESE
- Page 4 – LIGHTING INSTRUCTIONS; LIGHTING INSTRUCTIONS AND SHUT-OFF PROCEDURES
- Page 6 – WATER PRESSURE SWITCH
- Page 7 – COLD WEATHER OPERATION; WINTERIZING THE SPA HEATER; DRAIN COCK
- Page 8 – PART 2 - INSTALLATION / SERVICE INSTRUCTIONS; IMPORTANT NOTICE; CODE REQUIREMENTS
- Page 9 – CLEARANCES; ALL HEATERS; For clearances from combustible surfaces, see; OUTDOOR HEATERS; The heater shall not be located in an area
- Page 10 – INDOOR HEATERS; COMBUSTION AIR; STACK ADAPTER
- Page 11 – VENTING CONNECTIONS
- Page 12 – VENT PIPING; Indoor boilers require a draft hood that must; Vent piping the same size or larger than the draft
- Page 13 – GAS SUPPLY CONNECTIONS; PIPE SIZING FOR GAS CONNECTIONS
- Page 14 – PLUMBING FOR WATER CONNECTIONS; Never install PVC directly in header flanges.
- Page 15 – ELECTRICAL WIRING; MILLIVOLT SYSTEM
- Page 19 – SECTION 4 / SERVICING INSTRUCTIONS; GENERAL LOCATION OF CONTROLS; TEMPERATURE CONTROLS; The water temperature is controlled by the heater; PRESSURE SWITCH; The pressure switch, or heater actuator, insures
- Page 20 – TWO SPEED PUMPS; HIGH LIMITS; PILOT SAFETY (IID Units) ELECTRIC IGNITION
- Page 23 – SECTION 5 / TROUBLE SHOOTING GUIDE; IMPORTANT NOTICE
- Page 25 – WARNING; HIGH VOLTAGE; Intermittent Pilot System; TROUBLESHOOTING HONEYWELL S8600; START
- Page 26 – SECTION 6/REPLACEMENT PARTS LIST; To supply the correct part it is important that you
CATALOG NO. 6100.60A
Effective: 10-1-99
Replaces: 6-15-99
Fig. # 9258
Part No. 240776
OPERATING AND
INSTALLATION
INSTRUCTIONS
Model
105B Cast Iron
VERSA
ABOVE GROUND POOL
and
SPA HEATER
WARNING:
If the information in these instructions are not followed exactly, a fire or explosion
may result causing property damage, personal injury or death. Installation and service must
be performed by a qualified installer, service agency or the gas supplier.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use any phone in your building.
•
Immediately call your gas supplier from a neighbor's phone. Follow the gas
supplier's instructions.
•
If you cannot reach your gas supplier, call the fire department.
This manual should be maintained in legible condition and kept adjacent to
the heater or kept in a safe place for future reference.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Contents 2 PART ONE - Owner's Operating Instructions 2 SECTION 1 / START-UP PROCEDURES 2 Before Start-Up 3 Lighting Instructions & Shut-Off Procedures(manually lighted pilot MV) 4 Operating Instructions & Shut-Off Procedures(automatically lighted pilot IID) 5 After Start-Up 5 SECTION 2 / CAU...
PART ONE - OWNER'S OPERATING INSTRUCTIONS BEFORE START-UP BURNERS Clean main burners and air louvers of dust, lint and debris. Keep heater area clear and free from com-bustibles, flammable liquids and chemicals. Do notobstruct the flow of combustion and ventilating air. 2 WATER First thing, insure t...
1. STOP! Read the safety information above.2. Set the thermostat on the lowest setting.3. Turn On/Off switch to the "Off" position.4. Remove heater door panel.5. Push in gas control knob slightly and turn clock- wise to "Off". NOTE: Knob cannot be turned from "Pilot" to "...
