Polaris PC 199-50 3NV - Manual

Polaris PC 199-50 3NV

Polaris PC 199-50 3NV – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
Page: / 64

Table of Contents:

  • Page 2 – Vent; Table of Contents
  • Page 3 – INSTALLATION INSTRUCTIONS; Consumer Information; Unpacking the Water Heater; Removing Packaging Materials; Excessive Weight Hazard
  • Page 4 – Location Requirements; Figure 1: Garage Installation; Do not store or use gasoline or other; FIRE AND EXPLOSION HAZARD; Can result in serious injury or death; Site Location; Figure 1A
  • Page 5 – CONDENSATE LINE; Condensate Trap Assembly; Figure 2: Minimum Clearance Locations; Clearances and Accessibility; Figure 3A: 2” Condensation Trap Installation
  • Page 6 – Condensate Drain Line; VENT PIPE SYSTEM; Figure 3B: Condensate Drain
  • Page 7 – Note: The heater must never be operated without the; Figure 4B: Adaptor Rubber Boot; Figure 4C: Air Inlet Piping
  • Page 8 – Vent Pipe Material; Combustion Air Inlet Piping; Vent Pipe Installation; Figure 5: Correct and Incorrect Pipe Fittings
  • Page 9 – Vent Termination Locations; Use only 2 inch pipe or a 2 inch concentric vent; Figure 6: Minimum Clearances for Inlet/Outlet and Concentric Vent; US Installations
  • Page 10 – INLET/OUTLET VENT TERMINATIONS; Standard Horizontal Termination; Figure 7: Standard Horizontal Termination; Figure 8: Alternate Horizontal Termination
  • Page 11 – VERTICAL TERMINATIONS; Venting Additional Polaris; Figure 9: Vertical Termination
  • Page 12 – CONCENTRIC VENT TERMINATIONS; Figure 10: 2 Inch Concentric Vent; Figure 13: Through the Wall Termination
  • Page 13 – Figure 14: Input Graph; Gas Input Rate; WATER PIPING SYSTEM; Piping Installation
  • Page 14 – Figure 15: Typical One-Temperature System Piping Installation; Mixing Valve Installation; The manufacturer of this water; Combination Space Heating/Potable; Figure 16: Sample Mixing
  • Page 15 – Figure 17: Air Handler Piping Installation
  • Page 16 – with Auxillary Storage Tank - One or Two
  • Page 17 – GAS SUPPLY AND PIPING; Gas Requirements; Read the data plate to be sure the water heater is made; Gas Piping; Figure 19: Gas Piping Installation; Gas Pressure; Important; Explosion Hazard
  • Page 18 – Gas Pressure Testing
  • Page 19 – ELECTRICAL CONNECTIONS; Figure 20: Electrical Connections
  • Page 20 – WIRING DIAGRAM; HEATER SUPPLIED WITH T92 SERIES RELAY
  • Page 22 – OPERATING YOUR WATER HEATER; Water Heater Operation; Green; control is signaling the gas valve to open.; Figure 21: Sequence of Operation; Thermostat Sensor
  • Page 23 – Temperature Dial; Stacking; Emergency Shut Down
  • Page 24 – Water Heater Sounds; Draining and Flushing; refill; Temperature and Pressure; Figure 23: Drain Valve Access
  • Page 26 – TROUBLESHOOTING
  • Page 27 – SOFTWARE OPERATION SEQUENCE; IGNITION CONTROL MODULE SOFTWARE OPERATION SEQUENCE
  • Page 28 – REPAIR PARTS LIST/DIAGRAM; TOOLS REQUIRED FOR SERVICING; When ordering repair parts always give the; Repair Parts List
  • Page 29 – POLARIS MODELS & DIMENSIONS
  • Page 30 – NOTES
  • Page 32 – call our Technical Support line at:; Fergus, ON Canada N1M 2X1; Polaris; Commercial Gas Water Heater
  • Page 33 – veuillez nous envoyer un courriel à :; Appeler notre ligne de soutien technique en composant; Chauffe-eau au gaz commercial
  • Page 34 – REMARQUES
  • Page 36 – MODÈLES ET DIMENSIONS POLARIS
  • Page 37 – LISTE/DIAGRAMME DES PIÈCES DE RECHANGE; OUTILS REQUIS POUR L’ENTRETIEN; Liste des pièces de
  • Page 38 – SÉQUENCE DE FONCTIONNEMENT DU LOGICIEL
  • Page 39 – DÉP ANNAGE
  • Page 41 – Arrêt de sécurité (Commutateur de; Vidange et rinçage; Soupape de décharge à sécurité; Figure 23 : Accès au robinet de vidange
  • Page 42 – T able 4; Arrêt d’urgence; Figure 22 : Cadran de; Empilable; A VERTISSEMENT
  • Page 43 – FONCTIONNEMENT DU CHAUFFE-EAU; Fonctionnement du chauffe-eau; Figure 21 : Séquence de fonctionnement; Capteur de thermostat; T empérature
  • Page 45 – SCHÉMA DE CÂBLAGE; VEC UN RELAIS DES SÉRIES T92; VEC UN RELAIS DES SÉRIES KUHP
  • Page 46 – CONNEXIONS ÉLECTRIQUES; Figure 20 : Connexions électriques
  • Page 47 – Essai de pression du gaz
  • Page 48 – Exigences relatives au gaz; Conduite de gaz; Figure 19 : Installation de la tuyauterie de gaz; Pression du gaz
  • Page 49 – avec réservoir de stockage auxiliaire - Système à; Notes sur la Figure 18 :
  • Page 52 – Figure 14 : Graphique de production; T aux de production de gaz; RÉSEAU DE CONDUITE D’EAU; Installation de la tuyauterie
  • Page 53 – TERMINAISONS DE VENTILA TION CONCENTRIQUES; Figure 10 : Ventilation concentrique de 2 po; Chauffes-eau multiples à ventilation
  • Page 54 – TERMINAISONS VERTICALES; Ventilation d’unités additionnelles; Figure 9 : T erminaison verticale
  • Page 55 – TERMINAISONS DE VENTILA TION D’ENTRÉE/SORTIE; T erminaison horizontale standard; Figure 7 : T erminaison horizontale standard; Figure 8 : T erminaison horizontale alternative
  • Page 56 – Installations pour les États-Unis
  • Page 57 – Matériau du tuyau de ventilation; Figure 5 : Raccords de tuyau corrects et incorrects; Installation du tuyau de
  • Page 58 – Figure 4B : Gaine en caoutchouc de l’adaptateur
  • Page 59 – Conduit de vidange de condensat; RÉSEAU DE TUY AUX DE; Ventilation; Figure 3B : Vidange de condensat
  • Page 60 – TUY AU DE CONDENSA; Ensemble du purgeur d’eau de; Figure 2 : Emplacements de dégagement minimum; VUE DE; Dégagements et accessibilité; Figure 3A : Installation du purgeur d’eau
  • Page 61 – Figure 1 : Installation dans le garage; Choix de l’emplacement; Peut entraîner des blessures graves ou la mort
  • Page 62 – Renseignements destinés à l’acheteur; Déballage du chauffe-eau; Retrait des matériaux d’emballage
  • Page 63 – Consignes importantes; T able des matières
  • Page 64 – Instructions; QUE FAIRE SI VOUS SENTEZ UNE ODEUR; A VERTISSEMENT : Si les informations contenues
Loading the manual

1

Polaris

®

Commercial Gas

Water Heater

Installation

Instructions and

Use & Care Guide

To obtain technical, warranty or service assistance during or
after the installation of this water heater, visit our website at:

http://www.gsw-wh.com

or call toll free:

1-888-479-8324

When calling for assistance, please have the following

information ready:
1. Model

number

2. 7 Digit product number

3. Serial

number

4. Date of installation

5. Place of Purchase

Table of Contents........................................................... 2

Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;

do not use any telephone in your

building.

• Immediately call your gas supplier

from a neighbor’s telephone. Follow

the gas supplier’s instructions.

• If you cannot reach your gas

supplier, call the fire department.

Installation and service must be performed
by a qualified installer, service agency or
the gas supplier.

WARNING: If the information in these

instructions is not followed exactly, a fire

or explosion may result causing property

damage, personal injury or death.

322761-000

INSTALLER:

•

Affix these instructions to or adjacent to the water
heater.

OWNER:

•

Retain these instructions and warranty for future
reference. Retain the original receipt as proof of
purchase.

PRINTED IN U.S.A. 0112

This manual covers model numbers:

Canada
PC 100-34 2NV or 2PV

PC 130-34 2NV or 2PV

PC 130-50 2NV or 2PV

PC 150-34 2NV or 2PV

PC 150-50 2NV or 2PV

PC 175-50 3NV or 3PV

PC 199-50 3NV or 3PV

Note:

The manufacturer of this water heater recommends that it

be professionally installed by trained and qualified service

professionals.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Vent; Table of Contents

2 Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol.This symbol alerts you to potential hazards that can kill or hurt you and others....

Page 3 - INSTALLATION INSTRUCTIONS; Consumer Information; Unpacking the Water Heater; Removing Packaging Materials; Excessive Weight Hazard

3 INSTALLATION INSTRUCTIONS Consumer Information OBSERVE ALL GOVERNING CODES AND ORDINANCES. This water heater is design-certified by CSA International as a Category IV, direct vented water heater which takes its combustion air from the outside of the structure and exhausts all products of combustio...

Page 4 - Location Requirements; Figure 1: Garage Installation; Do not store or use gasoline or other; FIRE AND EXPLOSION HAZARD; Can result in serious injury or death; Site Location; Figure 1A

4 Location Requirements The water heater design has been tested by CSA International and complies with ANSI Z21.10.1, Section 2.35 Flammable Vapors Resistance. In garage installation avoid damage to your water heater by installing a vehicle stop as shown in figure below. Check state and local/ provi...

Other Polaris Models