Page 2 - USE OUTDOORS IN A WELL-VENTILATED SPACE.; NOTICE TO CONSUMER: Keep these instructions for future reference.; CONGRATULATIONS; You’ve Just Upgraded Your Grilling Game.
2 | Welcome Napoleon.com | BUILT-IN Series ! ! WE WANT YOUR GRILLING EXPERIENCE TO BE MEMORABLE AND SAFE. Please read and follow this Owner’s Manual before using your grill to avoid property damage, personal injury, or death. Remove all packaging material, promotional labels and cards from the grill...
Page 3 - om; C O N T E N T S; Safety First; WARNING
Napoleon.com | BUILT-IN Series Welcome | 3 Welc om e Welcome to Napoleon! EMAIL [email protected] ONLINE www.napoleon.com PHONE: 1-866-820-8686 C O N T E N T S Welcome to Napoleon! 3 Safety First Full System Features 4 Getting Started 5 Locating Your Outdoor Gas GrillCut-Out DimensionsGas Connection...
Page 4 - Full System Features; WAVE
4 | Features Napoleon.com | BUILT-IN Series Fe at ur es Full System Features The grills illustrated in this Owner’s Manual may differ from the model you purchased. ! Easy access to drip pan with stainless steel roller bearings for efficient maintenance Back-lit Control Knobs for late night entertain...
Page 5 - Getting Started; STOP; dditional
Napoleon.com | BUILT-IN Series Getting Started | 5 G ett in g S ta rte d Getting Started CAUTION! The hook-up and installation of the gas and hose connection must be performed by a licensed gas fitter, and leak tested before operating the grill. CAUTION! Ensure the hoses do not contact any high temp...
Page 6 - Open both ends
6 | Getting Started Napoleon.com | BUILT-IN Series G et tin g S ta rt ed It is important when selecting a location for your gas grill to ensure clearances to adjacent combustibles are met. This appliance is intended for installation on an outdoor patio or in your yard. ‘This appliance shall only be ...
Page 7 - ut
Napoleon.com | BUILT-IN Series Getting Started | 7 G ett in g S ta rte d D A B H W W X Non combustible countertop C A = 6.5" (16.5 CM) B = 6.5" (16.5 CM) C = 5.7" (14.5 CM) MIN. E* E*= For use with the installation of a Napoleon BI door. c ut -o ut d imenSionS WARNING ! The cabinet frame...
Page 8 - aS
8 | Getting Started Napoleon.com | BUILT-IN Series G et tin g S ta rt ed g aS c onnectionS This grill must operate with a gas supply pressure of 2.75 kPa (0.39 psi) for propane and 1.00 kPa (0.25 psi) for natural gas. If the gas supply exceeds these requirements a regulator must be installed upstrea...
Page 9 - To a Portable LP Cylinder
Napoleon.com | BUILT-IN Series Getting Started | 9 G ett in g S ta rte d Applicable to: (BIB 10) To a Portable LP Cylinder Only use a propane cylinder constructed and marked in accordance with the AS/NZS 5601 and local codes. The cylinder connection device must be compatible with the connection for ...
Page 10 - a ximum; If Placing the Cylinder in a Built-in Enclosure; Openin; Cylinder size
10 | Getting Started Napoleon.com | BUILT-IN Series G et tin g S ta rt ed 306 mm 465 mm m a ximum c ylinder d imenSionS WARNING ! Close the individual shutoff valve to isolate the grill from the gas supply piping system during any pressure testing equal to or less than ½ Psi (3.5 kPa). WARNING ! Che...
Page 11 - Leak Test Steps; If you find a leak
Napoleon.com | BUILT-IN Series Getting Started | 11 G ett in g S ta rte d l eak t eSt Why and When to Leak Test? A leak test confirms no gas is escaping after you connect the hose to the gas supply.Each time the tank is refilled and reinstalled, ensure that there are no leaks in the fitting where th...
Page 12 - ighting; Operation; Lighting with a match
12 | Operation Napoleon.com | BUILT-IN Series O pe ra tio n l ighting your grill Is it the very first time? Perform a Burn-off Remove warming rack and run the main burners on high for 30 minutes. It is normal for the grill to emit an odor the first time it is lit. This odor is caused by the “burn-of...
Page 13 - BE; Indirect Grilling
Napoleon.com | BUILT-IN Series Operation | 13 O pe ra tio n WARNING! Never grill food directly on the flame side burner. It is designed for use with pots and pans only. WARNING! Do not close side burner lid while it is operating or hot. WARNING! Do not deep fr y food on the side burner. Cooking with...
Page 14 - GRILLING
14 | Operation Napoleon.com | BUILT-IN Series O pe ra tio n WARNING! Do not leave food unattended on any lit burners. WARNING! Keep the lid open if main infrared burner is set on high to prevent accidentally burning food. ! GRILLING PRO TIP! Use a thermometer to check the internal temperature of mea...
Page 15 - Option 2
Napoleon.com | BUILT-IN Series Operation | 15 O pe ra tio n Assembling Your Rotisserie Kit (if equipped) 6 5 4 3 2 1 6 5 4 3 2 1 h ow to uSe the r ear B urner & r otiSSerie 6 5 4 3 2 1 6 5 4 3 2 1 6 5 4 3 2 1 6 5 4 3 2 1 BIG 44 Spit Rod: Option 1 • The rotisserie motor can be mounted on either s...
Page 16 - DID YOU; Tips about using the Rotisserie:
16 | Operation Napoleon.com | BUILT-IN Series O pe ra tio n WARNING! Disassemble rotisserie components when finished cooking, wash with warm soapy water, and store indoors. WARNING! Use heat resistant grilling gloves when handling the hot rotisserie components. WARNING! Disconnect rotisserie plug fr...
Page 18 - rilli; Infrared Grilling Guide
18 | Grilling Guide Napoleon.com | BUILT-IN Series G rilli ng G ui de Infrared Grilling Guide FOOD CONTROL KNOB SETTING COOKING TIME SUGGESTIONS Steak 1 inch (2.54 cm) thick HIGH – 2 minutes each side Rare – 4 minutes Ask for marbled fat in cut. Fat is a natural tenderizer and keeps meat juicy. HIGH...
Page 19 - Cleaning Instructions; First Time Use
Napoleon.com | BUILT-IN Series Cleaning | 19 Cle an in g Cleaning Instructions WARNING! Always wear protective gloves and safety glasses when cleaning your grill. WARNING ! Accumulated grease is a fire hazard. WARNING ! Cleaning should only be done when the grill is cool to avoid the possibility of ...
Page 20 - Drip Pan
20 | Cleaning Napoleon.com | BUILT-IN Series Cl ea nin g WARNING ! Ensure all burners are turned off and grill is cool before cleaning. Do not use oven cleaner to clean any part of the grill. Do not put cooking grids or any other parts of the grill in a self-cleaning oven to clean. Clean the grill i...
Page 21 - SAFETY; Insect Screen and Burner Ports
Napoleon.com | BUILT-IN Series Cleaning | 21 Cle an in g WARNING ! It is ver y important the valve/orifice enters the burner tube when reinstalling the burner after cleaning and before lighting your grill, or a fire or explosion could occur. WARNING ! Avoid unprotected contact with hot surfaces. WAR...
Page 22 - Maintenance Instructions; omBuStion; RECOMMENDATIONS; Model
22 | Maintenance Napoleon.com | BUILT-IN Series M ai nte na nc e Maintenance Instructions WARNING ! Keep the grill away from combustible materials, gasoline, and other flammable vapors and liquids. ! c omBuStion in air adjuStment ! IMPORTANT ! This must be done by a qualified gas installer. • The ai...
Page 23 - WE WANT; tainleSS; Maintenance and Protection of Infrared Burners; Steps to Avoid Damaging Ceramic Surfaces; Clearance Ventilation of hot air
Napoleon.com | BUILT-IN Series Maintenance | 23 M ai nte na nc e WE WANT TO HELP! Contact the Napoleon Customer Solutions Department for recommended replacement parts. 1-866-820-8686. S tainleSS in harSh environmentS Stainless steel oxidizes or stains in the presence of chlorides and sulfides, espec...
Page 24 - ou; Troubleshooting; Lighting Problems
24 | Troubleshooting Napoleon.com | BUILT-IN Series Tr ou bl es ho ot in g Troubleshooting Lighting Problems • Main, rear or side burners will not light with the igniter, but will light with a match.• Burners will not cross light each other. Possible causes Solution M ain Bu rn er JETFIRE TM outlet ...
Page 25 - Gas Flow
Napoleon.com | BUILT-IN Series Troubleshooting | 25 Tro ub le sh oot in g Gas Flow • Low heat or low flame when valve is turned to high.• Burners burn with yellow flame, accompanied by the smell of gas.• Flames lift away from burner, accompanied by the smell of gas, and possible lighting difficultie...
Page 26 - Infrared Burner Flashes Back; Peeling Paint; REGISTER
26 | Troubleshooting Napoleon.com | BUILT-IN Series Tr ou bl es ho ot in g Infrared Burner Flashes Back • During operation the burner abruptly makes a loud whoosh sound, followed by a continuous blow-torch type sound and grows dim or has a large flame on start up. Possible causes Solution Ceramic ti...
Page 27 - Warranty
Napoleon.com | BUILT-IN Series Troubleshooting | 27 Tro ub le sh oot in g d iagr am for e lectrical c onnectionS Warranty BIG44RB: ELECTRODE IGNITER - 12VAC/DC, 1.5W, 120mA FUSE - 2 A TRANSFORMER - INPUT: 230v 50z - OUTPUT: 12VAC ~ 2083mA, 25W POWER SWITCHES - KNOBS CONTROL BOX - OUTPUT: 12VDC, 24W ...
Page 28 - NAPOLEON LIMITED LIFETIME WARRANTY; FOR PRESTIGE; ra
28 | Warranty Napoleon.com | BUILT-IN Series W ar ra nt y NAPOLEON LIMITED LIFETIME WARRANTY FOR PRESTIGE ® , PRESTIGE PRO ™ AND BUILT-IN SERIES MODELS PARTS FOR 15 YEARS + LIFETIME MAJOR COMPONENTS Napoleon products are designed with superior components and materials and are as-sembled by trained c...
Page 32 - NAPOLEON - CELEBRATING OVER 40 YEARS
Napoleon.com | BUILT-IN Series Last Revision | - | July 27, 2022 NAPOLEON - CELEBRATING OVER 40 YEARS OF HOME COMFORT PRODUCTS De Riemsdijk 22, 4004 LC, Tiel, The Netherlands 10-12 Home Farm, Meriden Road, Berkswell, CV7 7SL, United Kingdom 24 Napoleon Road, Barrie, Ontario, L4M 0G8, Canada PHONE: +...
