ProCom 200059 - User Manual

ProCom 200059

ProCom 200059 Heater – User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
Page: / 60

Table of Contents:

  • Page 2 – SPECIFICATIONS; Model; TABLE OF CONTENTS; Specifications
  • Page 3 – SAFETY; Standard for Storage and Handling; Check with your local; soning resemble the flu, with headaches, diz
  • Page 5 – INSTALLATION; Figure 2 - Cross Section Operational View; THEORY OF OPERATION; The Automatic Control System:; causes the heater to shut down if the flame; PROPANE SUPPLY; Standard for Storage and Handling of; Average Temp
  • Page 6 – Figure 3 - Regulator Position; SUPPORT BRACKET
  • Page 7 – Figure 7 - Automatic Control Valve; TO START HEATER; Extension Cord Wire Size Requirements
  • Page 8 – MAINTENANCE; place with hose specified by manufacturer.; STORAGE; seat at the bullnose of the POL fitting. If; OPERATION; TO STOP HEATER; Wait five minutes after stopping heater.
  • Page 9 – SERVICE PROCEDURES; ELECTRICAL SYSTEM; tor. Make sure set screw contacts flat; FAN; set screw contacts flat surface on motor
  • Page 10 – WARNING: Make sure heater; Motor
  • Page 11 – Problem; serviced by qualified service
  • Page 12 – PARTS
  • Page 13 – Replacement Parts; Item; Main Orifice Valve; PARTS AVAILABLE - NOT SHOWN
  • Page 16 – WIRING DIAGRAM
  • Page 17 – REPLACEMENT PARTS; replaced under warranty.; PARTS NOT UNDER WARRANTY; ACCESSORIES; You can also visit ProCom Heating, Inc.’s web site at
  • Page 18 – NOTES
  • Page 20 – REGISTER YOUR PRODUCT AT WWW.USAPROCOM.COM; New Products – Outdoor Heating; Factory Reconditioned Products; WARRANTY; KEEP THIS WARRANTY; located on product or identification tag
  • Page 21 – CALENTADOR DE AIRE
  • Page 22 – TABLA DE CONTENIDOS; ESPECIFICACIONES; Modelo
  • Page 23 – Norma de; SEGURIDAD; CONSULTE A LA AUTORIDAD LOCAL
  • Page 25 – El sistema de combustible:; Figura 2 - Vista transversal de funcionamiento
  • Page 26 – SUMINISTRO DE PROPANO; Norma; Temperatura promedio en No. de tanques; INSTALACIÓN; Suministro de propano
  • Page 27 – VENTILACIÓN; Nota: Si no se abre lentamente, la válvula; PATAS DE LA BASE; Figura 4 - Manguera y conector de entrada; Figura 5 - Conexión de Patas de la Base; SOPORTE DE APOYO; Figura 6 - Ajuste del Calentador Altura; ADVERTENCIA: Procure tener al menos una abertura de aire fres-
  • Page 28 – PARA ENCENDER EL; Requisitos de medida del cable de; la válvula de exceso de flujo del tanque
  • Page 29 – el flujo de combustible. Pasarán; PARA APAGAR EL; ALMACENAMIENTO
  • Page 30 – Procedimientos de; PROCEDIMIENTOS DE SERVICIO; SISTEMA ELÉCTRICO; motor y el resguardo del ventilador del
  • Page 31 – VENTILADOR
  • Page 32 – ENCENDIDO; ADVERTENCIA: Asegúrese
  • Page 33 – Problema
  • Page 34 – PIEZAS
  • Page 35 – Piezas de repuesto; Descripción
  • Page 36 – MODELO PCFA60V
  • Page 38 – DIAGRAMA DE CABLEADO
  • Page 39 – PIEZAS DE REPUESTO; partes remplazadas bajo la garantía.; PIEZAS CON GARANTÍA; SERVICIO TÉCNICO
  • Page 40 – REGISTRE SU PRODUCTO EN WWW.USAPROCOM.COM; GARANTÍA; MANTENGA ESTA GARANTÍA; Modelo (ubicado en la etiqueta del producto o de identificación)
  • Page 41 – CHAUFFAGE
  • Page 42 – TABLE DES MATIÈRES; Modèles
  • Page 43 – SÉCURITÉ; Norme pour l’emmagasinage et
  • Page 45 – Figure 1 - Modèle à 30 000 BTU/H illustré; Système de contrôle automatique :; Ce; Figure 2 - Vue opérationnelle en coupe transversale
  • Page 46 – APPROVISIONNEMENT EN PROPANE; Norme pour l'emmagasinage; ambiante; flamme nue pour rechercher une; sionnement en propane; Figure 3 - Position du détendeur
  • Page 47 – Figure 5 - Fixation de base Pieds; coupera le gaz. Vous pouvez entendre un; PIEDS DE LA BASE (PCFA40
  • Page 48 – FONCTIONNEMENT; POUR ALLUMER L'APPAREIL; Exigences des dimensions de la ral-; le gaz. Vous pouvez entendre un clic; AVERTISSEMENT : Vérifiez; Figure 7 - Automatic bouton de la valve
  • Page 49 – Remarque : si l'appareil de chauffage ne; le flux de combustible. Le limiteur; POUR ARRÊTER L'APPAREIL DE; Pour; ENTREPOSAGE; Norme pour l'emmagasinage et la
  • Page 50 – Procédures d'entretien; PROCÉDURES D'ENTRETIEN; CIRCUIT ÉLECTRIQUE; grille de protection du moteur et du
  • Page 51 – Figure 10 - Emplacement de la vis d'arrêt; Figure 11 - Retrait ou installation de la; VENTILATEUR
  • Page 52 – chauffage est débranché de la; Moteur; Figure 13 - Retrait de l'allumeur et de la
  • Page 53 – DÉPANNAGE; PROBLÈME OBSERVÉ; AVERTISSEMENT : Ne réparez jamais l'appareil de chauffage
  • Page 54 – Ventilateur; Remarque : Utilisez uniquement des pièces; PIÈCES SOUS GARANTIE; PIÈCES DE RECHANGE
  • Page 55 – SCHÉMA DE CÂBLAGE
  • Page 56 – PIÈCES
  • Page 57 – Pièces de rechange; DESCRIPTION
  • Page 58 – MODÈLE PCFA60V
  • Page 59 – Tube; PIÈCES DISPONIBLES - PAS ILLUSTRÉES
  • Page 60 – ENREGISTREZ VOTRE PRODUIT À WWW.USAPROCOM.COM; Nouveaux Produits - Chauffage Extérieur; Produits Reconditionnés en Usine; Conditions Communes à Tous les Garanties; GARANTIE; GARDEZ CETTE GARANTIE; Modèle (situé sur l’étiquette du produit ou de l’identification)
Loading the manual

PROPANE CONSTRUCTION FORCED AIR HEATER

OWNER’S MANUAL

PCFA40 - 40,000 BTU/HR HEATER

PCFA60V - 60,000 BTU/HR HEATER

IMPORTANT: Read and understand this manual before

assembling, starting or servicing heater. Improper use

of heater can cause serious injury. Keep this manual for

future reference.

GENERAL HAZARD WARNING:

Failure to comply with the precautions and instructions

provided with this heater, can result in death, serious

bodily injury and property loss or damage from hazards

of fire, explosion, burn, asphyxiation, carbon monoxide

poisoning and/or electrical shock.

Only persons who can understand and follow the in-

structions should use or service this heater.

If you need assistance or heater information such as an

instructions manual, labels, etc. contact the manufacturer.

Questions, problems, missing parts?

Before returning to your retailer, call

our customer service department at 1-866-573-0674, 7:30 am - 4:15 pm CST,

Monday through Friday or email

[email protected]

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - SPECIFICATIONS; Model; TABLE OF CONTENTS; Specifications

www.usaprocom.com 160448-01C 2 SPECIFICATIONS Model PCFA40 PCFA60V Output Rating 40,000 BTU/Hr 60,000 BTU/Hr Fuel Consumption/Hour 0.44 gal (1.65 liter), 1.86 lb (0.84 kg) 0.66 gal (2.48 liter), 2.78 lb (1.26 kg) Manifold Pressure 9.7 PSI 19.8 PSI Ignition Manual Piezo Electric Spark Fuel Propane Va...

Page 3 - SAFETY; Standard for Storage and Handling; Check with your local; soning resemble the flu, with headaches, diz

www.usaprocom.com 3 160448-01C SAFETY ziness and/or nausea. If you have these signs, the heater may not be working properly. Get fresh air at once! Check for proper ventilation and have heater serviced. Propane Gas: Propane gas is odorless. An odor-making agent is added to propane gas. The odor help...

Page 5 - INSTALLATION; Figure 2 - Cross Section Operational View; THEORY OF OPERATION; The Automatic Control System:; causes the heater to shut down if the flame; PROPANE SUPPLY; Standard for Storage and Handling of; Average Temp

www.usaprocom.com 5 160448-01C INSTALLATION Figure 2 - Cross Section Operational View Air For Combustion Air For Heating Clean Heated Air Out (Front) Fan Motor Cool Air In (Back) Combustion Chamber Hose/Regulator Assembly THEORY OF OPERATION The Fuel System: The hose/regulator as- sembly attaches to...