Page 2 - Raymarine is a registered trademark of Raymarine Limited.
Raymarine is a registered trademark of Raymarine Limited.
Page 3 - M1500 Marine Monitor Preface; Important information; Intended Use; Safety notices; WARNING:Product installation; The operator should never remove the display; WARNING: Navigation aid; Call a qualified service engineer if any of the following occur:
i M1500 Marine Monitor Preface This handbook contains very important information on the installation and operation of your new equipment. In order to obtain the best results in operation and performance, please read this handbook thoroughly. Raymarine’s Technical Services representatives or your loc...
Page 4 - TFT Color LCD Displays; For the latest product information visit our website:; Warranty
ii M1500 Marine Monitor i. The power cable or signal cable is damaged or worn. ii. Liquid has penetrated the monitor. iii. The monitor is not working correctly despite the fact that it has been used follow- ing the instructions provided. iv. The monitor has been dropped or the casing has been damage...
Page 5 - iii; For Accessories and Parts; Or visit the Raymarine World Wide Web site:
iii Alternatively, if you don’t have access to the world wide web, contact technical support as detailed below. Our Technical Support Specialists are available to answer questions about installing, operating and trouble-shooting all Raymarine products. How to Contact Raymarine (US) For Accessories a...
Page 6 - iv
Page 7 - Contents
v Contents M1500 Marine Monitor Preface ..................................................................................... .i Important information .........................................................................................i Intended Use ................................................
Page 9 - Overview; The display has the following switchable input connectors:; Recommendations for your PC; 024 x 768 at 60Hz is the preferred resolution and refresh rate.; Input; Resolution
1 M1500 Marine Monitor 1 Overview The M1500 Marine Monitor is a waterproof, ruggedized, sunlight viewable display. It has been designed to satisfy the requirements of the recreational marine market for installation either above or below decks. The display has the following switchable input connector...
Page 10 - Features; Power Saving; Power can be reapplied to the monitor by switching it on with; Active Thermal Management; Display Location and Mounting Options
2 M1500 Marine Monitor 2 Features CAUTION: To prevent the ships battery being discharged if the system is left on, Raymarine do not recommend the use of screen savers with navigation displays. Do not use the power save feature of your PC. Power Saving This monitor powers off completely if no video s...
Page 11 - Front of Monitor
3 Front of Monitor Stereo speakers Display screen Power ON LED Power/OSD select button On Screen Display(OSD) control buttons Stereo speakers For audio output from your PC or audio/video source. Alternatively, a separate sound system may be connected directly to your source device. Display screen Hi...
Page 12 - Rear of Monitor
4 M1500 Marine Monitor Rear of Monitor Power in Power input connection from the ship's supply (nominal 12V or 24V system). DVI input Digital Video Input from a Personal Computer (PC). VGA input Analogue Video Input from a Personal Computer (PC). Audio input, composite video or S-video input Audio in...
Page 13 - Operation; Close
5 3 Operation Brightness 43 -- + Volume 29 -- + Video source Analogue (RGB)DV1Composite-S Set up Image adjustAuto setupLanguageAbout RNS1500Close Set up Image adjustAuto setupLanguageAbout RNS1500Close Power off 2 Press Press Press (do not hold) + To adjust/select Selectingthe mode What you see To f...
Page 15 - Installation; Pack Items
7 4 Installation Unpack your display carefully to prevent damage. Save the carton and packing in case you need to return the unit for service. Pack Items 15" LCD Panel template Drill mounting hole4.1 mm diameter(4 positions) Remove shaded areas only 302.2 mm (11.9 in) 391.6 mm (15.4 in) center l...
Page 16 - Planning; Power requirements; Power Requirements; Grounding the display; Vessels Supply
8 M1500 Marine Monitor Planning Before you install your display, plan the installation considering: • Power requirements • Cable runs • Display location and mounting options. • Optional Audio/Video Junction Box location • Additional ancillary parts e.g. keyboard or extra speakers. Power Requirements...
Page 17 - Extending the Power Cable; Cable Runs; Connections - Typical
9 Extending the Power Cable Longer power cable runs may require larger wire gauges to minimize any voltage drop in the cable. Ensure that the minimum voltage specification of the display is met at the junction of these cables when the display is operating at full brightness. If a longer power cable ...
Page 18 - Viewing angle; : This LCD has been chosen to give the very best performance,; To prevent overheating, do not restrict airflow at the rear; EMC Installation Guidelines; For; optimum; EMC performance, it is recommended that; wherever possible; Raymarine equipment and cables connected to it are:
10 M1500 Marine Monitor • Viewing angle : This LCD has been chosen to give the very best performance, including viewing angle. However, the contrast and colors seen on all LCD displays vary slightly with viewing angle. • Access: There must be sufficient space behind the display to allow cable con- n...
Page 19 - Console Mounting - Display Dimensions
11 • The equipment is supplied from a separate battery from that used for engine start. Volt-age drops below 10 V, and starter motor transients, can cause the equipment to reset. This will not damage the equipment, but may cause the loss of some information and may change the operating mode. • Rayma...
Page 20 - Console Mounting - Preparation
12 M1500 Marine Monitor Console Mounting - Preparation 15" LCD P anel template Drill mounting hole4.1 mm diameter(4 positions) Remove shaded areas only 302.2 mm (11.9 in) 391.6 mm (15.4 in) center line Instrument edge Sun cover edge Cut aperture in surface D6313-1 3 Tape template in required pos...
Page 21 - Console Mounting; To mount the console:; Remove the backing paper from the installation gasket.
13 Console Mounting To mount the console: 1. Remove the backing paper from the installation gasket. 2. Attach the installation gasket to the back of the display plate. 3. Place display into the aperture, push 4 x M4 screws through holes. 4. Assemble 2 off, side plates onto M4 screws and secure using...
Page 22 - Connections - Typical Installations
14 M1500 Marine Monitor Connections - Typical Installations Power INfrom ship'ssupply Connections tojunction box via ScartORphono and/or S-video. Details provided withjunction box. Audio, composite video or S-video input using Optional Audio/Video Junction Box DVI Input DVIInput VGA Input Audio OR ....
Page 23 - Connections - Accessing the Connector Panel
15 Connections - Accessing the Connector Panel Rotate clockwise to secure seal and cover Push latch to release and close cover Cable seal Cable clamp kit D6367-1
Page 24 - Maintenance and Problem Solving; The display unit contains; high voltage; . Adjustments require specialized; The operator should not remove the; Switch off the display unit before removing the power cord.; Routine Checks; Check that the cable connectors are firmly attached.; Cleaning the Display; EMC Servicing and Safety Guidelines
16 M1500 Marine Monitor 5 Maintenance and Problem Solving WARNING: The display unit contains high voltage . Adjustments require specialized service procedures and tools only available to qualified service technicians - there are no user serviceable parts or adjustments and the operator should not at...
Page 25 - Problem Solving; Common Problems and Their Solutions; Problem
17 Problem Solving All Raymarine products are, prior to packing and shipping, subjected to comprehensive test and quality assurance programs. However, if this unit should develop a fault, please refer to the following table to identify the most likely cause and the corrective action required to rest...
Page 26 - Audio/video Junction Box; Power Connections
18 M1500 Marine Monitor 6 Specification 7 Accessories Audio/video Junction Box E85003 Black Dress Panel Kit E05009 Trunnion Mount Bracket Kit E05011 Approvals:CE - conform toFCC - conforms to 1999/5/EC, EN60945:1997Part 80 (47CFR) and Part 2 (47CFR) Size: 416.4 mm x 334.2 mm x 141.0 mm(16.4 in x 13....
Page 27 - Warranty Certificate; Limited Warranty; Installed Warranty; Obtaining Warranty Service; Limited Warranty; Warranty Limitations
Warranty Certificate The Raymarine warranty terms and conditions as described below do not affect the customer’s statutory rights. Limited Warranty Raymarine warrants each new Light Marine Product to be of good materials and workmanship. Raymarine, or it’s approved agents, will repair or exchange un...
Page 29 - Factory Service Centers; United States of America
Factory Service Centers United States of America UK, Europe, Middle East, Far East Raymarine Inc.22 Cotton Road, Unit DNashua, NH 03063-4219, USA Raymarine Ltd.Anchorage Park, PortsmouthPO3 5TD, England Telephone: +1 603 881 5200Fax: +1 603 864 4756www.raymarine.com Telephone: +44 (0)23 9269 3611Fax...
