Page 2 - Diesel engine exhaust and some of
PAGE 2 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) Diesel engine exhaust and some of
Page 4 - NOTE; QP3TY Trash Pump; QP3TY — TABLE OF CONTENTS; Yanmar L70EE-D Engine; Terms and Condition Of Sale
PAGE 4 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) Specification and part number are subject to change without notice . NOTE QP3TY Trash Pump Here’s How To Get Help ............................................ 3Table of Contents .................................................
Page 5 - PARTS ORDERING PROCEDURES; Ordering parts has never been easier!; Choose from three easy options:; Order via Internet; Order; Order via Fax
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 5 PARTS ORDERING PROCEDURES www .multiquip .com Ordering parts has never been easier! Choose from three easy options: WE ACCEPT ALL MAJOR CREDIT CARDS! When ordering parts, please supply: R Dealer Account Number R Dealer Name ...
Page 6 - QP3TY — SAFETY MESSAGE ALERT SYMBOLS
PAGE 6 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) QP3TY — SAFETY MESSAGE ALERT SYMBOLS Safety precautions should be followed at all times when operatingthis equipment. Failure to read and understand the SafetyMessages and Operating Instructions could result in injury toyour...
Page 7 - Accidental Starting; QP3TY — SAFETY MESSAGE ALERT SYMBOLS; place the engine ON/OFF switch in; OFF; position when the pump is not in use.; Respiratory Hazard; A LWAY S; w e a r a p p r o ve d r e s p i r a t o r y; Equipment Damage Messages; ALWAYS; wear approved eye and hearing; Sight and Hearing hazard
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 7 Accidental Starting QP3TY — SAFETY MESSAGE ALERT SYMBOLS ALWAYS place the engine ON/OFF switch in the OFF position when the pump is not in use. Respiratory Hazard A LWAY S w e a r a p p r o ve d r e s p i r a t o r y protect...
Page 8 - RULES FOR SAFE OPERATION; Refer to the; Engine Owner's Manual; for engine technical; DANGER
PAGE 8 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) RULES FOR SAFE OPERATION ■ ALWAYS refuel in a well-ventilated area, away from sparks and open flames. ■ ALWAYS use extreme caution when working with flammable liquids. When refueling, stop the engine and allow it to cool. DO...
Page 9 - Maintenance Safety
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 9 ■ High Temperatures – Always stop engine and allow the engine to cool before adding fuel, oil or performing serviceand maintenance functions. Contact with hot components can cause serious burns. ■ NEVER disconnect any "e...
Page 10 - Figure 1. QP3TY Dimensions
PAGE 10 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) QP3TY — SPECIFICATIONS/DIMENSIONS (PUMP) Figure 1. QP3TY Dimensions ) p m u P ( s n o i t a c i f i c e p S . 1 e l b a T p m u P l e d o M Y T 3 - P Q e p y T p m u P h s a r T e z i S e g r a h c s i D & n o it c u S ...
Page 11 - US GALLONS PER MINUTE
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 11 QP3TY — SPECIFICATIONS (ENGINE) Table 2 . Eng i ne S pe ci f ic at i on s (YAN M AR) E ngine Ma k e Y ANMAR E ngine M o de l L-70EE-D E ngine Typ e Air -cool ed 4-cycl e D iese l E ngine Cyl inder Bo re X S t r ok e 3. 07 x...
Page 12 - QP3TY — GENERAL INFORMATION
PAGE 12 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) QP3TY — GENERAL INFORMATION APPLICATION The QP3TY Trash Pump is designed to be used for dewatering applications. Both the suction and discharge ports on the QP3TYtrash pump use a 3-inch diameter opening, which allows thepum...
Page 13 - amounts of sand and foreign debris.; QP3TY — PUMP COMPONENTS
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 13 Figure 2 shows a typical application using the QP3TY Trash pump. Please note that this pump is intended for the removal of cleanwater and water containing some debris and solids. Maximum size of solids should not exceed 1.5...
Page 14 - Figure 3. Pump Refueling; QP3TY — REFUELING; PLASTIC; cool down. In the event of a fuel spill,; DO NOT; attempt to start the; REMOVE; pump from truck bed and place on; fire; or; explosion
PAGE 14 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) Figure 3. Pump Refueling QP3TY — REFUELING PLASTIC TRUCK-BED LINER DO NOT ADD FUEL TO TRASH PUMP IF TRASH PUMP IS PLACED INSIDE TRUCK-BED WITH PLASTIC LINER. POSSIBILITY EXISTS OF EXPLOSION OR FIRE DUE TO . STATIC ELECTRICI...
Page 15 - QP3TY — BASIC ENGINE
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 15 QP3TY — BASIC ENGINE ENGINE COMPONENTS Figure 4 illustrates the location of the major components of theengine. Each component is described below: 1 . Fuel Filler Cap – Remove this cap to add diesel fuel to the fuel tank. Ma...
Page 17 - discharge; must; collapsible
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 17 Before Starting 1. Read safety instructions at thebeginning of manual. 2. Place pump as near to water as possible, on a firm flat, level surface. 3. To prime pump, remove fill cap (Figure 2) and fill pump casing with water....
Page 18 - run engine at; full speed
PAGE 18 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) QP3TY — INITIAL START-UP (ENGINE) DO NOT attempt to operate the pump until the Safety, General Information andInspection sections of this manual haveb e e n r e a d a n d t h o r o u g h l y understood . This section is int...
Page 19 - CAUTI; Emergency Shutdown
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 19 QP3TY — INITIAL START-UP (ENGINE) Stopping The Engine Normal Shutdown 1. Move the engine speed lever to the low speed and run the engine for about three minutes with no load. 2. After the engine cools, move the engine speed...
Page 24 - QP3TY — PREPARATION FOR LONG -TERM STORAGE; Pump Storage; Drain the fuel tank completely.; when it feels tight. This closes the intake and
PAGE 24 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) QP3TY — PREPARATION FOR LONG -TERM STORAGE Pump Storage For storage of the pump for over 30 days, the following isrequired: Drain the fuel tank completely. Run the engine for about 3 minutes and then stop . Stop the e...
Page 25 - NOTE PAGE
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 25 NOTE PAGE
Page 28 - QP3TY — EXPLANATION OF CODE IN REMARKS COLUMN; SAMPLE PARTS LIST; REMARKS Column
PAGE 28 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) QP3TY — EXPLANATION OF CODE IN REMARKS COLUMN The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there are...
Page 29 - QP3TY — SUGGESTED SPARE PARTS
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 29 QP3TY — SUGGESTED SPARE PARTS QP3TY TRASH PUMP 1 TO 3 UNITSW/ YANMAR L48EE-D Qty. P/N Description 2 ............ KIT3T .................... KIT, MECHANICAL SEAL, O-RINGS1 ............ 1992040032 .......... IMPELLER2 ..........
Page 36 - — See Cylinder Block Assy Drawing
PAGE 36 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) YANMAR L70EE-D — CYLINDER HEAD & COVER ASSY. CYLINDER HEAD & COVER ASSY. 1 — See Cylinder Block Assy Drawing
Page 38 - — See Cylinder Head and Cover Assy Drawing
PAGE 38 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) YANMAR L70EE-D — AIR CLEANER ASSY. AIR CLEANER ASSY. 2 — See Cylinder Head and Cover Assy Drawing
Page 39 - WING
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 39 YANMAR L70EE-D — AIR CLEANER ASSY. AIR CLEANER ASSY. NO. PART NO. PART NAME QTY. REMARKS 1 11425012211 GASKET, AIR CLEANER 1 2 71425012560 CLEANER ASSY, AIR ......................................... 1 ............. INCLUDES...
Page 41 - MUFFLER ASSY
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 41 YANMAR L70EE-D — MUFFLER ASSY. MUFFLER ASSY. NO. PART NO. PART NAME QTY. REMARKS 1 11425013201 GASKET (NON — ASB.) 1 2 11487013551 MUFFLER ASSY 1 8 26106060122 BOLT M 6X 12 PLATED 2 9 26216080182 STUD M 8X 18 PLATED 2 10 26...
Page 43 - TAPPET
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 43 YANMAR L70EE-D — CRANKSHAFT, PISTON & CAMSHAFT ASSY. CRANKSHAFT, PISTON & CAMSHAFT ASSY. NO. PART NO. PART NAME QTY. REMARKS 1 71488014580 CAMSHAFT (D) ASSY 1 6 11425014200 TAPPET 2 7 11477114260 TAPPET, F.O. 1 8 11...
Page 48 - YANMAR L70EE-D — FUEL INJECTION PUMP ASSY.; FUEL INJECTION PUMP ASSY.
PAGE 48 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) YANMAR L70EE-D — FUEL INJECTION PUMP ASSY. FUEL INJECTION PUMP ASSY. — See Cylinder Block Assy Drawing 1 — See Cylinder Head and Cover Assy Drawing 2
Page 49 - PART NAME
QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) — PAGE 49 YANMAR L70EE-D — FUEL INJECTION PUMP ASSY. FUEL INJECTION PUMP ASSY. NO. PART NO. PART NAME QTY. REMARKS 1 71465051100 PUMP ASSY, F. INJECT. ................................ 1 ................. INCLUDES ITEMS W/ * 2 * 10554...
Page 50 - — See Fuel Injection Pump Assy Drawing
PAGE 50 — QP3TY TRASH PUMP — OPERATION AND PARTS MANUAL — REV. #2 (11/15/10) YANMAR L70EE-D — FUEL TANK & FUEL LINE ASSY. — See Fuel Injection Pump Assy Drawing 8
Page 56 - OPERATION AND PARTS MANUAL; Your Local Dealer is:; HERE’S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL; UNITED STATES; CANADA
OPERATION AND PARTS MANUAL Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND W HEN CALLING © COPYRIGHT 2010, MULTIQUIP INC. Multiquip Inc and the MQ logo are registered trademarks of Multiquip Inc. and may not be used, reproduced, or altered without written...
