Page 2 - PROPOSITION 65 WARNING
Page 3 - NOTES
OPERATION & PARTS MANUAL — REV. #0 (01/25/06) — PAGE 3 NOTES
Page 4 - TABLE OF CONTENTS; NOTE
PAGE 4 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) TABLE OF CONTENTS Specification and part number are subject to change without notice . NOTE NOTE As a continuing effort to u p d a t e o u r p a r t s b o o k , c o n t a c t t h e M U LT I QU I P literature department for the l a t e s t r e v...
Page 5 - Ordering parts has never been easier!; Choose from three easy options:; Order via Internet; Order; PARTS ORDERING PROCEDURES
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 5 www .m ultiquip .com Ordering parts has never been easier! Choose from three easy options: WE ACCEPT ALL MAJOR CREDIT CARDS! When ordering parts, please supply: ❒ ❒ ❒ ❒ ❒ Dealer Account Number ❒ ❒ ❒ ❒ ❒ Dealer Name and Address ❒ ❒ ❒ ❒ ❒ Shipping...
Page 6 - SAFETY MESSAGES; DANGER; NOTICE; SAFETY INFORMATION
PAGE 6 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safety messages and operating instructions could resu...
Page 7 - GENERAL SAFETY; PUMP SAFETY
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 7 GENERAL SAFETY CAUTION NEVER operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective devices required by the job or city and state regul...
Page 8 - ENGINE SAFETY
PAGE 8 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) CAUTION NEVER lubricate components or attempt service on a running machine. NEVER block or restrict flow from discharge hose. Remove kinks from discharge line before starting pump. Operation with a blocked discharge line can cause water ins...
Page 9 - FUEL SAFETY
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 9 FUEL SAFETY DANGER DO NOT add fuel to equipment if it is placed inside truck bed with plastic liner. Possibility exists of explosion or fire due to static electricity. DO NOT start the engine near spilled fuel or combustible fluids. Fuel is ...
Page 10 - TRANSPORTING SAFETY; ENVIRONMENTAL SAFETY
PAGE 10 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) TRANSPORTING SAFETY CAUTION NEVER allow any person or animal to stand underneath the equipment while lifting. NOTICE Before lifting, make sure that the equipment parts (hook and vibration insulator) are not damaged and screws are not loose...
Page 12 - GENERAL INFORMATION
PAGE 12 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) GENERAL INFORMATION APPLICATION The QP4TE Trash Pump is designed to be used for de-watering applications. Both the suction and discharge ports on the QP4TEpump use a 4-inch diameter opening, which allows the pump topump at a rate of approximat...
Page 13 - Figure 1. QP4TE Pump Dimensions; ti
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 13 Figure 1. QP4TE Pump Dimensions ) p m u P ( s n o i t a c i f i c e p S . 1 e l b a T p m u P l e d o M E T 4 - P Q e p y T p m u P h s a r T e z i S e g r a h c s i D & n o it c u S ) . m m 0 0 1 x 0 0 1 ( . n i 4 x 4 g n i p m u P m u m i...
Page 15 - PUMP COMPONENTS; DO NOT
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 15 PUMP COMPONENTS 1 . Pump – The MQ Model QP4TE is a 4-inch trash pump used in general de-water ing applications. Typicaldewatering applications consist of manholes, septic tanks,fast and slow seepage ditch water, silt water, mud waterand muck wa...
Page 16 - BASIC ENGINE
PAGE 16 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) BASIC ENGINE Figure 3. Engine Controls and Components INITIAL SERVICING The engine (Figure 3) must be checked for proper lubrication andfilled with fuel prior to operation. Refer to the ROBIN engine service manual for instructions and details ...
Page 17 - CAUTION - Read Manual; Adding fuel to the tank; attempt to start the engine; DANGER - Explosive Fuel
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 17 PRE-INSPECTION (ENGINE) Figure 4. Engine Oil Dipstick (Removal) Figure 5. Engine Oil Dipstick (Oil Level) 1. Clean the pump, removing dirt and dust, particularly theengine cooling air inlet, carburetor and air cleaner. 2. Check the air filter f...
Page 18 - CAUTION - Pump Casing; discharge; CAUTION - Flammable Fluids
PAGE 18 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PRE-SETUP (PUMP) Before Starting 1. Read safety instructions at thebeginning of manual. 2. Place pump as near to water as possible, on a firm flat, level surface. 3. To prime pump, remove fill cap (Figure 2) and fill pump casing with water. If...
Page 20 - full speed; CAUTI
PAGE 20 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) INITIAL START-UP (ENGINE) 6. Grasp the starter grip (Figure 11) and slowly pull it out. The resistance becomes the hardest at a certain position, corre-sponding to the compression point. Pull the starter grip brisklyand smoothly for starting. ...
Page 21 - attempt to start the engine unless the pump has; primed; with water. Severe pump damage; CAUTION - Priming Pump
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 21 MAINTENANCE (PUMP) To perform the pump vacuum test do the following: 1. Remove the pump fill cap (Figure 2), and fill the pump with water. 2. Start the engine as outlined in the initial start-up section, and wait for the pump to begin pumping. ...
Page 25 - PREPARATION FOR LONG -TERM STORAGE; Pump Storage; Drain the fuel tank completely.
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 25 PREPARATION FOR LONG -TERM STORAGE Pump Storage For storage of the pump for over 30 days, the following isrequired: z Drain the fuel tank completely. z Run the engine until the fuel in the injection system iscompletely consumed . z Completely d...
Page 28 - EXPLANATION OF CODE IN REMARKS COLUMN
PAGE 28 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) EXPLANATION OF CODE IN REMARKS COLUMN The contents and part numbers listed in the parts section aresubject to change without notice . Multiquip does not guarantee the availability of the parts listed. When ordering a part that has more than on...
Page 29 - SUGGESTED SPARE PARTS
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 29 QP4TE 1 TO 5 UNITS WITH ROBIN EX270D50021 ENGINE Qty. ..... P/N ......................... Description 1 ......... 0811885433 ............ MECHANICAL SEAL SLEEVE1 ......... 1470040030 ............ IMPELLER1 ......... 1401350350 ............ CHEC...
Page 33 - CAP
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 33 PUMP ASSY. PUMP ASSY. NO. PART NO. PART NAME QTY. REMARKS 40 4334201240 IMPELLER WASHER, F42XF12 T4.5 1 41 0458220070 SEAL WASHER, 3/8" (CASING COVER ) 4 42 0205450100 NUT, M10 (ENGINE) 4 43 0205450100 NUT, M10 (CUSHION RUBBER) 8 44 0205450...
Page 37 - RELEASE LEVER
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 37 ROBIN EX270D50220 ENGINE — CAMSHAFT ASSY. CAMSHAFT ASSY. NO. PART NO. PART NAME QTY. REMARKS 10 2793160101 CAMSHAFT CP .......................................... 1 ............. INCLUDES ITEMS W/ * 25 2773510103 PIN, CAMSHAFT, 9DX78.5L 1 27 024...
Page 41 - BALL BEARING
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 41 ROBIN EX270D50220 ENGINE — CRANKCASE ASSY. CRANKCASE ASSY. NO PART NO PART NAME QTY. REMARKS 10 2791010221 CRANKCASE CP, W/ OIL SENSOR ................................ 1 .......... INCLUDES ITEMS W/ * 30 * 0440300160 OIL SEAL, 28.8DX45DX7T 1 40...
Page 42 - ROBIN EX270D50220 ENGINE — CRANKSHAFT/PISTON ASSY.
PAGE 42 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) ROBIN EX270D50220 ENGINE — CRANKSHAFT/PISTON ASSY. CRANKSHAFT, PISTON ASSY.
Page 43 - PART NO; CRANKSHAFT CP
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 43 ROBIN EX270D50220 ENGINE — CRANKSHAFT/PISTON ASSY. CRANKSHAFT, PISTON ASSY. NO PART NO PART NAME QTY. REMARKS 10 2792090111 CRANKSHAFT CP 1 50 0180180010 FLANGE NUT, M18X31DX14H 1 70 0323030010 WOODRUFF KEY, 3BX6HX16D 1 310 2792250120 CONNECTIN...
Page 45 - SPRING RETAINER
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 45 ROBIN EX270D50220 ENGINE — CYLINDER HEAD ASSY. CYLINDER HEAD ASSY. NO. PART NO. PART NAME QTY. REMARKS 20# 2371420203 VALVE GUIDE,5.5DX9.5DX27L 2 26# 2771601001 STEM SEAL, 5DX11.6DX15DX7.8T 1 30 2793360103 VALVE SPRING, 17DX2.3DX27L N=5.8 2 40 ...
Page 47 - FUEL TANK CAP CP
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 47 ROBIN EX270D50220 ENGINE — FUEL TANK ASSY. FUEL TANK ASSY. NO. PART NO. PART NAME QTY. REMARKS 10 2796010211 FUEL TANK CP., 3.6L BLACK 1 20 0732005180 LABEL, WARNING 1 23 2799510103 LABEL, MODEL 1 30 0430440050 FUEL TANK CAP CP 1 40 0641360010 ...
Page 50 - ROBIN EX270D50220 ENGINE — IGNITION COIL/FLYWHEEL ASSY.
PAGE 50 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) ROBIN EX270D50220 ENGINE — IGNITION COIL/FLYWHEEL ASSY. IGNITION/FLYWHEEL ASSY.
Page 51 - IGNITION COIL CP
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 51 ROBIN EX270D50220 ENGINE — IGNITION COIL/FLYWHEEL ASSY. IGNITION/FLYWHEEL ASSY. NO PART NO PART NAME QTY. REMARKS 10 2797923001 FLYWHEEL CP, 15W, 40W CHARGING 1 11 2797943001 IGNITION COIL CP 1 30 0011406250 BOLT & WASHER ASSY. 2 50 2777310...
Page 55 - OIL SENSOR CP
OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 55 ROBIN EX270D50220 ENGINE — OIL SENSOR ASSY. OIL SENSOR ASSY. NO PART NO PART NAME QTY. REMARKS 700 2797630121 OIL SENSOR CP 1 740 0011406160 BOLT AND WASHER ASSY 2 770 2077500101 CLAMP CP 1
Page 58 - TERMS AND CONDITIONS OF SALE — PARTS
PAGE 58 —OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAYMENT TERMS Terms of payment for parts are net 30 days. FREIGHT POLICY All parts orders will be shipped collect orprepaid with the charges added to the invoice.All shipments are F.O.B. point of origin.Multiquip’s responsibility ceases when a...
Page 60 - OPERATION AND PARTS MANUAL; Your Local Dealer is:; HERE’S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL; UNITED STATES
OPERATION AND PARTS MANUAL Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING © COPYRIGHT 2008, MULTIQUIP INC. Multiquip Inc, the MQ logo are registered trademarks of Multiquip Inc. and may not be used, reproduced, or altered without written per...
