Page 2 - page 2 — ga6HB/ga6HeB; Table of ConTenTs; Ga6Hb/Ga6Heb Portable; Component Drawings; NOTICE
page 2 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) Table of ConTenTs Ga6Hb/Ga6Heb Portable 60 Hz Generator Table Of Contents .................................................... 3 Safety Information ................................................ 4-8 Specificatio...
Page 3 - PaRTs oRDeRinG PRoCeDuRes; ordering parts has never been easier!; Choose from three easy options:; WE ACCEpT All mAJOR CREdiT CARds!; Order via internet; Order; internet; Order via Fax; Fax
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 3 PaRTs oRDeRinG PRoCeDuRes www .multiquip .com ordering parts has never been easier! Choose from three easy options: WE ACCEpT All mAJOR CREdiT CARds! when ordering parts, please supply: ❒ dealer Account Number ❒ de...
Page 4 - safeTy infoRmaTion; sAFETY mEssAgEs; dANgER
pAgE 4 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) safeTy infoRmaTion Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the saf...
Page 5 - gENERAl sAFETY; gENERATOR sAFETY
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 5 safeTy infoRmaTion gENERAl sAFETY CAuTiON NEvER operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective d...
Page 6 - page 6 — ga6HB/ga6HeB; ENgiNE sAFETY; FuEl sAFETY
page 6 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) safeTy infoRmaTion ENgiNE sAFETY dANgER The engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. The engine of this equipment require...
Page 7 - ElECTRiCAl sAFETY; power Cord/Cable safety; grounding safety
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 7 safeTy infoRmaTion NEvER use fuel as a cleaning agent. dO NOT s m o ke a r o u n d o r n e a r t h e equipment. Fire or explosion could result from fuel vapors or if fuel is spilled on a hot engine. ElECTRiCAl ...
Page 8 - page 8 — ga6HB/ga6HeB; TRANspORTiNg sAFETY; ENviRONmENTAl sAFETY/dECOmmissiONiNg
page 8 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) safeTy infoRmaTion If the battery liquid (dilute sulfuric acid) comes into contact with clothing or skin , rinse skin or clothing immediately with plenty of water. If the battery liquid (dilute sulfuric acid) ...
Page 9 - EmissiONs iNFORmATiON; Emission Control label
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 9 EmissiONs iNFORmATiON NOTICE The gasoline engine used in this equipment has been designed to reduce harmful levels of carbon monoxide (CO), hydrocarbons (HC) and nitrogen oxides (NOx) contained in gasoline exhaust ...
Page 11 - Effects of Altitude and heat
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 11 Table 2. specifications (Engine) Engine model hONdA gX340R2EdN2 hONdA gX340R2EdE2 Type Air-cooled 4 stroke, Single Cylinder, OHV, Horizontal Shaft Gasoline Engine Bore X Stroke 3.46 in. X 2.52 in. (88 mm x 64 mm.)...
Page 12 - Dimensions; Table 3. generator dimensions; LENGTH
pAgE 12 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) Dimensions Figure 1. Dimensions 120/240V 30A 0N OFF IDLE CONTROL OPERATION SWITCH ON OFF 120 V GA-6HB 120 20A 120 30A AC CIRCUIT BREAKER GFCI PROTECTED 120 AC VOLTMETER 120V FULL POWER SWITCH 120V 120V/240V MANUA...
Page 13 - noTe
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 13 noTe
Page 14 - insTallaTion; CONNECTiNg ThE gROuNd; The nut and ground terminal on the generator should always; Figure 2. Generator Grounding
pAgE 14 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) insTallaTion CONNECTiNg ThE gROuNd The nut and ground terminal on the generator should always be used to connect the generator to a suitable ground. The ground cable should be #8 size wire (aluminum) minimum. If ...
Page 15 - OuTdOOR iNsTAllATiON; DO NOT; gENERATOR gROuNdiNg; eaRTH; AlWAYs
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 15 insTallaTion OuTdOOR iNsTAllATiON If possible install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slid...
Page 16 - GeneRal infoRmaTion; FAmiliARizATiON
pAgE 16 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) GeneRal infoRmaTion FAmiliARizATiON generator The Multiquip GA6HB/GA6HEB generator is designed as a portable dual purpose power source for 60 Hz (single phase) lighting facilities, power tools, submersible pumps ...
Page 17 - Figure 3. Generator Components
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 17 ComPonenTs (GeneRaToR) 120/240V 30A 0N OFF IDLE CONTROL OPERATION SWITCH ON OFF 120 V GA-6HB 120 20A 120 30A AC CIRCUIT BREAKER GFCI PROTECTED 120 AC VOLTMETER 120V FULL POWER SWITCH 120V 120V/240V MANUAL RESET P ...
Page 18 - Figure 4. Full Power Switch; Full power switch –; dO NOT
pAgE 18 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) Figure 4. Full Power Switch 120/240V 30A 0N OFF IDLE CONTROL OPERATION SWITCH ON OFF 120 V GA-6HB 120 20A 120 30A AC CIRCUIT BREAKER GFCI PROTECTED 120 AC VOLTMETER 120V FULL POWER SWITCH 120V 120V/240V MANUAL RE...
Page 19 - NOT
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 19 Figure 7. Generator Components (Continued) 16 17 19 20 22 23 24 25 26 GA-6H 21 18 GA-6H ComPonenTs (GeneRaToR) 16. Fuel gauge – This gauge is located on top of the fuel tank. Read this gauge to determine when fuel...
Page 20 - Current in; : Equipment damage can result from low voltage.
page 20 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) insPeCTion/seTuP gENERAl iNspECTiON pRiOR TO OpERATiON ground power Tools When using power tools or electrical equipment requiring AC power from the generator, make sure power tool cord has a ground pin or is dou...
Page 21 - Figure 9. Engine Oil Dipstick Removal; Fuel Check; Figure 11. Fuel Gauge
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 21 insPeCTion/seTuP Before starting 1. Read safety instructions at the beginning of manual.2. Clean the generator, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3. Che...
Page 22 - oPeRaTion; Before starting the Engine; NEvER; Figure 14. Choke Lever; OpeN; Figure 16. Starter Grip
page 22 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) oPeRaTion This section is intended to assist the operator with the initial start-up of the portable generator. It is extremely important that this section be read carefully before attempting to use the generator ...
Page 24 - Emergency shutdown
pAgE 24 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) oPeRaTion/sHuTDown 12. Read voltmeter on front panel of generator (Figure 22) and verify that 240 VAC is displayed. Using an external voltmeter as shown in Figure 22, verify that 240 VAC is present at the 120/240...
Page 25 - generator storage; PRePaRaTion foR lonG TeRm sToRaGe
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 25 generator storage For storage of the generating set for over 30 days, the following is required: Drain the fuel tank completely, or add STA-BIL to the fuel. Run the engine until the gasoline in the carburetor ...
Page 26 - mainTenanCe; Use Table 6 as a general maintenance guideline when; Table 6. Engine maintenance schedule; REPLACE; dusTY
page 26 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) mainTenanCe Use Table 6 as a general maintenance guideline when servicing your engine. For more detail engine maintenance information, refer to the engine owner's manual supplied with your engine. Table 6. Engine...
Page 27 - Figure 27. Fuel Strainer; Figure 29. Draining Engine Oil
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 27 mainTenanCe mAiNTENANCE Perform the scheduled maintenance procedures as defined by Table 5 and below: daily Thoroughly remove dirt and oil from the engine and control area. Clean or replace the air cleaner element...
Page 28 - ENgiNE AiR ClEANER; Figure 30. Engine Air Cleaner; spARk ARREsTER ClEANiNg; Figure 32. Spark Arrester Removal
page 28 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) ENgiNE AiR ClEANER 1. Remove the air cleaner cover and foam filter element as shown in Figure 30. 2. Clean foam element in war m, soapy water or nonflammable solvent. Rinse and dry thoroughly. Dip the element in ...
Page 29 - BATTERY CABlE iNsTAllATiON; red; Figure 34. Battery Connections; pOlARiTY; main
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 29 BATTERY (gA6hEB) This unit is of negative ground dO NOT connect in reverse. Always maintain battery fluid level between the specified marks. Battery life will be shortened, if the fluid levels are not properly mai...
Page 30 - green
pAgE 30 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) 3. On the GFCI module (Figure 36), verify that the green POWER LED is ON . Figure 36. GFCI Module (Green LED ON) 4. Also verify that the AC voltmeter is registering a voltage reading as indicated by Figure 41. 5....
Page 31 - noTes
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 31 noTes
Page 32 - GENERATOR
pAgE 32 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) GeneRaToR wiRinG DiaGRam (Ga6Hb) Figure 42. Generator Wiring Diagram (GA6HB) CONNECTOR ARRANGEMENT (VIEW FROM INSERTING WIRE SIDE) 2 1 4 3 W R CN1 CN2 1 2 CN5 CN4 Ar Fg-P, N Ex W1 ARMATURE WINDING ROTOR ASSEMBLY ...
Page 38 - eXPlanaTion of CoDe in RemaRks Column; sAmplE pARTs lisT; pART NAmE; REmARks Column
pAgE 38 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) eXPlanaTion of CoDe in RemaRks Column The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there ...
Page 39 - suGGesTeD sPaRe PaRTs; pORTABlE 60 hz gENERATOR; description
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 39 suGGesTeD sPaRe PaRTs ga6HB/ga6HeB pORTABlE 60 hz gENERATOR W i T h h O N dAg X 3 4 0 R 2 E d N 2 / g X 3 4 0 R 2 E d E 2 gAsOliNE ENgiNEs 1 to 3 units Qty. p/N description 1............0430430120 .......... CAP F...
Page 40 - Ga6Hb/Ga6Heb— namePlaTe anD DeCals assy.; DANGER
pAgE 40 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) Ga6Hb/Ga6Heb— namePlaTe anD DeCals assy. S-1123 To avoid injury,you MUST readand understandoperator’s manualbefore using thismachine. Ask for training as needed. This machine to be operated by qualified personnel...
Page 43 - SURGE ABSORBER
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 43 Ga6Hb/Ga6Heb — GeneRaToR assy. NO. pART NO. pART NAmE QTY. REmARks 1 7901002403 ROTOR ASSY. ...................................................1................INCLUDES ITEMS W/# 1-1# FIELD ASSY .....................
Page 45 - Ga6HbGa6Heb — ConTRol boX assy.
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 45 Ga6HbGa6Heb — ConTRol boX assy. NO. pART NO. pART NAmE QTY. REmARks 1 A3214000103 CONTROL BOX 1 2 0601850102 GROMMET 1 3 0601823204 RECTIFIER S5VB60 2 4 0027103012 MACHINE SCREW 2 5 0601823853 SLOW DOWN UNIT 1 6 0...
Page 47 - Ga6HbGa6Heb — PiPe fRame assy.
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 47 NO. pART NO. pART NAmE QTY. REmARks 1 A5417000702 PIPE FRAME, GA6HB 1 1A A5417000802 PIPE FRAME, GA6HEB 1 2 A3417100004 BRACKET 1 3 0017106015 HEX. HEAD BOLT 4 4 7905443003 BASE 1 5 3015419604 RUBBER SUSPENSION 2 ...
Page 48 - Ga6Heb — baTTeRy assy.
pAgE 48 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) Ga6Heb — baTTeRy assy.
Page 52 - HonDa GX340R2eDe2/eDn2 — aiR CleaneR assy.
page 52 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — aiR CleaneR assy.
Page 56 - HonDa GX340R2eDe2/eDn2 — CaRbuReToR assy.
page 56 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — CaRbuReToR assy.
Page 59 - SPRING, THROTTLE RETURN
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 59 NO. pART NO. pART NAmE QTY. REmARks 1 16550ZE3700 ARM, GOVERNOR 1 3 16555ZE3000 ROD, GOVERNOR 1 4 16561ZK6D70 SPRING, GOVERNOR 1 5 16562ZE3700 SPRING, THROTTLE RETURN 1 8 16570Z5T880 CONTROL ASSY.....................
Page 60 - HonDa GX340R2eDe2/eDn2 — CRankCase CoVeR assy.
page 60 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — CRankCase CoVeR assy.
Page 61 - PACKING CRANKCASE COVER
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 61 NO. pART NO. pART NAmE QTY. REmARks 1 11300ZE3040 COVER ASSY., CRANKCASE ...........................1................INCLUDES ITEMS W/$ 2 11381Z5T000 PACKING CRANKCASE COVER 1 3 15600ZG4003 CAP ASSY., OIL FILLER ....
Page 62 - HonDa GX340R2eDe2/eDn2 — CRanksHafT assy.
page 62 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — CRanksHafT assy.
Page 64 - HonDa GX340R2eDe2/eDn2 — CylinDeR baRRel assy.
pAgE 64 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — CylinDeR baRRel assy.
Page 66 - HonDa GX340R2eDe2/eDn2 — CylinDeR HeaD assy.
page 66 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — CylinDeR HeaD assy.
Page 67 - GASKET, CYLINDER HEAD
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 67 NO. pART NO. pART NAmE QTY. REmARks 1 12210Z5T406 CYLINDER HEAD ..............................................1................INCLUDES ITEMS W/$ 2$ 12204ZE2306 GUIDE, VALVE (OS) (OPTIONAL) 1 3$ 12205ZE2305 GUIDE,...
Page 72 - HonDa GX340R2eDe2/eDn2 — iGniTion Coil assy.
pAgE 72 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — iGniTion Coil assy.
Page 75 - BOLT, CONNECTING ROD
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 75 NO. pART NO. pART NAmE QTY. REmARks 1 13010Z5R004 RING SET, PISTON (STD) 1 1 13011Z5R004 RING SET, PISTON (OS 0.25) (OPTIONAL) 1 1 13012Z5R004 RING SET, PISTON (OS O.50) (OPTIONAL) 1 1 13013Z5R004 RING SET, PISTON...
Page 76 - HonDa GX340R2eDe2/eDn2 — ReCoil sTaRTeR assy.
pAgE 76 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — ReCoil sTaRTeR assy.
Page 77 - PULLEY, RECOIL STARTER
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 77 NO. pART NO. pART NAmE QTY. REmARks 1 28400Z5T305ZB STARTER ASSY., RECOIL *NH1* (BLACK) ......1................INCLUDES ITEMS W/$ ......................................................................................
Page 78 - HonDa GX340R2eDe2 — sTaRTeR moToR assy.
pAgE 78 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2 — sTaRTeR moToR assy.
Page 79 - ARMATURE COMPLETE
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 79 HonDa GX340R2eDe2 — sTaRTeR moToR assy. NO. pART NO. pART NAmE QTY. REmARks 1$ 31204ZA0003 CONTACTOR ASSY. 1 2$ 31206ZE3003 ARMATURE COMPLETE 1 3$ 31207ZE3003 CLUTCH, OVERRUNNING ................................1....
Page 81 - SPRING, CHOKE RETURN
ga6HB/6HeB 60 hz gENERATOR • OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) — pAgE 81 NO. pART NO. pART NAmE QTY. REmARks 1 16268893000 SPRING, CHOKE RETURN 1 2 17850ZD1E30 LEVER, THROTTLE 1 3 36160ZB4013 SOLENOID ASSY. 1 4 90013883000 BOLT, FLANGE (6X12) 1 5 93500050080A SCREW, PAN (5X8) 2 HonDa G...
Page 82 - HonDa GX340R2eDe2/eDn2 — enGine DeCals assy.
page 82 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) HonDa GX340R2eDe2/eDn2 — enGine DeCals assy.
Page 84 - TeRms anD ConDiTions of sale — PaRTs
pAgE 84 — ga6HB/ga6HeB 60 hz gENERATOR• OpERATiON ANd pARTs mANuAl — REv. #0 (03/13/14) TeRms anD ConDiTions of sale — PaRTs pAYmENT TERms Terms of payment for parts are net 30 days. FREighT pOliCY All parts orders will be shipped collect or prepaid with the charges added to the invoice. All shipmen...
Page 86 - OperatiOn and parts Manual; Your Local Dealer is:; HERE’S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL; UNITED STATES; CANADA; UNITED KINGDOM
OperatiOn and parts Manual Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING © COPYRIGHT 2014, MULTIQUIP INC. Multiquip Inc , the MQ logo are registered trademarks of Multiquip Inc. and may not be used, reproduced, or altered without written pe...
