Page 3 - HERE'S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 3 HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING MULTIQUIP’S MAIN PHONE NUMBERS 800-421-1244 FAX: 310-537-3927 310-537-3700 PARTS DEPARTMENT 800-427-1244 FAX: 800-672-7877 ...
Page 4 - TABLE OF CONTENTS; S p e c i f i c a t i o n a n d p a r t; NOTE; PARTS ILLUSTRATIONS
PAGE 4 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) TABLE OF CONTENTS S p e c i f i c a t i o n a n d p a r t n u m b e r a r e s u b j e c t t o change without notice . MQ MIKASA MVH-702DRSC-REVERSIBLE PLATECOMPACTOR Proposition 65 Warning .....................
Page 5 - PARTS ORDERING PROCEDURES; please supply the following information:; Direct TOLL-FREE access
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 5 PARTS ORDERING PROCEDURES When ordering parts, please supply the following information: ❒ ❒ ❒ ❒ ❒ Dealer account number ❒ ❒ ❒ ❒ ❒ Dealer name and address ❒ ❒ ❒ ❒ ❒ Shipping address (if different than billing...
Page 6 - MVH-702DRSC — SAFETY MESSAGE ALERT SYMBOLS
PAGE 6 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — SAFETY MESSAGE ALERT SYMBOLS Safety precautions should be followed at all times whenoperating this equipment. Failure to read and understand theSafety Messages and Operating Instructions could ...
Page 7 - Accidental Starting; Respiratory Hazard; Equipment Damage Messages; Sight and Hearing hazard
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 7 Accidental Starting MVH-702DRSC — SAFETY MESSAGE ALERT SYMBOLS ALWAYS place the engine ON/OFF switch in the OFF position, when the compactor is not in use. Respiratory Hazard A LWAY S w e a r a p p r o ve d ...
Page 8 - MVH-702DRSC — RULES FOR SAFE OPERATION
PAGE 8 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — RULES FOR SAFE OPERATION ■ ALWAYS refuel in a well-ventilated area, away from sparks and open flames. ■ ALWAYS use extreme caution when working with flammable liquids. When refueling, stop the ...
Page 9 - Emergencies
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 9 MVH-702DRSC — RULES FOR SAFE OPERATION ■ ALWAYS use extreme care when operating near obstructions, on slippery surfaces, grades and side slopes. ■ When reversing, particularly on the edges and banks ofditche...
Page 10 - MVH-702DRSC — OPERATION AND SAFETY DECALS; Figure 1a. Operation and Safety Decals; MAIN SWITCH; Shell Tellus Oil; CAUTION
PAGE 10 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — OPERATION AND SAFETY DECALS Figure 1a. Operation and Safety Decals Figure 1 displays the operation and safety decals as they appear on the compactor. Should any of these decals become damagedo...
Page 11 - Figure 1b. Operation and Safety Decals; DIESEL; OPEN; OH RE OP NR; HYDRAULIC
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 11 MVH-702DRSC — OPERATION AND SAFETY DECALS Figure 1 displays the operation and safety decals as they appear on the compactor. Should any of these decals become damagedor unreadable, contact the Multiquip Par...
Page 12 - Figure 2. MVH-702DRSC Compactor Dimensions; MVH-702DRSC — DIMENSIONS AND SPECIFICATIONS
PAGE 12 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) Figure 2. MVH-702DRSC Compactor Dimensions s n o i t a c i f i c e p S r o t c a p m o C C S R D 2 0 7 - H V M . 1 e l b a T r a l u g e R h ti W e t a l P h c n i- 3 h ti W e t a l P n o i s n e t x E s n ...
Page 13 - MVH-702DRSC — FEATURES
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 13 MVH-702DRSC — FEATURES The Mikasa Model MVH-702DRSC is a Reversible PlateCompactor which operates by infra-red remote control withforward-reverse motion, steering, and stepless speed controlby single-lever ...
Page 14 - MVH-702DRSC — COMPACTOR COMPONENTS; Figure 3. MVH-702DRSC Compactor Components
PAGE 14 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — COMPACTOR COMPONENTS Figure 3. MVH-702DRSC Compactor Components 4 5 1 3 7 9 11 10 6 14 13 12
Page 16 - MVH-702DRSC — REMOTE CONTROL COMPONENTS; Figure 4. MVH-702DRSC Remote Control Components
PAGE 16 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — REMOTE CONTROL COMPONENTS Figure 4. MVH-702DRSC Remote Control Components 10 1 2 3 4 7 8 5 9 6
Page 17 - MONITOR LAMP
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 17 MVH-702DRSC — REMOTE CONTROL COMPONENTS CONTROL UNIT (BODY) Figure 4 illustrates the location of the major components for theRemote Control on the body of the machine. The function ofeach component is descr...
Page 18 - Figure 7. MVH-702DRSC Transmitter Components
PAGE 18 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — REMOTE CONTROL COMPONENTS Figure 7. MVH-702DRSC Transmitter Components 12 1 2 3 4 5 6 8 7 9 10 11
Page 20 - SETTING THE OPERATIONAL CHANNEL
PAGE 20 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — BEFORE START-UP BEFORE START-UP 1. Read this manual carefully and understand all functions ofthe machine before start-up. 2. The engine is located on front side of the machine and thealuminum ...
Page 21 - MVH-702DRSC — BATTERY CHARGING
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 21 MVH-702DRSC — BATTERY CHARGING CHARGING THE BATTERY The battery can be charged in three different ways: Using the remote cable Using the AC plug-in battery charger Solar Energy Battery Charging Using Remote...
Page 22 - MVH-702DRSC — OPERATION
PAGE 22 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — OPERATION BEFORE OPERATION 1. Familiarize yourself with the operating and control elementsof the machine and the working environment. This includesobstacles in the working area, bearing capaci...
Page 23 - MVH-702DRSC — OPERATION
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 23 MVH-702DRSC — OPERATION Refer to Figures 4 and 7 for the location of controls andcomponents . STARTING THE ENGINE 1. Move the cell/crank start switch of the machine to the cellstart position. 2. Move the ma...
Page 24 - MVH-702DRSC — LOADING AND UNLOADING GUIDELINES; LIFTING; TRANSPORTING
PAGE 24 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — LOADING AND UNLOADING GUIDELINES LIFTING 1. Use a crane or lift to load and unload the machine. Askilled crane operator is required to perform the job. 2. When lifting the machine, check for a...
Page 25 - MVH-702DRSC — MAINTENANCE; Figure 16. Battery Location
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 25 MACHINE MAINTENANCE 1. At the end of each day’s operation, wipe off any dust fromthe transmitter and the receiver on the body of the machine. 2. At the end of each day’s operation, charge the transmitterbat...
Page 26 - MVH-702DRSC — TROUBLESHOOTING; il
PAGE 26 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — TROUBLESHOOTING t r a h C n o i t a c il p p A li O C S R D 2 0 7 - H V M . 3 e l b a T M E T I N O I T A C O L E C I V R E S N O I T A C I F I S S A L C ) C ° / F ° ( E R U T A R E P M E T T ...
Page 30 - MVH-702DRSC — BLOCK DIAGRAM; Figure 17. Block Diagram
PAGE 30 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — BLOCK DIAGRAM Figure 17. Block Diagram
Page 31 - MVH-702DRSC — RECIEVER WIRING DIAGRAM; Figure 18. Receiver Wiring Diagram
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 31 MVH-702DRSC — RECIEVER WIRING DIAGRAM Figure 18. Receiver Wiring Diagram
Page 32 - MVH-702DRSC — VALVE CONTROL DIAGRAM; Figure 19. Valve Control Diagram
PAGE 32 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC — VALVE CONTROL DIAGRAM Figure 19. Valve Control Diagram
Page 33 - NOTE PAGE
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 33 NOTE PAGE
Page 34 - Items Found In the “Remarks” Column; Items Found In the “Items Number” Column; MVH-702DRSC — EXPLANATION OF CODE IN REMARKS COLUMN
PAGE 34 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) How to read the marks and remarks used in this partsbook. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serialnumber range (inclusive) where a particular part is used....
Page 35 - MVH-702DRSC — SUGGESTED SPARE PARTS
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 35 MQ MIKASA MVH-702DRSC REVERSIBLEPLATE COMPACTOR 1 to 3 Units Qty. P/N Description 3 .......... 954001910 ........... OIL FILTER, HYDRAULIC3 .......... 954001920 ........... SUCTION, OIL FILTER HYDRAULIC1 .....
Page 36 - MVH-702DRSC COMPACTOR — NAMEPLATE AND DECALS; NAMEPLATE AND DECALS
PAGE 36 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC COMPACTOR — NAMEPLATE AND DECALS NAMEPLATE AND DECALS
Page 37 - PART NAME; MIKASA MARK 200MM DECAL
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 37 MVH-702DRSC COMPACTOR — NAMEPLATE AND DECALS NAMEPLATE AND DECALS NO. PART NO. PART NAME QTY. REMARKS 1 920109840 MODEL- MVH- 702 (350) DECAL 1 2 920109550 MODEL- MVH- 702 DECAL 2 3 920209080 CONTROLLER MVH...
Page 38 - MVH-702DRSC COMPACTOR — VIBRATING PLATE ASSY.; VIBRATING PLATE ASSY.
PAGE 38 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC COMPACTOR — VIBRATING PLATE ASSY. VIBRATING PLATE ASSY.
Page 39 - VIBRATING PLATE
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 39 VIBRATING PLATE ASSY. NO. PART NO. PART NAME QTY. REMARKS 1 462116380 VIBRATING PLATE 1 2 953405840 DRAIN PLUG M18(H) 1 3 953402930 COPPER PACKING 19 X30 X1 1 4 953400270 PLUG 1/4X14 10L 1 5 953405260 PACKI...
Page 48 - MVH-702DRSC COMPACTOR — HYDRAULIC SYSTEM ASSY.; HYDRAULIC SYSTEM ASSY.
PAGE 48 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC COMPACTOR — HYDRAULIC SYSTEM ASSY. HYDRAULIC SYSTEM ASSY.
Page 51 - SUB OIL TANK BASE
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 51 HYDRAULIC SYSTEM ASSY. NO. PART NO. PART NAME QTY. REMARKS 50 462116450 SUB OIL TANK BASE 1 51 551010530 ADAPTER 1/2 1009- 08 3 52 001521025 SOCKET HEAD BOLT 10X25 T 4 53 050101200 O-RING G- 120 1 54 954002...
Page 52 - MVH-702DRSC COMPACTOR — ELECTRIC DEVICE ASSY.; ELECTRIC DEVICE ASSY.
PAGE 52 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) MVH-702DRSC COMPACTOR — ELECTRIC DEVICE ASSY. ELECTRIC DEVICE ASSY.
Page 55 - TRANSMITTER
MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) — PAGE 55 ELECTRIC DEVICE ASSY. NO. PART NO. PART NAME QTY. REMARKS 51 462340480 HARNESS (PS) 1 52 462340510 HARNESS (LED, F. LAMP) 1 53 462340470 HARNESS (HOUR METER) 1 54 462340460 HARNESS (MAGNET VALVE) 1 55 46234...
Page 56 - TERMS AND CONDITIONS OF SALE — PARTS
PAGE 56 — MQ-MIKASA MVH-702DRSC COMPACTOR — PARTS & OPERATION MANUAL — REV. #1 (12/17/03) Effective: October 1, 2002 TERMS AND CONDITIONS OF SALE — PARTS PAYMENT TERMS Terms of payment for parts are net 10 days. FREIGHT POLICY All parts orders will be shipped collect orprepaid with the charges a...
Page 58 - OPERATION AND PARTS MANUAL
MULTIQUIP INC. POST OFFICE BOX 6254CARSON, CA 90749310-537-3700 • 800-421-1244FAX: 310-537-3927E-MAIL: [email protected]: multiquip.com Atlanta • Boise • Dallas • Houston • Newark Quebec, Canada • Manchester, UK • Rio De Janiero, BR • Guadalajara, MX manufactured for Multiquip Inc. by MIKASA SANGY...
