Premier Mounts SCM-103 - Manual

Page 2 - Warning Statements

Page 2 Installation Instructions Table of Contents Warning Statements Warning Statements 2 Parts List 3 Installation Tools 3 Locating the Mounting Points 4 Mounting the Brackets to the Display 5 Securing the Lower Cover 6 Securing the Tubes to the Mounting Brackets 6 Lifting the Display into Positio...

Page 3 - Parts List

Installation Instructions Page 3 Parts List This ceiling mount is shipped with all proper installation hardware and components. Make sure that none of these parts are missing and/or damaged before beginning installation. If there are missing and/or damaged parts, please stop the installation and con...

Page 4 - Locate the Mounting Points; Mounting

Page 4 Installation Instructions Locate the Mounting Points The display comes with four (4) M16 screws with quick release sleeves that are pre-installed on the display. Mounting Points MountingPoints Step 1. Locate the 4 quick release sleeves on the back of the display and remove. Place the M16 bolt...

Page 5 - Mounting the Brackets to the Display; each side of the display.

Installation Instructions Page 5 Mounting the Brackets to the Display Step 1. Align the mounting bracket holes up with the mounting holes on the back of the display. There are two mounting holes used on each side of the display. Step 2. Place the split washer between the display and the mounting bra...

Page 6 - Insert the lower cover between the vertical mounting brackets.; Securing the Lower Cover; Lower Cover

Page 6 Installation Instructions Step 1. Insert the lower cover between the vertical mounting brackets. Step 2. Attach four (4) 10-32 Kep Nuts and tighten down securing the lower cover into place. Step 3. Insert two (2) 8-32 x ½” screws and tighten down the lower cover bracket against the vertical s...

Page 7 - Cotter Pin

Installation Instructions Page 7 THE SCM-103 IS HEAVY. IT IS STRONGLY RECOMMENDED THAT THREE PEOPLE PERFORM ALL INSTALLATION STEPS. Now that the mount is attached to the display, double check all mounting locations to insure all hardware is properly tightened and secured. Step 5. Once the tubes are ...

Page 8 - Lifting the Display into Position; Scissor Lift

Page 8 Installation Instructions THE SCM-103 IS HEAVY. IT IS STRONGLY RECOMMENDED THAT THREE PEOPLE PERFORM ALL INSTALLATION STEPS. Lifting the Display into Position Step 1. Raise the display to the desired height (Refer to the display manufacturer specs on raising the display into position and the ...

Page 9 - Cable Routing; Locate the plastic insert plugs and slip around cable

Installation Instructions Page 9 Cable Routing Pre-Hung Cable 2 Hole Locations for Cable Routing Two holes are provided at the top of each mounting bracket. Cables can be routed so both are going through one hole or routed so each cable runs through its own hole. The system is designed to allow for ...

Page 10 - Installation Instructions; Cable Routing Holes

Page 10 Installation Instructions THE SCM-103 IS HEAVY. IT IS STRONGLY RECOMMENDED THAT THREE PEOPLE PERFORM ALL INSTALLATION STEPS. Step 5. Route the cable down through the provided holes on the display mounting bracket. 6-32 x 1/4”Set Screw Step 3. Slide plastic insert plug down cabling and insert...

Page 11 - Measure 1 3⁄4” inches up the threaded stud attached to

Installation Instructions Page 11 THE SCM-103 IS HEAVY. IT IS STRONGLY RECOMMENDED THAT THREE PEOPLE PERFORM ALL INSTALLATION STEPS. Step 6. Locate the ½”-20 Nuts & ½” flat washer. Step 7. Measure 1 ¾” inches up the threaded stud attached to the cable and thread one ½-20 nut into position. Level...

Page 12 - Install the panel by sliding it into position behind the tubes.; Installing the Beauty Covers; Slide the mounting bracket covers into position.

Page 12 Installation Instructions Step 1. After all cables have been routed through mount and are properly installed, locate the display input cover panel. Step 2. Install the panel by sliding it into position behind the tubes. Step 3. Lock the cover into position by tightening the six (6) 8-3 x 3/8...

Page 14 - Technical Specifications

Page 14 Installation Instructions Technical Specifications All measurements are in inches(mm). SCM-103

Page 15 - Installation

Warranty PREMIER MOUNTS LIMITED LIFETIME WARRANTY What and Who is Covered by this Limited Warranty and for How Long Premier Mounts warrants this product to be free from defects in material and workmanship for the lifetime of the original owner of this product. The limited warranty is valid only for ...

Premier Mounts SCM-103 - Manual

Table of Contents:

Summary

Other Premier Mounts Models