Polaris CREW 800 EFI - Manual

5 INTRODUCTION Failure to follow the warnings contained in this manual can result in severe injury or death. Your POLARIS RANGER is not a toy and can be hazardous to operate. This vehicle handles differently than other vehicles, such as cars, trucks or other off-road vehicles. A collision or rollove...

6 INTRODUCTION Vehicle Identification Numbers Record your vehicle's identification numbers and key number in the spaces provided. Remove the spare key and store it in a safe place. An ignition key can be duplicated only by ordering a POLARIS key blank (using your key number) and mating it with one o...

7 INTRODUCTION European Vibration and Noise The driver-perceived noise and hand/arm and whole body vibration levels of this machinery is measured per prEN 15997. The operating conditions of the machinery during testing: The vehicles were in like-new condition. The environment was controlled as indic...

8 SAFETY Safe Riding Gear The driver and all passengers must wear helmet, eye protection, gloves, long-sleeve shirt, long pants, over-the-ankle boots and seat belt at all times. Protective gear reduces the chance of injury. Helmet Wearing a helmet can prevent a severe head injury. Whenever riding th...

9 SAFETY Safe Riding Gear Eye Protection Do not depend on eyeglasses or sunglasses for eye protection. Whenever riding this POLARIS vehicle, always wear shatterproof goggles or use a shatterproof helmet face shield. POLARIS recommends wearing approved Personal Protective Equipment (PPE) bearing mark...

10 SAFETY Safety Labels and Locations Warning labels have been placed on the vehicle for your protection. Read and follow the instructions of the labels on the vehicle carefully. If any of the labels depicted in this manual differ from the labels on your vehicle, always read and follow the instructi...

11 SAFETY Safety Labels and Locations Seat Belt/Drive Responsibly Warning WARNING Improper vehicle use can result in SEVERE INJURY or DEATH Be Prepared • Fasten seat belts. • Wear an approved helmet and protective gear. • ALWAYS use vehicle cab nets and/or doors. • Each rider must be able to sit wit...

12 SAFETY Safety Labels and Locations Load/Passenger/Tire Pressure Warning Storage Box Load 250 lbs. (113 kg) WARNING • Never carry passengers in cargo box.• Passengers can be thrown off. This can cause serious injury or death. IMPROPER TIRE PRESSURE OR OVERLOADING CAN CAUSE LOSS OF CONTROL RESULTIN...

13 SAFETY Operator Safety Serious injury or death can result if you do not follow these instructions and procedures, which are outlined in further detail within your owner's manual. • Read this entire manual and all labels carefully. Follow the operating procedures described. • Never allow anyone un...

14 SAFETY Operator Safety • Always travel slowly and use extra caution when operating on unfamiliar terrain. Be alert to changing terrain. • Never operate on excessively rough, slippery or loose terrain.• Always follow proper procedures for turning. Practice turning at slow speeds before attempting ...

15 SAFETY Operator Safety • Always use the proper size and type of tires specified in this manual. Always maintain proper tire pressure as specified on safety labels. • Never modify this vehicle through improper installation or use of non-POLARIS- approved accessories. • Never exceed the stated load...

16 SAFETY Operator Safety Failure to operate the RANGER properly can result in a collision, loss of control, accident or rollover, which may result in serious injury or death. Heed all safety warnings outlined in this section of the owner’s manual. See the OPERATION section of the owner’s manual for...

17 SAFETY Operator Safety Cab Nets Riding in this vehicle without using the cab nets (or doors, if equipped) increases the risk of serious injury or death in the event of an accident or rollover. Always use the cab nets (or doors) while riding in this vehicle. Always keep hands and feet inside the v...

18 SAFETY Operator Safety Handling Gasoline Gasoline is highly flammable and explosive under certain conditions. • Always exercise extreme caution whenever handling gasoline.• Always turn off the engine when refueling.• Always refuel outdoors or in a well ventilated area free of any source of flame ...

19 SAFETY Operator Safety Turning Improperly Turning improperly could cause loss of traction, loss of control, accident or rollover. Always follow proper procedures for turning as described in this owner’s manual. Never turn abruptly or at sharp angles. Never turn at high speeds. Practice turning at...

20 SAFETY Operator Safety Improper Tire Maintenance Operating this vehicle with improper tires or with improper or uneven tire pressure could cause loss of control or accident. Always use the size and type of tires specified for your vehicle. Always maintain proper tire pressure as described in the ...

21 FEATURES AND CONTROLS Component Locations Your vehicle is equipped with cab nets on both sides of the vehicle. Cab nets (or doors, if equipped) must be used by both operator and passengers at all times. Any illustrations without cab nets are only to allow component identification. Always use the ...

22 FEATURES AND CONTROLS Console Auxiliary Outlets The 12-volt receptacles have spade connections on the back that may be used to power an auxiliary light or other optional accessories or lights. The connections are behind the console, under the dash. On CREW models, an additional receptacle is loca...

23 FEATURES AND CONTROLS Switches Ignition Switch The ignition switch is a three-position, key-operated switch. The key can be removed from the switch when it is in the OFF position. Mode Button The MODE button is located on the instrument cluster. Use the MODE button to toggle through mode options ...

24 FEATURES AND CONTROLS Trailer Hitch Bracket This vehicle is equipped with a receiver hitch bracket for a trailer hitch. To avoid injury and property damage, always heed the warnings and towing capacities outlined on pages 44-45. Brake Pedal Depress the brake pedal to slow or stop the vehicle. App...

25 FEATURES AND CONTROLS Park Brake Lever To help prevent the vehicle from rolling, engage the park brake when parking the vehicle. When the park brake is fully engaged, “BRAKE” appears in the rider information display. Engine speed is limited to 1300 RPM in all gears, except neutral. If throttle is...

26 FEATURES AND CONTROLS Cab Nets Riding in this vehicle without using the cab nets (or doors, if equipped) increases the risk of serious injury or death in the event of an accident or rollover. Cab nets (or doors) must be used by both operator and passengers at all times. Make sure all latches are ...

27 FEATURES AND CONTROLS Seat Removal Pull up on the front of the seat and slide it toward the front of the vehicle. Install the seat by sliding the tabs into the rear of the seat base. Push down firmly on the front of the seat until the pins are fully seated into the grommets. Seat Belts This POLAR...

28 FEATURES AND CONTROLS Rollover Protective Structure (ROPS) The Rollover Protective Structure (ROPS) on this vehicle meets OSHA 1928.53 rollover performance requirements. Always have your authorized POLARIS dealer thoroughly inspect the ROPS if it ever becomes damaged in any way. No device can ass...

29 FEATURES AND CONTROLS Instrument Cluster High water pressure may damage components. Wash the vehicle by hand or with a garden hose using mild soap. Do not use alcohol to clean the instrument cluster. Do not allow insect sprays to contact the lens. Speedometer The speedometer displays vehicle spee...

30 FEATURES AND CONTROLS Instrument Cluster Rider Information Center The rider information center is located in the instrument cluster. All segments will light up for one second at start-up. If the instrument cluster fails to illuminate, a battery over-voltage may have occurred and the instrument cl...

31 FEATURES AND CONTROLS Instrument Cluster Rider Information Center Use the MODE button to toggle through the information area options. Display Units (Standard/Metric) The display can be changed to display either standard or metric units of measurement. Tip: To exit the set-up mode at any time, wai...

32 FEATURES AND CONTROLS Instrument Cluster Rider Information Center Odometer Mode The odometer records and displays the distance traveled by the vehicle. Trip Meter Mode The trip meter records the distance traveled by the vehicle if reset before each trip. To reset, select the trip meter mode. Pres...

33 FEATURES AND CONTROLS Instrument Cluster Rider Information Center Engine Error Codes The error screen displays only when the CHECK ENGINE light is on or when it goes on and off during one ignition cycle. Error codes are not stored. When the key is turned OFF, the code and message is lost, but wil...

34 OPERATION Failure to operate the vehicle properly can result in a collision, loss of control, accident or rollover, which may result in serious injury or death. Read and understand all safety warnings outlined in the safety section of this owner’s manual. Break-In Period The break-in period for y...

35 OPERATION Pre-Ride Inspection Failure to inspect and verify that the vehicle is in safe operating condition before operating increases the risk of an accident. Always inspect the vehicle before each use to make sure it's in safe operating condition. Item Remarks Page Brake system/pedal travel Ens...

36 OPERATION Starting the Engine 1. Always start the engine outdoors or in a well-ventilated area. 2. Sit in the driver's seat and fasten the seat belt. Secure the cab nets (or doors). 3. Apply the brakes. Engage the park brake. 4. Shift the transmission to neutral. 5. Do not press the throttle peda...

37 OPERATION Driving Procedure 1. Wear a helmet, eye protection, gloves, long-sleeve shirt, long pants and over-the-ankle boots. 2. Perform the pre-ride inspection. See page 35. 3. Sit in the driver's seat and fasten the seat belt. 4. Always use the cab nets (or doors) while riding in this vehicle. ...

38 OPERATION Driving with a Passenger 1. Perform the pre-ride inspection. See page 35. 2. Make sure all passengers are at least 12 years of age and tall enough to comfortably and safely sit in a passenger seat with the seat belt secured, put both feet on the floor and grasp the hand hold. 3. Make su...

39 OPERATION Driving on Slippery Surfaces Skidding or sliding can cause loss of control or rollover (if tires regain traction unexpectedly). When operating on slippery surfaces such as ice or loose gravel, reduce speed and use extra caution to reduce the chance of skidding or sliding out of control....

40 OPERATION Driving Over Obstacles Follow these precautions when operating over obstacles: 1. Always check for obstacles before operating in a new area. 2. Look ahead and learn to read the terrain. Be constantly alert for hazards such as logs, rocks and low hanging branches. 3. Travel slowly and us...

41 OPERATION Driving Uphill Whenever traveling uphill, follow these precautions: 1. Always travel straight uphill.2. Avoid excessively steep hills.3. Keep both feet on the floor.4. Always check the terrain carefully before ascending any hill. 5. Never climb hills with excessively slippery or loose s...

42 OPERATION Driving Through Water Your POLARIS RANGER can operate through water up to a maximum recommended depth equal to the floorboards. NOTICE: Immersion can result in major damage if the vehicle isn't serviced correctly and promptly. After immersion, always take the vehicle to your dealer serv...

43 OPERATION Driving in Reverse Follow these precautions when operating in reverse: 1. Always check for obstacles or people behind the vehicle. Always inspect left and right fields of vision before backing. 2. Always avoid backing downhill.3. Back slowly.4. Apply the brakes lightly for stopping. 5. ...

44 OPERATION Hauling Cargo Hauling cargo improperly can alter vehicle handling and may cause loss of control or brake instability, which can result in serious injury or death. Always follow these precautions when hauling cargo: Never exceed the maximum weight capacity of the vehicle. When determinin...

45 OPERATION Towing Loads Towing improperly can alter vehicle handling and may cause loss of control or brake instability. Always follow these precautions when towing: 1. Never load more than 150 lbs. (68.1 kg) tongue weight on the towing bracket. 2. Always shift to low gear for towing. 3. When towi...

46 OPERATION Dumping the Cargo Box 1. Select a level site to dump the cargo box. Do not attempt to dump or unload the vehicle while parked on an incline. 2. Apply the brakes. Place the transmission in gear. Engage the park brake. 3. Dismount the vehicle. 4. Ensure that the cargo is positioned evenly...

47 OPERATION All Wheel Drive (AWD) Engaging AWD Press the top of the switch to engage All Wheel Drive (AWD). The 4X4 indicator illuminates in the rider information center to indicate that the vehicle is in AWD. See page 30. When the AWD switch is on, the front wheels will automatically engage any ti...

48 OPERATION All Wheel Drive (AWD) Locking the Differential NOTICE: Damage to the differential can occur if it is engaged while the vehicle is traveling at high speeds or while the rear wheels are spinning. Slow the vehicle to nearly stopped before engaging the differential. Locking the differential...

49 WINCH GUIDE These safety warnings and instructions apply if your vehicle came equipped with a winch or if you choose to add an accessory winch to your vehicle. Improper winch use can result in SEVERE INJURY or DEATH. Always follow all winch instructions and warnings in this manual. Your winch may...

51 WINCH GUIDE Winch Operation Read the Winch Safety Precautions in the preceding pages before using your winch. Tip: Consider practicing the operation and use of your winch before you actually need to use it in the field. Improper winch use can result in SEVERE INJURY or DEATH. Always follow all wi...

52 WINCH GUIDE Winch Operation 4. Always use the hook strap when handling the hook. WARNING! Never put your fingers into the hook. This could lead to SEVERE INJURY. A. Attach the hook itself onto the load or use a tow strap or chain to secure the load to the winch cable. Tip: A “tow strap” is NOT in...

53 WINCH GUIDE Winch Operation 8. Read and adhere to the following information for winch damping to ensure safe winch use. A. In order to absorb energy that could be released by a winch cable failure, always place a “damper” on the winch cable. A damper can be a heavy jacket, tarp, or other soft, de...

55 WINCH GUIDE Winch Cable Care For your safety, always replace POLARIS winch parts (including the cable) with genuine POLARIS replacement parts available at your authorized POLARIS dealer. WARNING! Use of worn or damaged cable could lead to sudden failure and SEVERE INJURY. 1. Always inspect your w...

56 WINCH GUIDE Shock Loading WARNING! Your winch cable is very strong but it is NOT designed for dynamic, or “shock” loading. Shock loading may tension a winch cable beyond its strength and cause the cable to break. The end of a broken winch cable under such high loading can cause SEVERE INJURY or D...

57 WINCH GUIDE Winch Maintenance and Service Safety WARNING! Improper or lack of winch maintenance and service could lead to SEVERE INJURY or DEATH. Always follow all winch instructions and warnings in this manual. 1. Always inspect your winch before each use. Inspect for worn or kinked winch cable....

58 EMISSION CONTROL SYSTEMS Noise Emission Control System Do not modify the engine, intake or exhaust components, as doing so may affect compliance with U.S.A. EPA noise control requirements (40 CFR 205) and local noise level requirements. Operation on Public Lands in the U.S.A. Your POLARIS vehicle...

59 MAINTENANCE Periodic Maintenance Chart Careful periodic maintenance will help keep your vehicle in the safest, most reliable condition. Inspection, adjustment and lubrication of important components are explained in the periodic maintenance chart. Inspect, clean, lubricate, adjust and replace par...

62 MAINTENANCE Lubrication Recommendations Check and lubricate all components at the intervals outlined in the Periodic Maintenance Chart beginning on page 59, or more often under severe use, such as wet or dusty conditions. Items not listed in the chart should be lubricated at the general lubricati...

63 MAINTENANCE Engine Intake Restrictor Plate Some RANGER 800 models are equipped with an intake restrictor plate in order to meet vehicle class regulations. This plate MUST NOT be removed for any reason. Removal of the intake restrictor plate will void the warranty on the vehicle. Engine Oil Always...

64 MAINTENANCE Engine Oil Oil and Filter Change Always change the oil and filter at the intervals outlined in the Periodic Maintenance Chart beginning on page 59. Always change the oil filter whenever changing oil. 1. Position the vehicle on a level surface. 2. Run the engine for two to three minute...

65 MAINTENANCE Gearcases Gearcase Specification Chart RANGER 4X4 Gearcase Specifications Gearcase Lubricant Capacity Fill Plug(s) Torque Drain Plug Torque Main Gearcase (Transmission) AGL Gearcase Lubricant & Transmission Fluid 34 oz. (1000 ml) 12 ft. lbs. (16.3 Nm) 12 ft. lbs. (16.3 Nm) Front G...

66 MAINTENANCE Gearcases Transmission (Main Gearcase) (4X4/CREW) Always check and change the transmission oil at the intervals outlined in the Periodic Maintenance Chart beginning on page 59. Refer to the Gearcase Specifications Chart on page 65 for recommended lubricants, capacities and torque spec...

67 MAINTENANCE Gearcases Transmission (Main Gearcase) (6X6) Always check and change the transmission oil at the intervals outlined in the Periodic Maintenance Chart beginning on page 59. Maintain the oil level even with the bottom of the fill plug hole. Refer to the Gearcase Specifications Chart on ...

68 MAINTENANCE Gearcases Front Gearcase Always check and change the front gearcase oil at the intervals outlined in the Periodic Maintenance Chart beginning on page 59. Maintain the oil level even with the bottom thread of the fill plug hole. Refer to the Gearcase Specifications Chart on page 65 for...

69 MAINTENANCE Gearcases Middle Gearcase (6X6) Always check and change the middle gearcase oil at the intervals outlined in the Periodic Maintenance Chart beginning on page 59. Maintain the oil level even with the bottom thread of the fill plug hole. Refer to the Gearcase Specifications Chart on pag...

71 MAINTENANCE Spark Plugs Spark Plug Recommendations Refer to the specifications section beginning on page 94 for the recommended spark plug type for your vehicle. Always torque spark plugs to specification. NOTICE: Using non-recommended spark plugs can result in serious engine damage. Always use P...

72 MAINTENANCE Cooling System The engine coolant level is controlled or maintained by the recovery system. The recovery system components are the overflow bottle, radiator filler neck, radiator pressure cap and connecting hose. As coolant operating temperature increases, the expanding (heated) exces...

73 MAINTENANCE Cooling System Overflow Bottle Coolant Level Always check and change the coolant at the intervals outlined in the Periodic Maintenance Chart beginning on page 59. Maintain the coolant level between the minimum and maximum marks on the bottle (when the fluid is cool). The overflow bott...

74 MAINTENANCE POLARIS Variable Transmission (PVT) System Failure to comply with the instructions in this warning can result in severe injury or death. Do not modify any component of the PVT system. Doing so may reduce its strength so that a failure may occur at a high speed. The PVT system has been...

75 MAINTENANCE POLARIS Variable Transmission (PVT) System Belt Replacement/Debris Removal If a belt fails, always clean any debris from the duct and from the clutch and engine compartments when replacing the belt. WARNING! Failure to remove ALL debris when replacing the belt could result in vehicle ...

76 MAINTENANCE Vehicle Immersion NOTICE: If your vehicle becomes immersed, major engine damage can result if the machine is not thoroughly inspected. Take the vehicle to your dealer before starting the engine. If it's impossible to take your RANGER to a dealer before starting it, follow the steps ou...

77 MAINTENANCE Spark Arrester Failure to heed the following warnings while servicing the spark arrester could result in serious injury or death. • Do not perform service on the spark arrester while the system is hot. Exhaust system temperatures can reach 1000° F. Allow components to cool sufficientl...

78 MAINTENANCE Throttle System Failure to check or maintain proper operation of the throttle system can result in an accident and lead to serious injury or death if the throttle pedal sticks during operation. Always check the pedal for free movement and return before starting the engine and occasion...

79 MAINTENANCE Brakes The front and rear brakes are hydraulic disc type brakes activated by the brake pedal. See page 24. Brake Fluid Inspect the brake system routinely. Inspect the level of the brake fluid before each operation. WARNING! After opening a bottle of brake fluid, always discard any unu...

80 MAINTENANCE Brakes Park Brake Adjustment Inspect and adjust park brake cable tension after the first 25 hours of operation and every 100 hours thereafter to ensure proper cable tension. Loss of tension in the park brake cable may cause “BRAKE” to display in the rider information center, along wit...

81 MAINTENANCE Tires Operating your vehicle with worn tires, improperly inflated tires, non-standard tires or improperly installed tires will affect vehicle handling and could cause an accident resulting in serious injury or death. Always follow all tire maintenance procedures as outlined in this ma...

82 MAINTENANCE Tires Wheel Removal 1. Apply the brakes. Engage the park brake. 2. Stop the engine. Place the transmission in gear. 3. Loosen the wheel nuts slightly. 4. Elevate the side of the vehicle by placing a suitable stand under the frame. 5. Remove the wheel nuts and washers. Remove the wheel...

83 MAINTENANCE Lights Poor lighting can result in reduced visibility when driving. Headlight and taillight lenses become dirty during normal operation. Clean lights frequently and replace burned out lamps promptly. Do not operate this vehicle at night or in low light conditions until the headlight i...

84 MAINTENANCE Lights Headlight Beam Adjustment 1. Place the vehicle on a level surface with the headlight approximately 25 ft. (7.6 m) from a wall. 2. Place the transmission in gear. Engage the park brake. 3. Measure the distance from the floor to the center of the headlight and make a mark on the ...

85 MAINTENANCE Fuses If the engine stops or will not start, or if you experience other electrical failures, a fuse may need replacement. Locate and correct any short circuits that may have caused the blown fuse, then replace the fuse. Spare fuses are provided in the fuse box. The power steering fuse...

86 MAINTENANCE Battery Battery electrolyte is poisonous. It contains sulfuric acid. Serious burns can result from contact with skin, eyes or clothing. Antidote: External : Flush with water. Internal : Drink large quantities of water or milk. Follow with milk of magnesia, beaten egg, or vegetable oil...

87 MAINTENANCE Battery Battery Removal Improperly connecting or disconnecting battery cables can result in an explosion and cause serious injury or death. When removing the battery, always disconnect the negative (black) cable first. When reinstalling the battery, always connect the negative (black)...

88 MAINTENANCE Battery Battery Installation Using a new battery that has not been fully charged can damage the battery and result in a shorter life. It can also hinder vehicle performance. Follow the battery charging instructions on page 89 before installing the battery. 1. Ensure that the battery i...

89 MAINTENANCE Battery Battery Charging (Conventional Battery) 1. Remove the battery from the vehicle to prevent damage from leaking or spilled electrolyte during charging. See page 87. 2. Charge the battery with a charging output no larger than 1/10 of the battery’s amp/hr rating. Charge as needed ...

90 MAINTENANCE Cleaning and Storage Washing the Vehicle Keeping your POLARIS vehicle clean will not only improve its appearance but it can also extend the life of various components. NOTICE: High water pressure may damage components. POLARIS recommends washing the vehicle by hand or with a garden ho...

91 MAINTENANCE Cleaning and Storage Storage Tips NOTICE: Starting the engine during the storage period will disturb the protective film created by fogging and damage could occur. Never start the engine during the storage period. Clean the Exterior Make any necessary repairs and clean the vehicle as ...

92 MAINTENANCE Cleaning and Storage Storage Tips Inspect and Lubricate Inspect all cables and lubricate all areas of the vehicle as recommended in the Periodic Maintenance Chart beginning on page 59. Battery Maintenance See page 88 for storage and charging procedures. Fluid Levels Inspect the fluid ...

93 MAINTENANCE Removal from Storage 1. Check the battery electrolyte level and charge the battery if necessary. Install it in the vehicle. Make sure the battery vent hose is routed properly and that it's not pinched or restricted in any way. 2. Make sure the spark plug is tight. 3. Fill the fuel tan...

94 SPECIFICATIONS RANGER 800 EFI/EPS Maximum Weight Capacity 1500 lbs. (681 kg) (including operator, passenger, cargo, accessories)1100 lbs. (499 kg) (Models sold in California) Dry Weight 1237 lbs. (561 kg) Test GVW - Rollover Protection System (ROPS) 2940 lbs. (1333.5 kg) per OSHA 29 CFR 1928.53 F...

95 SPECIFICATIONS Clutching See your POLARIS dealer for clutching specifications. RANGER 800 EFI/EPS Driving System Type PVT, 4-wheel independent shaft, lockable differential Shift Type Single Lever (H/L/N/R) Gear Reduction - Low 7.70:1 Gear Reduction - Reverse 7.00:1 Gear Reduction - High 3.6:1 Dri...

100 POLARIS PRODUCTS Part Number Description Engine Lubricant 2870791 Fogging Oil (12 oz./355 ml Aerosol) 2876244 PS-4 Full Synthetic 5W-50 4-Cycle Oil (qt./.95 l) 2876245 PS-4 Full Synthetic 5W-50 4-Cycle Oil (gal./3.8 l) Gearcase / Transmission Lubricants 2878068 AGL Full Synthetic Gearcase Lubric...

101 TROUBLESHOOTING Drive Belt Wear/Burn Possible Cause Solution Driving onto a pickup or tall trailer in high range Use low range during loading. Starting out going up a steep incline Use low range. See warnings on page 41. Driving at low RPM or ground speed (3-7 MPH) Drive at a higher speed or use...

102 TROUBLESHOOTING Park Brake Engine Limiting Feature Fails to Disengage Engine Doesn't Turn Over Engine Turns Over, Fails to Start Engine Backfires Engine Pings or Knocks Possible Cause Solution Park brake is not completely disengaged Ensure lever is in forward-most position Park brake connector m...

103 TROUBLESHOOTING Engine Runs Irregularly, Stalls or Misfires Engine Stops or Loses Power Possible Cause Solution Fouled or defective spark plugs Inspect, clean and/or replace spark plugs Worn or defective spark plug wires See your dealer Incorrect spark plug gap or heat range Set gap to specs or ...

104 WARRANTY LIMITED WARRANTY POLARIS Sales Inc., 2100 Highway 55, Medina, MN 55340 (POLARIS) gives a SIX MONTH LIMITED WARRANTY on all components of your POLARIS vehicle against defects in material or workmanship. POLARIS further warrants that the spark arrestor in this product will meet the effici...

105 WARRANTY LIMITATIONS OF WARRANTIES AND REMEDIES This warranty excludes damages or failures caused by abuse, accident, fire, or any other cause other than a defect in materials or workmanship and provides no coverage for consumable components, general wear items, or any parts exposed to friction ...

106 WARRANTY HOW TO OBTAIN WARRANTY SERVICE If your vehicle requires warranty service, you must take it to a POLARIS Servicing Dealer. When requesting warranty service you must present your copy of the Warranty Registration From to the dealer. (THE COST OF TRANSPORTATION TO AND FROM THE DEALER IS YO...

108 WARRANTY U.S.A. EPA Emissions Limited Warranty The exclusive remedy for breach of this limited warranty shall be, at the exclusive option of POLARIS, repair or replacement of any defective materials, components or products. THE REMEDIES SET FORTH IN THIS LIMITED WARRANTY ARE THE ONLY REMEDIES AV...

109 MAINTENANCE LOG Use the following chart to record periodic maintenance. DATE MILES (KM) OR HOURS TECHNICIAN SERVICE PERFORMED / COMMENTS

110 INDEX A Accessory Outlets . . . . . . . . . . . . . . . . . . . . . . . . 22Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76Air Filter Cleaning . . . . . . . . . . . . . . . . . . . . . . . . 76 All Wheel Drive . . . . . . . . . . . . . . . . . . . . . . . 47-48 Diseng...